Beruflich Dokumente
Kultur Dokumente
H. TRIM ASSIST
Activate/Deactivate Power Trim Assistant (PTA)
I. TOW MODE
Activate/Deactivate Tow Mode
J. +/- BUTTONS
Used for Tow Mode and Cruise Control
K
K. POWER TRIM BUTTONS
Power Trim up/down
B, C, D
F
J
I
G
H 7” Color Display
Information Display Generic Button Panel Joystick NOTE! If two 7” color displays are
used on one helm station they Repeat steps for additional helm stations
must be configured as SINGLE and
SINGLE SECONDARY (for single
installations) and as TWIN and TWIN
SECONDARY (for twin installations).
A B C D A A A A
A. BACK BUTTON A. BUTTONS A B
Push to step backwards in the menu Button function dependent on software
- Menu structure A. DOCKING BUTTON
Push to enable docking Set language and units
B. MENU NAVIGATION BUTTON function. LED indication IMPORTANT!
Navigate left and up. (red). Activate helm station by pushing the ACTIVE
C. MENU NAVIGATION BUTTON STATION BUTTON on the control lever. Language
Navigate right and down. B. BOOST BUTTON
Push to enable boost In example to the right the Information display
D. ACKNOWLEDGE BUTTON mode. LED indication is used. When using the 7” color display use
Push to acknowledge choice (red). the knob to navigate in the menues and OK to
confirm.
Units
Lever calibration
This applies to top mounted controls, twin instal-
lation.
NOTE! Both levers should be calibrated at the
same time, to give the same lever travel/positions
for both engines.
Powertrim calibration
(Aquamatic)
Joystick calibration
(Electronic Steering)
This calibration only needs to be performed if
the boat movement does not corresponds to the
movement of the joystick
NOTE! Calibration only needs to be done in one
direction, port or starboard, on one helm station.
Reset
Calibration
Toe-in/Toe-out
(Electronic Steering)
The toe-in setting can be adjusted to optimize for
top speed or cruising speed. To select the best
toe-in, each new boat design needs to be tested
with different settings by the boat manufacturer.
Toe adjustments are only efficient above 2500
engine RPMs.
Toe Adjustment increments are 0.1 degree. Each
0.1 degree equals 3 mm of tie-bar length adjust-
ment. Maximum adjustment is ± 2.0 degrees.
Default Toe-in setting is 0 degrees.
Menu system
At power-up Volvo Penta logotype will be shown
on the display. After a few seconds MAIN MENU
will appear.
Navigate MAIN MENU by pressing the naviga-
tion buttons. Push the OK button to aknowledge
selection.
47700917 07-2010
IMPORTANT!
For all setting procedures:
Activate helm station by pushing the ACTIVE STA-
TION BUTTON on the control lever.