Beruflich Dokumente
Kultur Dokumente
US-101-485
USB To Serial Operation Manual
2
HIMAQ S.R.L - Tel.: (011) 4709-3505 - Mail: himaq@himaq.com.ar - WEB: http://www.himaq.com.ar
2
Package checklist
US-101-485 product is shipped with the following items:
NOTE: Notify your sales representative if any of the above items is missing or
damaged
RS-485/4225
● No. of Ports : 422/485 * 1 Port (Terminal Block)
● RS-422 Signals : RxD+ , RxD- , TxD+ , TxD- in Full-duplex (Surge Protection)
● RS-485 Signals : Data+ , Data- in Half-duplex (Surge Protection)
● Receive buffer : 576 Byte
● Transmit buffer : 640 Byte
● Baud Rate Speed : 300 bps〜230.4k bps
● Built-in RS-422/RS-485 Terminal Resister (Surge Protection)
● Connected Serial port type identification : Auto-Detection
● Built in Terminal 100 Ohm Terminal resistor SW selection ON/OFF
● 15KV ESD for all signal
USB Port
No. of Ports : USB * 1 Port
● Chipset : Silicon Laboratories CP2102
● Fully compatible with the USB V1.0, V1.2, V2.0
● USB type A connector
● Baud Rates : Full speed 12 Mbps.
Environment :
● Operating Temperature: 0 〜60
● Storage Temperature : -20 〜85
Humidity: 5-95% RH
Dimensions : 55 * 40 * 25 mm ( W * D * H )
WEIGHT : 35 gm
Regulatory Approved.
5
HIMAQ S.R.L - Tel.: (011) 4709-3505 - Mail: himaq@himaq.com.ar - WEB: http://www.himaq.com.ar
4
Product Panel Views Description
Terminator
Terminator
The purpose is for compensating signal attenuation in long distance
connection at RS-485/422 . If the switch 1 & 2 are set in “ON” position, the
signal compensation will be activated. To disable the function, just to push
switch 1 & 2 to opposite position.
Power LED
SYS (Red):
It is a power indicator (When the power is on, the SYS LED will be on.)
All the US-101-485 USB to RS-485/422 Adapters must be installed the driver first
before you use it.
Driver Installation
Before when connecting up US-101-485 adapter for the first time, you have
to install the driver software in your computer first. US-101-485’s driver has
supported several kinds of OS like Windows, Mac and Linux
10
11
12
Hardware Installation
1. Power on your computer and until OS is ready after booting
2. There is a type A USB cable has two distinct connectors to connect the cable
from a USB device to as on a computer or USB hub.
3. Connect USB cable between a PC USB port or USB hub and US-101-485
adapter.
6. The SYS indicator of red LED will be turn into on. The US-101-485 USB to
serial adapter is active.
14
15
16
17
G. “Details” item
It is for checking device ID numbers as device instance ID.
18
□
□
□ USB Layout Diagram
1 2 3 4
19
D- 2 D-
D+ 1 D+
20