Beruflich Dokumente
Kultur Dokumente
Connections
Smartpack S Controller, panel mounted
Internal & Customer Connections
Customer Connections
X:a X:c
Input Circuit 1 + NO
Config. Input 1 Alarm Circuit 1
— Relay 1 C
Input Circuit 2
(From external equipment)
+
Config. Input 2 NC
Programmable Inputs
— NO
Input Circuit 3 Alarm Circuit 2
+
Config. Input 3 Relay 2 C
— NC
X:h
From Battery +
Power Input Ethernet port
— RJ45, 8 pins
To LVD Contactor 1 +
LVD Output 1
—
To LVD Contactor 2 +
LVD Output 2
—
Max. 1.5mm
(14AWG) wire section
The Smartpack S panel mounted controllers are usually shipped from factory with
the default CAN bus address "1", as the DIP switches for CAN bus addressing are
350030.013, 2v3-2017-01
not accessible from outside. Notice that the DIP switches are accessible on the
standard Smartpack S controllers, part # 242100.410. Refer to Figure 2 on page
9 and section "CAN Bus Addressing" on page 13.