Beruflich Dokumente
Kultur Dokumente
O/.argels. S. r. ,,.,\rh1lD.\\B
consent Not Ro-PItNE/crNsENz lBb\ob0q\q
Consent to establish under Section 25 ofthe Water (Prevention & Control
of Pollution) Act, Ig14 & under Section 21 of the Air (Prevention &
Control of Pollution) Act, 1981 and Authorization / Renewal ol
Authorization .rrnder Rule 6 of the Hazardous and Other Wastes
(Managernent fTransboundrv Movement) Rules 2016
ITo be referred as Water Act, Air Act and H & oW (M&TM) Rules respectivelyl'
located in the area declared under the provisions of the Water Act, Air act
and
Authorization under the provisions of H & OW(M&TNl) Rules and amendments lhereto
subject to the provisions of the Act and the Rules and the Orders that may be made
Jurther and subject to the following terms and condilions:
(i) The daily quantity oftrade effluent from the factory shall be Nil
(ii)The daily quantity of sewage effluent trom the faclory shall not exceed 0 50 M3'
Page I ol5
sev/age effluenl to the
same continuously so as to achieve the quality of treated
following slandards.
be soaked in a soak
(vr) Sewage Effluent Disposal: The treated domestic effluent shall
be used on land for
iit, which shall be got cleaneo penoorcally Ovedlow if any shall
dardening / Plantation only
(Prevention &
The applicant shall comply with the provisions of the Waterand amendment
Control of Pollution) Cess Act 1977 (to be referred as Cess Act)
Rules,2003 there under 'il OF,
ls as unoer
The daily watef consumption for the following categories
a. Conlrot EquiPment:
sufflcient capacity io
Industry shall provide dust collection sysiem of
controllhe emissions from different source
Page 2 ol5
a. Noise from the D.G. Set should be controlled by providing an acoustic
enclosure or by treating the room acousiically.
b. Industry should provide acoustic enclosure for conkol of noise. The
acoustic enclosure/ acoustic treatment of the foom should be designed
for minimum 25 dB (A) insertion loss or for meeting the ambient noise
standards, whichever is on higher side. A suitable exhaust mufflef with
insertion loss of 25 dB (A) shall also be provided. The measurement of
inse(ion loss will be done at different points at 0.5 meters from acouslic
enclosure/room and then average.
c, The industry shall take adequate measures for contfol of noise
levels from its own sources within the premises in respecl of noise to
less than 75 dB(A) duing day time and 70 dB(A) du ng the night
time. Day time is reckoned between 6 a.m. to 10 p.m and night time is
reckoned between 10 p.m to 6 a.m.
o. Industry should make efforts to bring down noise level due to DG set,
outside industrial premises, within ambient noise requiremenls by
prodr silting and control measures.
e. Installation of DG Set must be strictly in compliance with
recommendatiors of DG Sei manufacturer
A proper rouline and preventive mainlenance Procedure for DG set
should be set and followed in consultation with the DG manufaciufer
which would help to prevent noise leveis of DG set from deteriorating
with use
D.G. Set shall be operated only in case of power failure
The applicant should not cause.any nuisance in the surrounding area
due to ooeration of D.G. Set.
0li),
i The applicant shall provide pofts in the chimney/(s) and facilities such as
ladder, platform etc. fof monitoring the air emissions and the same shall be
open for inspection to/and for use of the Board's Staff. The chimney(s) vents
attached to various sources of emission shall be designated by numbers such
as S-1, S-2, etc. and these shall be painted/ displayed to facilitate identificaiion.
(iv) The industry shall take adequate measures for control of noise levels from its
own sources within the premises so as to maintain ambient air quality standard
in respect of noise to less than 75 dB(A) during day time and 70 dB(A) during
night time. Day time is reckoned in between 6 a.m. and 10 p.m. and night time
is reckoned between 10 p.m- and 6 a.m.
Page J of 5
','.i ir\.: r .-l,.lr. \,, ,,,,,,,rt,,,,,
.-r
f) 9o&J
2) The industry should monitor stack emissions and ambient air quality
RegLllarlY.
2. The industry should comply with the Hazardous and Other Wastes
(l\/anageme;t and Transboundry l\,4ovement) Rules 2016
act ot
a. Whe;ever due to any accident or gas leakage or other unforeseen
even, such e- ss:ons occur o- s applerended lo oLcl,- In elcess o'
sla'dards laro down. such inlornalion shall be Iorlhw th Repodeo Io
trire
Co lector, D rec'orate o' l_dustry SafeIV and -lea ln Po'rLe StaliL.
Jea l' Se v ces Depalnenl oL L :o o/sAe.J i boa_o
Brigade, Direclo'ate of
an; Local Body and the p-oo-ction orocess should be stoppdd by lanng arL
necessary satety measules Tne ndusL'y sha'l also monilol the ernlsslon
and ens-re lhdl Ihe emsslons do nol cause any
harn or nursance ln lne
su||ounding. Thc nduslry shourd nol restarl l"e process wilhoJl peJnlss'o1
of the BoaA and other slatulory organiTation as'equire under lbe ldvv
.
b. The unif has to display ano malntaln the data online ouiside thr;_6"ctory
main gate in Marathi& Engljsh bolh on a 6'x4'display board in the manner
and tlie report of the compliance along with photograph sh.all be subrnitted
to this office & concerned Regional Office/ Sub Regional Office
c. lt shall be ensured ihat ihe Hazafdous waste is handled' managed &
disposed of stficlly in accordance with the Hazardous and Other Wasles
(Management and Transboundry Movement) Rules 20'16
Page .{ ofs
I
L_.
v. The applicant shall not change or alter quanliiy, qualiiy, the rate of discharge,
temperalure or the mode of the effluenl / emissions or hazardous wastes or control
equipments provided for wilhout previous written permission of the Board.
vi. The applicant shall provide facility fof collection of environmental samples and
samples of trade and sewage effluents, air emissions and hazardous wastes to the
Board staff at the terminal or designated points and shall pay to ihe Board for the
services rendered in this behalf.
The frrm shall submit to thrs office the 30'h day of September every year, the
-
,,,vii.
Envrronmenlal Siatemenl Repod for the financial year ending 31s' A,4arch in the
prescribed Form-V as pfe the provisions of rule 14 of the Environmeni (Protection)
(Second Amendment) Rules, 1992.
viii.As insoection book shall be oDened and made available to the Board's officers
during their visit to the applicanl.
ix. The applicant shall install a separate eleclric meler showing the consumption of
energy for operation of domeslic and induslrial effluent treatment plants and
polluiion control system. A regisler showing consumplion of chemicals used for
keatmentthall be maintained.
Separate drainage system shall be paovided for collection of trade and sewage
effluenls. Terminal manholes shall be provided at the end of colleclion system with
arrangemenl for measuring the tlow. No effluent shall be admitted in lhe pipes /
sewefs down- stream of the terminal manholes. No effluent shall find ils way other
than in designed and provided collection System-
Neither storm water nor discharge from olher premises shall be allowed 10 mix with
\. the effluents from the factorv.
,rit",
, :l,l This is without prejudice to any other permission required under any of the
laws, by-laws or regulations in force.
';;tfi The applicant shall obtain consent to operate before starting actual
Commercial production.
12. This Board reserves the r;ght to add / amend / revoke any condition in this
consent and the sameshall be binding on the applicant.
13. The Capital inveslment of the industry is Rs. 150.00 Lakhs.
(Dr. H. D. Gandhe)
REGIONAL OFFICER, PUNE
To,
Balaji Sugar,
N,4/s.
Plot No. C 48, I\,4lDC Tasawade,
Tal. Karad, Dlst. Solapur
Copy io:
'1.Chief Account Officer, l\,4PCB. Mumbai.
2.Sub-Regional Officer, l\.4PCB, Solapur.
Page 5 ot 5