Beruflich Dokumente
Kultur Dokumente
If you have further questions or damaged accessory parts, contact us at 1-800-SAMSUNG (726-7864)
1. Automatic Ice Maker does not work • Do not use copper line.
• Cut the tubing, making sure the ends are square and clean. Press the Freezer button to set the freezer temperature
(1)
• Allow your refrigerator to operate and cool down 12
Freezer
between colder and coldest.
for 24 hours (1 full day) before the ice maker starts Press and hold the Freezer button for 3 seconds to activate
9 3
(Hold 3 sec for
producing ice. Power Freezer function which speeds up the freezing
6 Power Freeze)
process in the freezer.
Incorrect Correct (2) Press the Fridge button to set the Fridge temperature
Fridge between colder and coldest.
Temperature Indicator moving) There are several items that you need to purchase to complete this (3)
For better energy efficiency, press the Energy Saver button.
If condensation occurs on the doors, turn the Energy Saver
connection. Energy Saver
• You may find these items sold as a kit at your local hardware store.
refrigerator not to generate cool air. (Only for product sold in U.S) (4)
Use Copper Tubing Use Plastic Tubing button. The LED will light up and the Ice-Maker stops
[RF221, RF220] making ice.
¼” copper tubing ¼” plastic tubing Molded end
¼” compression nut (1pc) (Bulb) (5)
Ferrule (2pc) ¼” compression nut (1pc)
① ①
(6) Press this button to activate Power Freezer function which
[RL225]
4. Fridge or freezer Compartments are warm Power Freeze speeds up the freezing process in the freezer.
• Allow your refrigerator to operate and cool down for 24 hours (1 8. Food stored in refrigerator is frozen
① ① full day) to reach to the set temperature.
[RL220] • Also, into your refrigerator, it may need an additional • If food with too much moisture is stored near the cooling vents, it
24 hours for the fridge to reach the set temperature. may get frozen. Be sure to keep moist food away from the cooling
vents.
•
• • When installing, servicing or cleaning behind the refrigerator, be
but it does not make cool air. To cancel this mode, press the
hot and humid seasons.) sure of the following:
“Cooling O Key” at the same time for 5 seconds until “Ding-dong”
sounds. • • To protect your floor’s finish when
Saving function. moving the refrigerator, cut a large
COOLING OFF KEY • If you open the doors frequently or for too long, it may cause section of the cardboard carton
- moisture inside the fridge. and place under the refrigerator
RL220
- Model : Power Freeze + Freezer Key where you are working.
6. Noise Clicks, Pops, Cracks, Snaps • Pull the unit straight out and push
back in straight after finishing.
3. Water dispenser Intallation(On some models) • These noises may be heard occasionally inside the refrigerator.
This is normal. This sound occurs when various items contract
• Turn on water installation and Flush 3 gallons through filter before use or expand while temperatures are changing; especially during 10. Leveling & Door Alignment
(flush approximately 6 minutes) defrosting. This may also occur when electronic devices including
1. Cold Water line the ice maker are operating. • Insert a flat-blade screwdriver
2. Pipe Clamp. into a slot on the control lever,
3. Plastic line
4. Compression Nut
7. Display turn it clockwise or counter-
clockwise to level the door.
5. Compression Sleeve
[RF221, RF220]
6. Packing Nut
Control Lever
90 degree Flat-blade screw driver(-)
8. Filter Cartridge
9. Cartridge Holder 1 2 3
[RL225]
• The water filter must be installed outside the refrigerator.
It is not provided with your new refrigerator. The filter
cartridge (8) and holder (9) kit can be purchased from local 4 5
.hardware store. [RL220]