Beruflich Dokumente
Kultur Dokumente
Issue 18
Page 1 of 12
October 2012
Aerospace series
"When this standard is applied, a careful check must be made as to whether any protective rights exist. This
standard issuer hereby disclaims any liability for infringement of patent or design rights resulting from the use of
this standard".
Copyright reserved
Ref. no. ABS0060
ABS0060 Page 2
Issue 18
Contents
1 Scope
2 Normative references
3 Requirements
4 Designation
5 Marking
6 Technical specification
ABS0060 Page 3
Issue 18
1 Scope
This standard specifies the dimensions, tolerances, required characteristics and the mass of a sleeve for coupling
of two ducts and air conditioning.
2 Normative references
This Airbus Standard incorporates by dated or undated reference provisions from other publications. All normative
references cited at the appropriate places in the text are listed hereafter. For dated references, subsequent
amendments to or revisions of any these publications apply to this Airbus Standard only when incorporated in it by
amendment of revision. For undated references, the latest issue of the publication referred to shall be applied.
3 Requirements
1,5 to 2
Marking see chapter 5-b
(see note 1)
ØA
Dimensions in millimeters
NOTE: The sleeve elasticity should allow the assembly on smooth end or end following MS33660
(AS5131) standard.
Figure 1: Configuration, dimensions and tolerances
ABS0060 Page 4
Issue 18
A L
1,5 to 2
B
Dimensions in millimeters
Figure 2: Configuration, dimensions and tolerances - Elliptical duct
B L
1,5 to 2
2
R
R1
A
Dimensions in millimeters
Figure 3: Configuration, dimensions and tolerances - Oval duct
4 Designation
This type of Standard shall be designated according to the philosophy of the following example:
Item No.
(see table 2 to table 4)
5 Marking
Unless otherwise specified by contract, marking shall include:
6 Technical specification
ABS0081.
ABS0060 Page 11
Issue 18
RECORD OF REVISIONS
Clause
Issue Description of modification
modified
1 New Standard.
01/92
4 Item Nos 210, 215, 219, 221, 223, 229, 231, 242 added in table 1.
08/02 Column Ø A deleted in table 1.
Note added in figure 1.
6 Item Nos 101, 102, 104 to 114, 115, 116, 117, 118, 120, 124, 125, 126, 127, 128,
08/04 129, 130, 131, 132, 133, 136, 137, 138, 139, 140, 141, 142, 143, 144, 145, 146,
147, 149, 150, 151, 152, 153, 154, 155, 156, 157, 158, 160, 162, 165, 200, 201,
202, 203, 204, 205, 208, 209, 211, 212, 216, 220, 224, 225, 226, 228, 239, 240,
246, 247, 248, 249, 250, 251, 252, 401, 402, 403, 404, 405, 406, 407, 408, 409,
410, 411, 412 added.
RECORD OF REVISIONS
Clause
Issue Description of modification
modified
16 Table 2 Item No. 134, 163, 164, 165,166 and 167 added.
Table 3 Item No. 300 added.
04/11
06/11
18
Table 2, 3, 4, 5 Tolerance for length L is added
10/12