Beruflich Dokumente
Kultur Dokumente
4 Crankshaft Position Sensor Failed sensor or timing belt slipped, bad CPS
6 Engine Coolant Temp Circuit Reading too low, high, short or open, bad ECT
7 Throttle Position Circuit Reading too high, low, short or open, bad TPS
Crankshaft Position
CKP/TDC/CYP sensor circuit disconnected,
Sensor/Top Dead Center
8
Sensor/Cylinder Position
Sensor open or short. Bad TDC senor.
9 Cylinder Position Sensor Open or short in CYP circuit, bad CYP sensor
Intake Air Temperature
10 Short or open in AIT circuit, bad AITS
Sensor
Barometric Pressure Sensor
13 Bad ECM (Barometric sensor)
Circuit
Idle Control System
14 Bad IAC valve, bad fast idle thermo valve, Throttle body
Malfunction
Vehicle Speed Sensor
17 Short or open in VSS circuit, bad VSS
Circuit
Electrical Load Detector
20 Short or open in circuit, bad ELD
Circuit
Short or open in VTEC circuit, bad VTEC solenoid valve,
22 VTEC System Malfunction
Bad VTEC pressure switch
23 Knock Sensor Circuit Short or open in Knock Sensor circuit, bad Knock Sensor
A/T FI Signal A high/low
30 Bad AFSA line, TCM
input
A/T FI Signal B high/low
31 Bad AFSB line, TCM
input
Primary Heated O2 Sensor
41 Open or short in Primary O2 sensor heater circuit
Heater
Fuel supply system, Primary O2 sensor, MAP sensor,
45 System too lean/rich
contaminated fuel, valve clearance, exhaust
leakage
Crankshaft Speed
54 Open or short in CKF circuit, bad CKF sensor
Fluctuation Sensor
61 Primary Heated O2 Sensor Slow response, bad O2 sensor, exhaust leak
Secondary Heated O2
63 Slow response, bad O2 sensor, exhaust leak
Sensor
Secondary Heated O2
65 Open or short in secondary O2 sensor circuit
Sensor Circuit
67 Catalyst System Efficiency System below threshold, bad catalytic converter
70 Automatic Transaxle A/T transmission, A/T FI data line, TCM, ECM
Ignition system, fuel supply system, MAP sensor, IAC
valve, contaminated fuel, lack of fuel,
71 Random Misfire (Cyl 1)
fuel injector, fuel injector circuit, low compression, valve
clearance
Heated Oxygen Sensor or Oxygen Sensor (Fuel Injection) or Vehicle Speed Sensor
2
(Carburator)
5 MAP Sensor
6 Engine Coolant Temperature (ECT Sensor)
12 EGR System
16 Fuel injector
23 Knock Sensor
30 A/T FI signal A
31 A/T FI signal B