Beruflich Dokumente
Kultur Dokumente
Application Note
Application Software
for
MS2650/MS2660 Series
Spectrum Analyzers
Measurement Group
Anritsu Corporation
MS2650/2660 Series Spectrum Analyzer Application Note
MS2653A*
No Yes No Yes Yes Yes Yes
MS2663A*
8 GHz
MS2653B
Yes Yes Yes Yes Yes Yes Yes
MS2663B
MS2663C Yes Yes Yes Yes Yes Yes Yes
21 GHz
MS2665C Yes Yes No No Yes No No
(Spurious: (No TV option) (Under (Spurious: (No QP option) (Under
up to 8GHz) development) up to 8GHz) development)
30 GHz
MS2667C Yes Yes No No Yes No No
(Spurious: (No TV option) (Under (Spurious: (No QP option) (Under
up to 8GHz) development) up to 8GHz) development)
40 GHz
MS2668C Yes Yes No No Yes No No
(Spurious: (No TV option) (Under (Spurious: (No QP option) (Under
up to 8GHz) development) up to 8GHz) development)
*Discontinued models
MS2650/2660 Series Spectrum Analyzer Application Note
GPIB
2C o r
RS-23
Configuration of equipment
Software Applicable Model Type Recommended components Components required to
for combination obtain a hard copy
MX260002A CDMA MS2651B,MS2653B, MG3671B DSG --- 1 Printer(RS232C):
measurement software MS2661B,MS2663B EPSON-VP600 --- 1
MS2661C,MS2663C --- 1* MG0310A
Memory card(256k-byte MS2665C Modulation Unit --- 1 Specified cable(J0742) --- 1
SRAM card) --- 1 MS2667C
MS2668C
Spurious measurement:
up to 3GHz; MS2651B/C
MS2661B/C
up to 8GHz; MS2663B/C
MS2665C
MS2667C
MS2668C
Configuration of equipment
Software Applicable Model Type Recommended components Components required to
for combination obtain a hard copy
MX260004A GSM Base MS2651A/B Always required: Printer: FP-850 or --- 1
Station measurement MS2653A/B Coaxial cable(J0114A) --- 1 EPSON-VP600, HP-2225
software MS2661A/B/C Coaxial cable(J0026A) --- 1
MS2663A/B/C --- 1 GPIB cable(J0007) --- 1
Memory card( 512k-byte MS2665C Required for some
SRAM card) --- 1 MS2667C measurement items:
MS2668C Attenuator --- 1
Bandpass filter --- 1
Low noise pre-amp --- 1
Coaxial cable --- required
quantity
MS2650/2660 Series Spectrum Analyzer Application Note
Configuration of equipment
Software Applicable Model Type Recommended components Components required to
for combination obtain a hard copy
MX260003A PDC Base MS2651A/B Always required: Printer: FP-850 or --- 1
Station measurement MS2653A/B Coaxial cable(J0114A) --- 1 EPSON-VP600, HP-2225
software MS2661A/B/C --- 1 Coaxial cable(J0026A) --- 1
MS2663A/B/C GPIB cable(J0007) --- 1
Memory card(256 KB Required for some
SRAM card) --- 1 measurement items:
Attenuator --- 1
Bandpass filter --- 1
Low noise pre-amp --- 1
Coaxial cable --- required
quantity
MS2650/2660 Series Spectrum Analyzer Application Note
EMI Measurement
Configuration of equipment
Software Applicable Model Type Recommended components Components required to
for combination obtain a hard copy
MX264001A EMI MS2651A/B Always required: Printer(RS232C):
measurement MS2653A/B --- 1* MH648A Preamplifier --- 1 EPSON-VP600 --- 1
MS2661A/B/C
Memory card(256k bytes MS2663A/B/C Special cable(J0742) --- 1
SRAM card) --- 1
*: The following options
are necessary
Opt.08: Preamplifier
Opt.10: Centronics
Interface
Opt.12: QP detector
MS2650/2660 Series Spectrum Analyzer Application Note
CATV Measurement
Configuration of equipment
Software Applicable Model Type Recommended Components required to
components for obtain a hard copy
combination
MX262001A CATV MS2651B When measuring weak Printer(RS232C):
measurement MS2653B --- 1* signal: EPSON-VP600 --- 1
MS2661B/C Opt.08:Preamplifier --- 1
Memory card(256k KB MS2663B/C Opt.02:Narrow resolution Special cable(J0742) --- 1
SRAM card) --- 1 Bandwidth --- 1
*: The following options
are necessary
Opt.01: Reference crystal
Oscillator
Opt.06: Trigger/gate
circuit
Opt.07: AM/FM demodulator
Interface
Opt.16 or 21: Television
monitor
MS2650/2660 Series Spectrum Analyzer Application Note
Anritsu MS2661C
DUT ATT
Measurement signal RF input
MS2650/2660 Series
connector Spectrum Analyzer
1. Measurement items
Channel power Gated power(for trigger Int)
Occupied bandwidth Tx spurious (other than standby power)
Adjacent channel leakage power
Anritsu MS2661C
DUT
Measurement signal RF input
MS2650/2660 Series
2. Measurement items connector Spectrum Analyzer
Tx spurious(standby power)
Rx spurious
MS2650/2660 Series Spectrum Analyzer Application Note
Anritsu MS2661C
DUT ATT
Measurement signal RF input MS2650/2660 Series
connector Spectrum Analyzer
3. Measurement items
Gated power (trigger Ext)
Station
Simulator DUT ATT
(MG3671B + MG0310A) Measurement signal RF input MS2650/2660 Series
connector Spectrum Analyzer
4. Measurement items
Time response of open-loop power control
MS2650/2660 Series Spectrum Analyzer Application Note
Receiver
Measurement items Monitor item Recommendation Measurable/ SFH support
Not Measurable
GSM11.21 J-STD
Spurious emissions from 7.9 5.4.4 Measurable
the receiver antenna
connector
MS2650/2660 Series Spectrum Analyzer Application Note
DUT ATT
RF output External Attenuator Input 50 Ω MS2650/2660 Series
Unit Under Test Spectrum Analyzer
DUT ATT
RF output External Attenuator Input 50 Ω
Unit Under Test
signal source(CW)
Circulator ATT
DUT External ATT Input 50 Ω
RF output
Unit Under Test
MS2650/2660 Series Spectrum Analyzer Application Note
Tx
----
Combinar ATT
External attenuator Input 50 Ω
RF output
MS2650/2660 Series Spectrum Analyzer Application Note
Pre-Amplifier
Tx
----
MS2650/2660 Series
Spectrum Analyzer
Connect IF-Out to
the power sensor Anritsu MS2661C
Measurement signal
DUT
2471 to2497 MHz
MF1603A
Frequency Counter
Change this connection (If required)
during measurement Anritsu FREQUENCY COUNTER MF1603A
Connect all the ground terminals of all the measuring instrument to the ground terminal or chassis of the DUT.
MS2650/2660 Series Spectrum Analyzer Application Note
RF output
DUT ATT
External Attenuator
Unit Under Test
MS2650/2660 Series
Repeated burst measurement Spectrum Analyzer
GPIB Anritsu MS2661C
DUT ATT
DUT ATT
External
Unit Under Test Attenuator MS2650/2660 Series
Spectrum Analyzer ML4803A + MA4601A
Power Meter
Anritsu MS2661C
RF output
DUT ATT
Unit Under Test External Attenuator
MS2650/2660 Series Spectrum Analyzer Application Note
MS2650/2660 Series
Spectrum Analyzer
Measurement signal Anritsu MS2661C
DUT
2471 to2497 MHz
MF1603A
Frequency Counter
Change this connection (If required)
during measurement Anritsu FREQUENCY COUNTER MF1603A
Connect all the ground terminals of all the measuring instrument to the ground terminal or chassis of the DUT.
MS2650/2660 Series Spectrum Analyzer Application Note
RF output
DUT ATT
External Attenuator
Unit Under Test
MS2650/2660 Series
Repeated burst measurement Spectrum Analyzer
GPIB Anritsu MS2661C
DUT ATT
GPIB
DUT ATT
External
Unit Under Test Attenuator ML4803A + MA4601A
Power Meter
Anritsu MS2661C
RF output
DUT ATT
Unit Under Test External Attenuator
MS2650/2660 Series Spectrum Analyzer Application Note
The MX264001A EMI measurement software memory card contains the following programs
and data files:
File Name Use
EMI.IMG Main program for the EMI measurement.
%ANT01.DAT Initialization data file of arbitrary registration antenna factor that ca be input and
%ANT02.DAT edited by users.
%ANT03.DAT %ANT01 and %ANT02 are data files that correspond to the USER1 antenna data
%ANT04.DAT and USER2 antenna data, respectively.
%ANT05.DAT
%LMT01.DAT Initialization data file of arbitrary registration specification line data that can be
%LMT02.DAT input and edited by users.
%LMT03.DAT %LMT01 and %LMT02 are data files corresponding to the specification line data
%LMT04.DAT USER1 and USER2, respectively.
%LMT05.DAT
%COR01.DAT Initialization data file of arbitrary registration level frequency correction cofficient
%COR02.DAT that can be input and edited by users.
%COR03.DAT %COR01 and %COR02 are data files corresponding to the specification line data
%COR04.DAT USER1 and USER2, respectively.
%COR05.DAT
MS2650/2660 Series Spectrum Analyzer Application Note
Analyzer
Only
with Opt.08
(Pre-Amp)
MH648A
Preamplifier MH648A
MS2650/2660 Series Spectrum Analyzer Application Note
Measuring items
1. Frequency Measurement
2. Channel Power Measurement
3. Harmonics Measurement
4. Near Carrier Spurious Emission Measurement
5. In-Band Spurious Emission Measurement
6. Out-of-Band Spurious Emission measurement
7. Occupied Bandwidth Measurement
8. Adjacent Channel Power Measurement
9. Power Measurement
MS2650/2660 Series Spectrum Analyzer Application Note
MS2650/2660 Series
Spectrum Analyzer
PDC
Base Station ATT
ATT
Modes of Measurement
1. Measure Mode
(Formal measurements)
2. Survey Mode
(Every day maintenance mode)
3. Surveiller Mode
(Long time period observation mode)
MS2650/2660 Series Spectrum Analyzer Application Note