Beruflich Dokumente
Kultur Dokumente
Synopsis should contain certificates from the company (if live project), and yourself
indicating that the work is original and is not submitted elsewhere.
1. One Copy of the Synopsis is submitted to the department.
2. Report must be Spiral Bound.
3. Size and font
Complete Synopsis Report including pages and chart.
(i) type of font: Times New Roman
(ii) Chapter heading 14 points
(iii) Heading 12 point capital and bold
(iv) Sub heading 12 point capital
(v) Text 12 point
4. Page Margin
Top Margin 1”
Bottom Margin 1”
Left Margin 1”
Right Margin 1”
5. Line Spacing 1 line
6. Paragraph Spacing 1.5 line
7. All pages (except front page and certificates) shall be numbered at bottom
with center alignment.
8. Only one side of the page will be written.
9. Each new chapter will start from a new page.
10. An appendix shall be added for technology used, functions implemented etc if
required.
11. Students should clearly mention what kind of testing and how is done in the
project.
12. Students should carefully read their synopsis reports to remove wrong
spellings, grammatical mistakes, and repetition of words, Lines or paragraph
in the text. They are advised not to repeat the same text again and again just to
increase the size of the chapter in their report. However giving reference is
allowed.
13. The lists of the chapters with subtopics are available below. Use The Chapters
and their sub topics as per your project’s requirements.
Table of Contents
Front Page (format attached)
Certificates (Company, your declaration.)
Acknowledgement
Index Page No
Chapter 1. Introduction
1
1. 1 Aims, Objectives , Vision
Chapter 2.Project / Problem Selection
Chapter 3.Project Monitoring System
3.1 Gantt Chart
3.2 PERT Chart
Chapter 4. System Study
4.1 Existing System along with limitations/deficiencies
4.2 Proposed system along with intended objectives
4.3 Feasibility study
4.3.1 Operational
4.3.2 Technical
4.3.3 Economic
Chapter 5. System Analysis
5.1 Requirement Specification
5.2 System flowcharts
5.3 DFDs/HIPOs/ERDs
5.4 Sources of data
Chapter 6. Scope of the Project
3. Shin, K.G. and Mckay, N.D. (1984) ‘Open Loop Minimum Time Control
of Mechanical Manipulations and its Applications’,
Proc.Amer.Contr.Conf., San Diego, CA, pp. 1231-1236.
Appendix, if any.
SUBMITTED TO
RAJIV GANDHI PROUDYOGIKI VISHWAVIDYALAYA
(M.P.)
Logo of rgpv
BACHELOR OF ENGINEERING
IN
(COMPUTER SCIENCE AND ENGINEERING /
INFORMATION TECHNOLOGY)
YEAR 2012-13
SUBMITTED BY
{Name of the Students with Roll Numbers}
GUIDED BY
(Name of the guide)
NAME
DESIGNATION
Deptt. of CSE & IT
ITM, Gwalior (M.P)
Logo of ITM
CERTIFICATE
This is to certify that {Name of the students with roll numbers}, students of
Bachelor of Engineering (Computer Science & Engineering / INFORMATION
TECHNOLOGY) VII semester has developed a synopsis on {Title of the} under the
guidance of {name of the guide} using {technology used} for the partial fulfillment of
Bachelor of Engineering (Computer Science & Engineering/ INFORMATION
TECHNOLOGY) and submitted a satisfactory Synopsis of the project. This work has
not been submitted in part or full to this or any other university for the award of any
degree or diploma to the best of my knowledge.
We wish him/ her success in the future.