Beruflich Dokumente
Kultur Dokumente
co
1
www.gradeup.co
measurement. This error may be called B. the time encountered when the
as_________. instrument has to wait for some
A. gross error reactions to take place.
B. random error C. the time before the instrument begins
C. error caused by misuse of instrument to response after the quantity has
D. error caused by loading effect altered.
Ans. D D. retardation or delay in the response of
654. Which of the following options is an Active an instrument to a change in the input
transducer? signal.
A. photo emissive cell Ans. C
B. photo voltaic cell 660. One input terminal of high gain comparator
circuit is grounded and a sinusoidal voltage
C. selsyn
is applied to the other input. The output of
D. photo emissive cell, photo voltaic cell
comparator will be___________.
and selsyn
A. a sinusoidal
Ans. B
B. a full rectified sinusoidal
655. Un-bonded strain gauges are _____.
C. a half rectified sinusoidal
A. exclusively used for transducer
D. a square wave
applications
Ans. D
B. exclusively used for stress analysis
661. A minimum-phase system with no zeros
C. used for unbounded strains only
has a phase-angle of – 270° at gain
D. None of these
crossover frequency. The system is_____.
Ans. A
A. stable
656. Dynamometer type moving coil
B. unstable
instruments are provided with _____.
C. marginally stable
A. eddy current damping
D. conditionally stable
B. pneumatic damping
Ans. B
C. fluid friction damping
662. Transfer function of a system is
D. electrostatic damping
G ( s ) = K/ s2 (1 + sT ) . This open-loop
Ans. B
657. Voltmeter is a galvanometer with _____. system is__________.
A. high resistance A. stable
B. low resistance B. unstable
C. both low and high resistance C. marginally stable
D. uncertain resistance D. conditionally stable
Ans. A Ans. B
658. Strain gauge rosettes are used when 663. In a closed-loop system in which the
____________.
output is the speed of a motor, the output
A. the direction of hoop stress is not
known rate control can be used to_________.
B. the direction of principal stress is not A. limit the speed of the motor
known B. limit the torque output of motor
C. the direction of principal stress is C. limit the acceleration of the motor
known D. reduce the damping of the system
D. the direction of longitudinal stress is Ans. C
not known 664. If an input signal with non-zero direct
Ans. B current (dc) component is applied to a low
659. The dead time of an instrument refers pass RC network, then dc component in the
to____________. output signal will be _____________.
A. large change of input quantity for
which there is no output.
5
www.gradeup.co
6
www.gradeup.co
677. The squirrel-cage winding of a single-phase C. both lap and wave wound machines
motor is placed in the_________. D. None of these
A. armature B. stator Ans. C
C. rotor D. field 685. For the production of induced e.m.f. field
Ans. C system of an electric machine_________.
678. NEMA standards rate motors according A. must be on stator
to__________. B. may be on stator or rotor
A. frame number B. horsepower C. must be on rotor
C. voltage D. weight D. None of these
Ans. A Ans. B
679. Which of the following motors is most 686. The number of conductors of the
suitable for signalling devices and timer? compensating winding in a D.C. machine
A. D.C. series motor ____________.
B. D.C. shunt motor A. is always more than the number of
C. Two phase induction motor armature conductors per pole
D. Reluctance motor B. is always less than the number of
Ans. D armature conductors per pole
680. The purpose of skewing of rotor slots in C. may be less or more than the number
induction motor is_________. of armature conductors per pole
A. to reduce the magnetic hum of the D. None of these
motor Ans. B
B. to increase the distribution factor 687. Two D.C. machines 500 kW each are tested
C. to reduce the locking tendency of rotor by Hopkinson testing method. The power
D. to increase the breadth factor input would be ___________.
Ans. C A. 500 kW B. 100 kW
681. In an induction motor, if the rotor C. 1000 kW D. None of these
resistance is equal to stand-still reactance Ans. B
then the maximum torque is_________. 688. In a D.C. machine, how are the
A. less than starting torque commutating pole winding connected?
B. equal to starting torque A. In series with the shunt winding
C. more than starting torque B. Parallel to the shunt winding
D. None of these C. In series with the armature winding
Ans. B D. Parallel to the armature winding
682. The m.m.f. produced by a single phase Ans. A
winding is____________. 689. In motor circuit static frequency changers
A. pulsating and stationary are used for __________.
B. pulsating and rotating A. improved cooling
C. constant in amplitude and stationary B. Power factor improvement
D. constant in amplitude and rotating C. reversal of direction
Ans. A D. speed regulation
683. Usually wide and very sensitive speed Ans. D
control is required in case of_________. 690. In case of travelling cranes, the motor
A. Reciprocating pumps preferred for boom hoist is _________.
B. Colliery winders A. slip ring induction motor
C. Centrifugal blowers B. squirrel cage induction motor
D. Lathe machines C. synchronous motor
Ans. B D. single phase motor
684. Inter-poles are used in_________. Ans. A
A. lap wound machines 691. Light duty cranes are generally used in
B. wave wound machines _____________.
A. automobile workshops
7
www.gradeup.co
10
www.gradeup.co
11
www.gradeup.co
C. D.
Ans. A
743. Which of the following answer figure
patterns can be combined to make the
question figure?
A. B.
C. D.
Ans. C
A. B. 747. From the given answer figures, select the
one in which the question figure is
hidden/embedded.
C. D.
Ans. B
244. Which of the following diagrams represent
the relationship between Chinese, Indians
and Asians?
A. B.
A. B.
C. D.
Ans. B C. D.
745. In the following figure square represents Ans. A
hockey players, triangle represents cricket 748. A piece of paper is folded and punched as
players, circle represents kabaddi players shown below in the question figures. From
and rectangle represents football players. the given answer figures, indicate how it
Which set of letters represents hockey will appear when opened
players who do not play football and circket
players who play kabaddi?
A. B.
A. O, U And P B. R, S and U
C. O, S and U D. Q, P and T
Ans. C
746. Which answer figure will complete the C. D.
pattern in the question figure? Ans. C
749. If a mirror is placed on the line MN, then
which of the answer figures is the right
image of the given figure?
12
www.gradeup.co
13
www.gradeup.co
C. the fundamental rights of the Indian 1. The point where the energy of an
Citizen earthquake is released is called the
D. the directive principles of state policy hypocentre.
Ans. D 2. The point on the surface, nearest to
760. Which commission suggested that jobs in the focus of the earthquake, is called
the Central Government should be epicentre.
reserved for the 'Other Backward Classes' 3. Epicentre is a point directly below the
(OBC)? focus of an earthquake.
A. Mandal B. Nanavati Which of the statements given above is /
C. Kelkar D. Kothari are correct?
Ans. A A. 1 only B. 2 only
761. With reference to the 1857 revolt consider C. 1 and 2 only D. 2 and 3 only
the following statements. Ans. C
1. The sepoys of Meerut appealed to 767. Which of the following places in India has
Bahadur Shah Zafar to accept the off shore petroleum reserves?
leadership of the revolt. A. Cochin High B. Madras High
2. In Kanpur, the sepoys made Nana C. Mumbai High D. Goa High
Sahib as their leader. Ans. C
3. In Awadh, Rani Laxmibai was made the 768. The earth's radius is approximately
leader. ___________.
Which of the given statements is/are A. 6,070 km B. 6,170 km
correct? C. 6,270 km D. 6,370 km
A. 1 only B. 1 and 2 only Ans. D
C. 2 and 3 only D. 1, 2 and 3 769. Which of the following indian rivers
Ans. B discharges its waters in the Arabian Sea?
762. One of the most important descriptions of A. Kaveri B. Tapi
the city of ____________ in the fifteenth C. Mahanadi D. Brahmaputra
century comes from Abdur Razzaq Ans. B
Samarqandi. 770. The Khardung La pass is associated with
A. Vijayanagara B. Harappa which mountain range?
C. Ayodhya D. Hampi A. Pir Panjal B. Ladakh
Ans. A C. Banihal D. Zaskar
763. Charles Cornwallis was the Governor Ans. B
General of ________ when the Permanent 771. Which of the following has a Fusiform root?
Settlement was introduced there in 1793.
A. Carrot B. Radish
A. Bihar B. Madras
C. Beet root D. Potato
C. Punjab D. Bengal
Ans. B
Ans. D
772. Double fertilization is a complex
764. The French Revolution, a period that fertilization mechanism of _________.
brought far-reaching social and political
A. Gymnosperms B. Monocots
upheaval in France, began in _________.
C. Angiosperms D. Bryophytes
A. 1689 B. 1789
Ans. C
C. 1889 D. 1989
773. The nuclear membrane is absent in the
Ans. B
cells of organisms belonging to which
765. When did the epidemic of Black Death (a kingdom?
type of Plague) spread in entire Europe?
A. Monera B. Protista
A. 1748 B. 1548
C. Fungi D. Plantae
C. 1348 D. 1148
Ans. A
Ans. C
774. ____________ are composed of long,
766. With reference to an earthquake consider fibrous proteins as filaments that slide past
the following statements.
14
www.gradeup.co
each other when a muscle contracts or C. Long Radio Waves < Microwaves <
relaxes. Visible light < X-Rays
A. Myofibril B. Sarcomeres D. Long Radio Waves < X-Rays < Visible
C. Cross bridges D. Z band light < Microwaves
Ans. B Ans. C
775. Which of the following is the first stage of 781. Which of the following is, "A device used to
mitosis? connect two separate Ethernet networks
A. Prophase B. Metaphase into one extended Ethernet."?
C. Anaphase D. Telophase A. Bridge B. Router
Ans. A C. Repeater D. Modem
776. The scientific and objective study of animal Ans. A
behaviour is called ______________. 782. _____________ is a language for the
A. Ethology B. Entomology specification of procedures for the retrieval
C. Ecology D. Euthenics (and sometimes also modification) of
Ans. A information from a database.
777. Read the pairs given below- A. High Level Language
Size of Object or distance : Length (in m) B. SQL
1. Size of a proton : 10-15 C. Query Language
2. Length of a typical virus : 10-8 D. 4GL
3. Distance of Sun from Earth : 105 Ans. C
4. Thickness of a paper : 10-1 783. Read the pairs given below-
Which of the above pairs are correctly Name : Formula
matched? 1. Acetone : CH2OHCHOHCH2OH
A. 1 and 2 only B. 2 and 3 only 2. Ethanal : CH3CHO
C. 3 and 4 only D. 1, 2 and 3
3. Formaldehyde : HCHO
Ans. A
4. Glycerol : CH3COCH3
778. Which of the following is the correct
formula for magnification while using a Which of the above pairs are correctly
concave mirror? matched?
A. -(Image distance)/(Object distance) A. 2 and 3 only B. 1 and 4 only
B. -(Object distance)/(Image distance) C. 2, 3 and 4 only D. 1,2 , 3 and 4
C. (Image distance)/(Object distance) Ans. A
D. (Object distance)/(Image distance) 784. What is the IUPAC name of tert-Butyl
Ans. A bromide?
779. A thermodynamic process during which the A. 2-Bromo-3-methylpropane
volume of the closed system in B. 2-Bromo-2-methylpropane
consideration remains constant is called C. 2-Bromo-3-methylbutane
____________. D. 2-Bromo-2-methylbutane
A. Isochoric process Ans. B
B. Isobaric process 785. Francium is highly radioactive; its longest-
C. Adiabatic process lived isotope223Fr has a half-life of only
D. Isothermal process _____________.
Ans. A A. 2.1 seconds B. 21 seconds
780. Which of the following is the correct order C. 2.1 minutes D. 21 minutes
of electromagnetic radiation arranged in Ans. D
order of increasing frequency? 786. Which of the following elements has the
A. Microwaves < Visible light < X-Rays < highest atomic number?
Long Radio Waves A. Rubidium B. Caesium
B. X-Rays < Microwaves < Visible light < C. Potassium D. Francium
Long Radio Waves Ans. D
787. Which of the following statements is true?
15
www.gradeup.co
16