Beruflich Dokumente
Kultur Dokumente
MID TERM
9 Keys, Types of Keys, uses and drawing methods ,Gibb and Cotter
Joint Drawing.
10 Tolerances, Types of Tolerances, Terminology, Clearance fit,
Interference Fit, and Transition fit, Cumulative Tolerance, Surface
quality and Texture.
11 Rivets and riveted joints, Pitch , Lap joints, butt joints
12 Geometric Tolerances, Symbols Used in geometric Tolerances,
Tolerances Location (Position Tolerance, Concentricity,) Tolerance
of form (Straightness, Flatness, Roundness, Cylindricity, Profile of
line, Profile of Surface , Angularity, Perpendicularity, Parallelism)
13 Wedded joints drawings. Symbols used for different types of
welds.
Basic Manufacturing Processes, working drawing needed for
production.
14 Bearings, Types and Examples, Journal , Bushed bearing
15 Assembly and layout drawings, Detailed Drawing
16 Pulleys, Shaft Coupling, Types,
17 Isometric projections (solids)/ Review Q&A Session.
Final TERM
Grading Criteria
Mid Term Examination = 20%
Final Term Examination = 60%
Quizzes / Assignments = 20%
Recommended Books:
Engineering Drawing and Graphics by T.E. French C.J Vierck R.J. Foster
Practical Geometry & Engineering Graphics by Abbot
Engineering Graphics by Craft, Meyers & Boyer
CLASS POLICIES:
It is hard to follow and fulfill the requirements of this course without attending to the lectures
properly, so attendance is an integral part of the evaluation.
I suggest you to spend 2-3 hours per week to make a review and solve the exercises at the end of
each chapter of the textbook. Each chapter builds upon the previous one, so once you miss any of
them and do not recover it, it will be difficult to follow the next session.
There will not be any makeup exams for the quizes, so try not to miss them!
Assignments should be submitted on time. Later assignments are not accepted.