Beruflich Dokumente
Kultur Dokumente
CHAPTER 23
REVISION QUESTIONS REVISION QUESTIONS
CORROSION
SURFACE PREPARATION
(Answer of question from course notes) (Answer of question from course note)
132
SURFACE PREPARATION
40- 65 till 70°C.
(Answer of question from course note) 41- After Pickling Process complete, immerse the steel substrate into a bath of
phosphoric/Chromic acid, 2 % solution at 80°C for approximately one to two minute with iron
01- Preparation of steel substrate before application of paints and related product. filling (0.5%) and after that rinse in clean water and check for Ph values. Value should be at
02- Size of particles, hardness, density and shape of particle. the range of 4.5 till 7pH.
03- Remove or reduce electric static shock. 42- 20 000psi
04- Hypodermic Needle Gauge. 43- Lot of slurry, use large amount of water and use inhibitor.
05- Long production run, Can control quality, more safety, efficient use of abrasive. 44- After Pickling Process complete, immerse the steel substrate into a bath of
06- Impossible. phosphoric/Chromic acid, 2 % solution at 80°C for approximately one to two minute with iron
07- Yes, the appearance. filling (0.5%) and after that rinse in clean water and check for Ph values. Value should be at
08- No different. the range of 4.5 till 7pH.
09- Yes, Rust grade D have a heavy pitted. 45- Reduce dust and good to remove toxic paint.
10- 220mph. 46- To forms rust inhibitive layers, which passivate the surface and increase the adhesion
11- 100psi per nozzle. properties and also extremely resistant to cathodic disbondment.
12- Polishing and smooth shiny areas which does not provide good adhesion. 47- Treated by abrading with emery clothes.
13- SA 1 48- No.
14- 7pH 49- 14 photos, 2 for rust grade A, 4 photos for each rust grade B, C and D.
15- Using pH indication strip paper. 50- Grit Blasting.
16- To retards the formation of corrosion product.
17- Rust Grade A and D.
18- Pickling process followed by passivation process.
19- 0 till 7pH.
20- 7 till 14pH
21- Litmus paper to measure of either acid or alkalis.
22- Supply a large amount of water, disposal of slurry and mix of inhibitor.
23- Revert, screw, bolt and nuts.
24- Expansion, Dehydration and Heat penetration.
25- AF1, BF1, CF1 and DF1.
26- Needle Jetting or Needle Gun.
27- Standard of tooling- ST 2 means thorough hand and power tool cleaning and ST 3 means Very
thorough hand and power tool cleaning.
28- Phosphorus Bronze and Beryllium Bronze.
29- Burnishing did not provide a good adhesion of paint.
30- Leave a very coarse profile and need to repair by abraded with emery clothes.
31- 4.5 Till 7pH.
32- Oil or water filter/separator.
33- 80% production.
34- Xylene
35- Blasting Triggers which always under operator control.
36- To reduce or remove electric shock of static.
37- By Air Wash Separator.
38- Very hazardous to the operator.
39- High pressure water blasting up to 30000psi, High pressure water plus abrasive injection, Low
pressure water plus abrasive injection and Water Blasting.
133
133 & 134 30- Carbon and aluminium.
135
PAINT TECHNOLOGY (1)