Beruflich Dokumente
Kultur Dokumente
Exper
Replacing Wristwatch Batteries
Before Opening the Watch Case If a dead battery has not been removed from the please look for a »Reset« contact. This can be a
If the watch has an endless strap, such as many watch or if a faulty or poor battery has been fit- small contact spring that has to be pushed down
metal bands, unhook one end so that the watch ted, corrosion can occur. In this case, the battery or two solder points, which have to be shorted
can be placed face down on the work surface. As contacts have to be cleaned. Please scrape the out with tweezers. Quite often, the »Reset« con-
a rule, there is a spring bar somewhere in the contacts with a screwdriver or a glass-fibre pencil tact is marked with »C« or »CLR« (= »Clear«).
brush rather than using emery paper. Use an eye
band that can be removed.
loupe! Do not blow any residue into the move-
Fitting the Case Back
Carefully clean the edge around the case back since ment. Use a »Rodico« rubber block to pick up Place a screwed-down back on the case and turn it
it usually collects dirt, which definitely should not any dirt particles. If air is needed, use a blower carefully in a clockwise direction to find the thread
enter the open movement! Check with a clock- such as SELVA No. 388-991-000 and then use a case opener tool to screw it down.
maker’s loupe. Carefully dust the working area. Please make absolutely sure that any synthetic or
Generally, a new battery should have the same num-
rubber O-ring fits properly into its groove.
Opening the Watch Case ber and specifications as the one being replaced.
A pressed-on back usually has a groove for the
Suitable tools are needed for screwed-down Fitting the New Battery hand setter. Place this groove over the hand set-
backs, e.g., SELVA Case Openers No. 380-078-300 Do not handle the battery with fingers or metal ter’s stem, then press down using both thumbs.
or 386-385-800. tools since this would cause the battery to in- The back will close easier if pressed down along
Pressed on backs can be pried open with a sharp stantly discharge. Fingerprints can be like printed the outer edge rather than at its centre.
blade, e.g., Case Openers No. 388-112-400, circuits and cause current leakage, which will Not mentioned so far are cases
382-383-900 or 384-189-100. The blade has to be substantially shorten battery life. Two suitable where it is almost impossible
applied at the recess that is cut into the case back plastic tweezers can be found in the SELVA to remove the back and close
(use a loupe to find it). When using the blade, Catalogue. it again. Sometimes the case
make sure that it does not slip and cause injuries When fitting the new battery,
or damage to the case! In many watches, the please make sure that any pre- These products from the
highly sensitive coil is unprotected. Even the viously installed
smallest damage to it – possibly only visible insulating shim is placed back SELVA Programme help you
under a loupe – will stop the movement. In most into the bottom of the battery
cases, the repair of such a coil is not possible! hold. Fit the contact spring,
to do a professional job:
Caution: Some watches with an acoustic alarm push it down and secure it with Tools Page Illus. Order No.
have a small spring between movement and case the screw. A finger can be used
back to provide contact between the movement to push the spring and battery Press 60 10 384-182-800
and the alarm beeper. These springs can have down, since the negative pole Loupes 61
many different shapes and are loosely held in a can no longer be touched. Clamping Fixture 62
recess. Such watches should not be turned over Push the hand setter in and Holding Clamp 62
after the back has been removed since the tiny check if the watch movement Case Opener 62
contact spring can fall out and get lost. runs. Use a loupe to check once Battery Tester 64 1 380-173-700
more for any foreign particles Plastic Tweezers 64
After Opening the Watch Case or dust. If necessary, use a
Please keep away from dust! Do not touch the Pencil Brush 68 5 387-569-400
blower or »Rodico«, then fit the »Rodico« Rubber Eraser 72 2 092-318-400
movement. It could cause static, which in turn back cover.
could damage the movement’s electronics. Silicone Grease 72 15 096-030-200
If the watch does not work, the Blower 72 21 388-991-000
Pull the hand setter out to its stop. There are problem is probably not the
many different types of battery contact springs. battery but a more serious damage in the
Some simply have to be unhooked, most of them opener has to be driven into the gap between case
electronics or the mechanical parts. and back with soft blows of a hammer (four hands
are held by a screw. Always use a screwdriver
with a sharp blade so as not to damage the It is difficult to make any recommendations. are needed!). Or the watch has a screwed-down
screw’s head. Sometimes, a thorough cleaning will solve the back that cannot be opened with a regular case
problem. Done by a professional watchmaker, it opener. When pressing down the back, it might
Caution: The contact springs are under tension may, however, be more expensive than a new become necessary to clamp the case in a vice
and can fling away their small screw. quartz watch. Spare parts for no-name move- taking special care not to put a load on the watch
Remove the battery. ments are virtually unavailable. crystal. A special press with a number of inserts
Caution: Quite often, a thin insulating shim is fitted Please note: Some watches with lithium batteries for various case and back shapes can be found in
underneath the battery. Be sure not lose this part. may not start or have a dead display. In this case, the SELVA Catalogue.
0910 466-440-1 E
Battery Exchange Chart SELVA Price List 2011
MAXELL
NATIONAL
UCAR PANASONIC
ENERGIZER SONY DURA- SELVA
SONY EVEREADY TOSHIBA VARTA RAYOVAC CELL PHILIPS TIMEX CITIZEN SEIKO Order No.
362 362 SR721SW V362 362 D362 362 S 280-29 SB-AK/DK 097-664-300
364 364 SR621SW V364 364 D364 364 T 280-34 SB-AG/DG 097-665-200
377 377 SR626SW V377 377 D377 377 BA 280-39 SB-AW 097-675-000
386* 386 SR43W V386 386 D386 386 H 280-41 SB-B8 097-667-000
389* 389 SR1130W V389 389 D389 389 M 280-15 SB-BU 097-668-900
390 390 SR1130SW V390 390 D390 390 — 280-24 SB-AU 099-207-300
391* 391 SR1120W V391 391 D391 391 L 280-30 SB-BS/ES 097-669-800
392* 392 SR41W V392 392 D392 392 K 280-13 SB-B1 097-670-500
396* 396 SR726W V396 396 D396 396 V 280-52 SB-BL 099-208-200
LR 9 –– EPX625G –– –– –– –– –– –– –– 090-076-000
LR44 A76 LR44 V13GA RW82 LR44 A76 — 280-904 SB-F9 097-676-900
CR2016 CR/BR2016 CR/BR2016 CR2016 CR/BR2016 DL2016 CR2016 FA 280-202/4/6 SB-T11 096-095-400
CR2025 CR2025 CR2025 CR2025 CR2025 DL2025 CR2025 NA 280-205 SB-T14 096-096-300
0910 466-440-1 E