Beruflich Dokumente
Kultur Dokumente
Advantage Operation
• touchless measuring principle • Relay version
• optional for distance, volume and level measurement · by the display and control module (Display)
• optional with current or relay output • 4-wire current version
· through the integrated potentiometer
Intended Use · optional by the display and control module (Display)
• The UFM is an ultrasonic sensor for continuous touchless level • 2-wire current version
measurement of fluids. · by the on-board mounted push buttons
Application Connection Head
• In containers or tanks in virtually all industries. • housing: PP, fiberglass-reinforced
• Suitable for neutral and aggressive liquids if the wetted parts of • housing cover: PP, fiberglass-reinforced
the sensor are resistant against the medium (medium vapor) in • housing seal: NBR
accordance with the ASV-resistance chart.
• Not suitable for foaming media. Sensor
• sensor housing: PVDF
Function • sensor seal: FPM
• The sensor consists of an ultrasonic transducer which
continuously transmits short ultrasonic pulses to the surface of Process Connection
the medium. The pulses are received by the sensor as echoes. • threaded port: 1 1/2 inch
• The time between the transmission and receipt of the pulses is
measured. This time is proportional to the distance and therefore Measuring Principle
to the filling height of the medium. The conversion of the values • ultrasonic
into e.g. distance, filling height and volume is done by a Measuring Value
processor in the connection head. • filling level
• The output values can be indicated by LCD and/or transmitted • dead zone: 0,25 m
via the respective outputs. • measuring resolution ≤ 1mm
• Versions with 4 freely programmable relay outputs, a 4-wire • precision ±0,2%FS
current version or a 2-wire current version are available. • temperature faults max. 0,04 % /K
• In the two-wire version, the same wires are used for the measured • ultrasonic frequency 75 kHz
value output and the voltage supply. • beam angle (-3dB) 14°
Version • measuring interval 1,4 sec
• Relay version: [Relay] Measuring Range
• 4-wire current version [4 Curent] • 0,25 - 6 m
• 2-wire current version [2 Curent]
Power Supply
Output Signal • 18 ... 30 VDC
• Relay version:
· 4 relays, NO, 8 A/ 230 VAC Connection Cable
· switching function NC/ NO programmable • cable outer diameter of 7...13 mm
• 4-wire current version : • nominal cross-section 1.5 mm²
· 0/4 ... 20 mA
Type Of Protection
· min.-/ max. filling level is adjustable
• connection housing: IP67
• 2-wire current version
• sensor housing: IP68
· 4 ... 20 mA
· min.-/ max. filling level is adjustable Process Temperature
• -20 ... +70°C
Ambient Temperature
• -20 ... +70°C
> data sheet no.: 330620 - 2012/03/15 All rights for technical modifications withheld 1
ASV Stübbe GmbH & Co. KG · Hollwieser Str. 5 · D-32602 Vlotho · Tel. +49(0)5733. 799-0 · Fax +49(0)5733. 799-5000 · contact@asv-stuebbe.de · www.asv-stuebbe.de
Process Pressure Display And Control Unit (Display)
• 0,8 ... 1,1 bar • housing: ABS
• housing cover: PA, transparent
Ambient Pressure • display: illuminated LC-Display
• 0,8 ... 1,1 bar • operating: via 4 function keys
Relative Humidity • front film: polyester
• 20 ... 85% • the display is necessary for setting the relay version
• parameter settings can be saved and copied onto other sensors
Mounting Position • after setting the unit the display can be removed from the sensor
• Vertical housing
Accessories
• Display and control module (Display)
Ident-no.: 141032
2 All rights for technical modifications withheld > data sheet no.: 330620 - 2012/03/15
ASV Stübbe GmbH & Co. KG · Hollwieser Str. 5 · D-32602 Vlotho · Tel. +49(0)5733. 799-0 · Fax +49(0)5733. 799-5000 · contact@asv-stuebbe.de · www.asv-stuebbe.de
Level measurement, Ultrasonic Filling Level Sensor UFM
> data sheet no.: 330620 - 2012/03/15 All rights for technical modifications withheld 3
ASV Stübbe GmbH & Co. KG · Hollwieser Str. 5 · D-32602 Vlotho · Tel. +49(0)5733. 799-0 · Fax +49(0)5733. 799-5000 · contact@asv-stuebbe.de · www.asv-stuebbe.de
Level measurement, Ultrasonic Filling Level Sensor UFM
4 All rights for technical modifications withheld > data sheet no.: 330620 - 2012/03/15
ASV Stübbe GmbH & Co. KG · Hollwieser Str. 5 · D-32602 Vlotho · Tel. +49(0)5733. 799-0 · Fax +49(0)5733. 799-5000 · contact@asv-stuebbe.de · www.asv-stuebbe.de
Level measurement, Ultrasonic Filling Level Sensor UFM
body PVDF
> data sheet no.: 330620 - 2012/03/15 All rights for technical modifications withheld 5
ASV Stübbe GmbH & Co. KG · Hollwieser Str. 5 · D-32602 Vlotho · Tel. +49(0)5733. 799-0 · Fax +49(0)5733. 799-5000 · contact@asv-stuebbe.de · www.asv-stuebbe.de
Level measurement, Ultrasonic Filling Level Sensor UFM
dimensions
dimensions(mm)
6 All rights for technical modifications withheld > data sheet no.: 330620 - 2012/03/15
ASV Stübbe GmbH & Co. KG · Hollwieser Str. 5 · D-32602 Vlotho · Tel. +49(0)5733. 799-0 · Fax +49(0)5733. 799-5000 · contact@asv-stuebbe.de · www.asv-stuebbe.de