Beruflich Dokumente
Kultur Dokumente
DULUX UNDERCOAT
DESCRIPTION Dulux Undercoat is a premium quality, hard wearing undercoat recommended for
use with Dulux/Caplux Finish
TYPICAL USES Suitable for interior/exterior concrete and wood surfaces over appropriate primers when an
undercoat is required
PRODUCT INFORMATION
Composition
Pigment: Lightfast Non-Lead Pigments
Binder: Alkyd
Solvent: Aliphatic Organic Solvent
Pack Size: 4L
Colour Range: Refer to the appropriate Colour Guide
Volume Solids: 40-45%
Theoretical
Spreading Rate: Up to 15sq.meter per litre on a smooth, non-porous surface
Opacity: 1 Coat
Film Properties
Film Thickness (Wet): 75 microns
APPLICATION INFORMATION
Coverage: Up to 15sqm per litre on non- porous surface can be achieved under normal conditions
Thinning
Brush/Roller: Stir well before application by brush or roller. Apply from container
Conventional Spray: For health and safety reasons relating to solvent based paints, spray application is not
recommended
Cleaning Up: After use, remove as much product as possible from application equipment before cleaning with
Dulux Thinner 41. If you have left over paint, dispose of it responsibly.
SYSTEMS AND COMPATIBILITY
Stir thoroughly before use. Apply 1 coat of Dulux Undercoat over an appropriate primer followed by 2 coats of
Dulux/Caplux Finish
SURFACE PREPARATION
Surfaces must be clean and dry before painting. All surfaces must be clean and free from grease, oil and other
contaminants. Remove all dirt, grease, loose or flaking paint, rust and oxide deposits. New or bare surfaces should
be primed with appropriate primer.
SAFETY INFORMATION
For detailed safety information, refer to the Material Safety Data Sheet
ADDITIONAL INFORMATION
Store in a cool, dry, well ventilated place protected from moisture, away from sources of heat, ignition and direct
sunlight. Containers which are opened should be properly resealed and kept upright to prevent leakage. Do not use
or store any paint container by hanging on a hook. Store separately from oxidizing agents, strongly alkaline
materials, strongly acidic materials, amines, alcohols and water
FURTHER SUPPORT
If you need further support, please contact Chemical & Allied Products Plc on 07098733733
Company Disclaimer: The information contained in the technical data sheet is believed to be accurate and true at the date of issuance but
are subject to change without prior notice. We guarantee our product to conform to the specifications contained herein, however we make no warranty
of merchantability or any other warranty, express or implied, with respect to such information, and liability (if any) resulting from its use is limited to
replacement of the product. In no event shall CAP Plc be liable for any claims, losses, or damages of any third party or for lost profits, labour cost or
any special, indirect, incidental, consequential or exemplary damages, howsoever arising even if CAP Plc has been advised of the possibility of such
damages
ISSUED: 01/16