Beruflich Dokumente
Kultur Dokumente
Bangalore East
Physics Project
AISSCE
Session- 2019-20
Topic: To study the factor on which the Self
Inductance of a coil depends by observing the
effect of this coil, when put in series with a resistor
(bulb) in a circuit fed up by an A.C. source of
adjustable frequency.
Submitted by-
Name- Shirish Ramaiya
ACKNOWLEDGEMENT
I would like to express my special thanks
of gratitude to my teacher Miss Raghy
who gave me the golden opportunity to
do this wonderful project on the topic
which also helped me in doing a lot of
Research and I came to know about so
many new things I am really thankful to
them.
Secondly, I would also like to thank my
parents and friends who helped me a lot
in finalizing this project within the limited
period.
Signature of
Student
Introduction
There are four basic factors of inductor construction determining the
by affecting how much magnetic field flux will develop for a given
coil.
• COIL AREA.
• COIL LENGTH.
• CORE MATERIAL.
INDEX
1: Certificate
2: Acknowledgement
3: Introduction
4: Aim, Apparatus Required,
Theory
5: Circuit Diagram,
Procedure
6: Observations
7: Result, Precautions,
Sources of Error.
Aim
To study the factor on which the Self Inductance of a coil depends by observing the effect of this coil,
when put in series with a resistor (bulb) in a circuit fed up by an A.C. source of adjustable frequency.
Apparatus Required
A coil of large turns, A.C. source of adjustable frequency, an electric bulb, (6 V) A.C. ammeter of suitable
range, rheostat, a soft iron rod, one way key, connecting wires etc.
Theory
Self Inductance is the property of a coil which oppose the change in current through it. The Self
Inductance of a coil (long solenoid) is
L =μ 0 μ r N2 A
I
l= Length of solenoid
When an inductor is connected in series with a resistor (bulb) with a variable source of
frequency, then current flowing in the bulb is
I rms =E rms
Z
½
Where Z= (R2 + ω2L2) =Impedance of the A.C. Circuit
H= I2 rmsZt
Circuit Diagram
Procedure
• Make all connections as shown in circuit diagram.
• Switch on the A.C. supply and adjust the constant current in the circuit by using
the variable resistor (R1) (let frequency of source is 60 Hz and voltage is 6V).
• Record the current in A.C. ammeter and see the brightness of bulb.
• Now, put the soft iron rod inside the inductor core and record the current in A.C.
ammeter and again check the brightness of bulb. The current and brightness
both decreases.
• Now, switch off the supply and decrease the frequency of A.C. source (say 50 Hz).
• Again switch on the supply and adjust the current in circuit at same constant
voltage 6V by using the rheostat. Note the current in ammeter and brightness of
bulb. The current and brightness both will increases.
• Again insert the iron in the core of coil and note the current and brightness. The
current and brightness both decreases.
• Repeat the steps 5, 6 and 7 for different frequency of A.C. source(say 40 Hz,30 Hz
and 20 Hz).
Observations
• Range of ammeter= A.
• The current in the circuit increases on decreasing the frequency of applied voltage and vice-
versa. Therefore, the brightness of bulb increases.
Precautions
• The coil should have large number of turns.
• Current should be passed for a small time to avoid the heating effect.
Sources of Error
• The resistance of circuit may increases slightly due to heating effect of current.