Beruflich Dokumente
Kultur Dokumente
System
Recommended combination
Recommended combination 2
Recommended combination 3
Cooling capacity
Heating capacity
ESEER - Automatic
ESEER - Standard
SCOP
SCOP recommended combination 2
SCOP recommended combination 3
SEER
SEER recommended combination 2
SEER recommended combination 3
ηs,c
ηs,c recommended combination 2
ηs,c recommended combination 3
ηs,h
ηs,h recommended combination 2
ηs,h recommended combination 3
Space cooling
Capacity range
PED
Weight
Packing
Packing 2
Packing 3
Casing
Heat exchanger
Fan
Fan motor
Compressor
Operation range
Refrigerant oil
Piping connections
Defrost method
Capacity control
Indication if the heater is equipped with a supplementary heater
Supplementary heater
Power consumption in other than active mode
Cooling
Heating
Safety devices
Standard Accessories
Power supply
Current
Current - 50Hz
Notes
RXYQ-U
Prated,c
Prated,h
Max.
TBivalent
TOL
A Condition (-7°C)
B Condition (2°C)
C Condition (7°C)
D Condition (12°C)
HP
Category
Most critical part
Min.
Max.
Unit
Packed unit
Unit
Packed unit
Material
Weight
Material
Weight
Material
Weight
Colour
Material
Type
Indoor side
Outdoor side
Air flow rate Cooling
Heating
Quantity
External static pressure
Quantity
Type
Output
Quantity
Type
Crankcase heater
Cooling
Heating
Cooling
Heating
Cooling
Type
GWP
Charge
Charge
Type
Liquid
Gas
Method
Installation manual
Operation manual
Connection pipes
Name
Phase
Frequency
Voltage
Min.
Max.
Nominal running current (RLA) - 50Hz
Starting current (MSC) - remark
Zmax
Minimum Ssc value
Minimum circuit amps (MCA)
Maximum fuse amps (MFA)
Full load amps (FLA)
For power supply
For connection with indoor
6°CWB
EERd
Pdc
EERd
Pdc
EERd
Pdc
EERd
Pdc
Space cooling recommended combination 2-=-A Condition (35°C - 27/19)-=-EERd
Space cooling recommended combination 2-=-A Condition (35°C - 27/19)-=-Pdc-=-kW
Space cooling recommended combination 2-=-B Condition (30°C - 27/19)-=-EERd
Space cooling recommended combination 2-=-B Condition (30°C - 27/19)-=-Pdc-=-kW
Space cooling recommended combination 2-=-C Condition (25°C - 27/19)-=-EERd
Space cooling recommended combination 2-=-C Condition (25°C - 27/19)-=-Pdc-=-kW
Space cooling recommended combination 2-=-D Condition (20°C - 27/19)-=-EERd
Space cooling recommended combination 2-=-D Condition (20°C - 27/19)-=-Pdc-=-kW
Space cooling recommended combination 3-=-A Condition (35°C - 27/19)-=-EERd
Space cooling recommended combination 3-=-A Condition (35°C - 27/19)-=-Pdc-=-kW
Space cooling recommended combination 3-=-B Condition (30°C - 27/19)-=-EERd
Space cooling recommended combination 3-=-B Condition (30°C - 27/19)-=-Pdc-=-kW
Space cooling recommended combination 3-=-C Condition (25°C - 27/19)-=-EERd
Space cooling recommended combination 3-=-C Condition (25°C - 27/19)-=-Pdc-=-kW
Space cooling recommended combination 3-=-D Condition (20°C - 27/19)-=-EERd
Space cooling recommended combination 3-=-D Condition (20°C - 27/19)-=-Pdc-=-kW
COPd (declared COP)
Pdh (declared heating cap)
Tbiv (bivalent temperature)
COPd (declared COP)
Pdh (declared heating cap)
Tol (temperature operating limit)
COPd (declared COP)
Pdh (declared heating cap)
COPd (declared COP)
Pdh (declared heating cap)
COPd (declared COP)
Pdh (declared heating cap)
COPd (declared COP)
Pdh (declared heating cap)
Space heating (Average climate) recommended combination 2-=-A Condition (-7°C)-=-COPd (declared COP)
Space heating (Average climate) recommended combination 2-=-A Condition (-7°C)-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 2-=-B Condition (2°C)-=-COPd (declared COP)
Space heating (Average climate) recommended combination 2-=-B Condition (2°C)-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 2-=-C Condition (7°C)-=-COPd (declared COP)
Space heating (Average climate) recommended combination 2-=-C Condition (7°C)-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 2-=-D Condition (12°C)-=-COPd (declared COP)
Space heating (Average climate) recommended combination 2-=-D Condition (12°C)-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 2-=-TBivalent-=-COPd (declared COP)
Space heating (Average climate) recommended combination 2-=-TBivalent-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 2-=-TBivalent-=-Tbiv (bivalent temperature)-=-°C
Space heating (Average climate) recommended combination 2-=-TOL-=-COPd (declared COP)
Space heating (Average climate) recommended combination 2-=-TOL-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 2-=-TOL-=-Tol (temperature operating limit)-=-°C
Space heating (Average climate) recommended combination 3-=-A Condition (-7°C)-=-COPd (declared COP)
Space heating (Average climate) recommended combination 3-=-A Condition (-7°C)-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 3-=-B Condition (2°C)-=-COPd (declared COP)
Space heating (Average climate) recommended combination 3-=-B Condition (2°C)-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 3-=-C Condition (7°C)-=-COPd (declared COP)
Space heating (Average climate) recommended combination 3-=-C Condition (7°C)-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 3-=-D Condition (12°C)-=-COPd (declared COP)
Space heating (Average climate) recommended combination 3-=-D Condition (12°C)-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 3-=-TBivalent-=-COPd (declared COP)
Space heating (Average climate) recommended combination 3-=-TBivalent-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 3-=-TBivalent-=-Tbiv (bivalent temperature)-=-°C
Space heating (Average climate) recommended combination 3-=-TOL-=-COPd (declared COP)
Space heating (Average climate) recommended combination 3-=-TOL-=-Pdh (declared heating cap)-=-kW
Space heating (Average climate) recommended combination 3-=-TOL-=-Tol (temperature operating limit)-=-°C
Name
Ps*V
Height
Width
Depth
Height
Width
Depth
Rated
Rated
Max.
Min.
Max.
Min.
Max.
Nom.
Nom.
Nom.
Type
OD
Type
OD
Actual
elbu
PCK
PCK
POFF
POFF
PSB
PSB
PTO
PTO
01
02
03
04
05
Cooling
List
Total
Quantity
Quantity
Remark
kW
kW
kW
kW
kW
kW
kW
kW
kW
kW
kW
kW
kW
kW
kW
kW
°C
kW
°C
kW
kW
kW
kW
kW
kW
kW
kW
kW
°C
kW
°C
kW
kW
kW
kW
kW
°C
kW
°C
Bar*l
mm
mm
mm
mm
mm
mm
kg
kg
kg
kg
kg
m³/h
m³/h
Pa
W
°CDB
°CDB
°CWB
°CWB
dBA
dBA
dBA
TCO2Eq
kg
mm
mm
m
kW
kW
kW
kW
kW
kW
kW
kW
kW
Hz
V
%
%
A
kVa
A
A
A
RXYQ8U7Y1B
4 x FXFQ50AVEB
4 x FXSQ50A2VEB
4 x FXMQ50P7VEB
22.4 (1)
13.7
25.0 (2)
7.53
6.37
4.3
4.2
4.2
7.6
6.9
7.5
302.4
273.6
295.2
167.9
165.4
165.6
3.0
22.4
5.2
16.5
9.5
10.6
18.8
8.0
2.6
22.4
4.9
16.5
8.8
10.6
15.1
8.8
3.0
22.4
5.1
16.5
9.6
10.6
16.0
9.1
2.5
13.7
-10
2.5
13.7
-10
2.7
12.1
3.9
7.4
6.3
5.0
7.9
5.9
2.7
12.1
3.9
7.4
6.3
5.0
7.8
5.9
2.4
13.7
-10
2.4
13.7
-10
2.7
12.1
3.9
7.4
6.2
4.9
7.8
5.8
2.5
13.7
-10
2.5
13.7
-10
8
Category II
Accumulator
325
64 (3)
100.0
260.0
1,685
930
765
1,820
995
860
198
211
Carton
1.8
Wood
11.0
Plastic
0.5
Daikin White
Painted galvanized steel plate
Cross fin coil
Air
Air
9,720
9,720
1
78
1
DC motor
550
1
Hermetically sealed scroll compre
33
-5.0
43.0
-20.0
15.5
78.0 (4)
62.7 (4)
57.0 (5)
R-410A
2,087.5
12.3
5.9
Synthetic (ether) oil FVC68D
Braze connection
9,52
Braze connection
19.1
1,000 (6)
Reversed cycle
Inverter controlled
no
0.0
0.000
0.052
0.041
0.052
0.041
0.052
0.005
0.056
0.25
0.25
High pressure switch
Fan driver overload protecto
Inverter overload protector
PC board fuse
Leakage current detector
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
7.2 (7)
See note 8
No requirements
4,050 (9.000)
16.1 (10)
20 (11)
1.2 (12)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ10U7Y1B
4 x FXFQ63AVEB
4 x FXSQ63A2VEB
4 x FXMQ63P7VEB
28.0 (1)
16.0
31.5 (2)
7.20
5.67
4.3
4.3
4.1
6.8
6.8
6.8
267.6
270.5
267.1
168.2
170.6
162.0
2.3
28.0
4.7
20.6
8.3
13.3
17.0
9.3
2.4
28.0
4.7
20.6
8.5
13.3
17.2
9.3
2.3
28.0
4.7
20.6
8.4
13.3
16.9
9.3
2.4
16.0
-10
2.4
16.0
-10
2.6
14.2
3.9
8.6
6.4
5.5
8.2
5.9
2.7
14.2
4.0
8.6
6.5
5.5
8.3
6.0
2.4
16.0
-10
2.4
16.0
-10
2.6
14.2
3.7
8.6
6.4
5.5
8.1
5.9
2.4
16.0
-10
2.4
16.0
-10
10
Category II
Accumulator
325
64 (3)
125.0
325.0
1,685
930
765
1,820
995
860
198
211
Carton
1.8
Wood
11.0
Plastic
0.5
Daikin White
Painted galvanized steel plate
Cross fin coil
Air
Air
10,500
10,500
1
78
1
DC motor
550
1
Hermetically sealed scroll compre
33
-5.0
43.0
-20.0
15.5
79.1 (4)
64.8 (4)
57.0 (5)
R-410A
2,087.5
12.5
6.0
Synthetic (ether) oil FVC68D
Braze connection
9,52
Braze connection
22.2
1,000 (6)
Reversed cycle
Inverter controlled
no
0.0
0.000
0.052
0.041
0.052
0.041
0.052
0.005
0.056
0.25
0.25
High pressure switch
Fan driver overload protecto
Inverter overload protector
PC board fuse
Leakage current detector
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
10.2 (7)
See note 8
No requirements
5,535 (9.000)
22.0 (10)
25 (11)
1.3 (12)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ12U7Y1B
6 x FXFQ50AVEB
6 x FXSQ50A2VEB
6 x FXMQ50P7VEB
33.5 (1)
18.4
37.5 (2)
6.96
5.50
4.1
4.1
4.1
6.3
5.9
6.2
247.8
233.5
246.3
161.4
161.3
160.6
2.4
33.5
4.3
24.7
7.7
15.9
13.9
9.4
2.4
33.5
4.0
24.7
7.1
15.9
13.1
9.1
2.4
33.5
4.2
24.7
7.7
15.9
13.7
9.4
2.0
18.4
-10
2.0
18.4
-10
2.4
16.3
3.9
9.9
6.1
6.4
7.9
6.3
2.4
16.3
3.9
9.9
6.1
6.4
7.9
6.4
1.9
18.4
-10
1.9
18.4
-10
2.4
16.3
3.9
9.9
6.0
6.4
7.8
6.2
2.0
18.4
-10
2.0
18.4
-10
12
Category II
Accumulator
325
64 (3)
150.0
390.0
1,685
930
765
1,820
995
860
198
211
Carton
1.8
Wood
11.0
Plastic
0.5
Daikin White
Painted galvanized steel plate
Cross fin coil
Air
Air
11,100
11,100
1
78
1
DC motor
550
1
Hermetically sealed scroll compre
33
-5.0
43.0
-20.0
15.5
83.4 (4)
64.9 (4)
61.0 (5)
R-410A
2,087.5
13.2
6.3
Synthetic (ether) oil FVC68D
Braze connection
12,7
Braze connection
28.6
1,000 (6)
Reversed cycle
Inverter controlled
no
0.0
0.000
0.052
0.041
0.052
0.041
0.052
0.005
0.056
0.25
0.25
High pressure switch
Fan driver overload protecto
Inverter overload protector
PC board fuse
Leakage current detector
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
12.7 (7)
See note 8
No requirements
6,038 (9.000)
24.0 (10)
32 (11)
1.5 (12)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ14U7Y1B
1 x FXFQ50AVEB + 5 x FXFQ63AV
1 x FXSQ50A2VEB + 5 x FXSQ63A2
1 x FXMQ50P7VEB + 5 x FXMQ63P
40.0 (1)
20.6
45.0 (2)
6.83
5.31
4.0
4.0
4.0
6.3
6.3
6.2
250.7
250.0
246.7
155.4
157.2
155.7
2.6
40.0
4.1
29.5
7.8
18.9
14.3
8.4
2.6
40.0
4.1
29.5
7.9
18.9
14.0
8.4
2.6
40.0
4.0
29.5
7.7
19.0
14.0
8.4
2.3
20.6
-10
2.3
20.6
-10
2.6
18.2
3.5
11.1
6.1
7.1
8.5
4.9
2.6
18.2
3.5
11.1
6.1
7.1
8.6
4.9
2.3
20.6
-10
2.3
20.6
-10
2.6
18.2
3.5
11.1
6.1
7.1
8.5
4.9
2.3
20.6
-10
2.3
20.6
-10
14
Category II
Accumulator
415
64 (3)
175.0
455.0
1,685
1,240
765
1,820
1,305
860
275
291
Carton
2.2
Wood
14.0
Plastic
0.6
Daikin White
Painted galvanized steel plate
Cross fin coil
Air
Air
13,380
13,380
2
78
2
DC motor
750
2
Hermetically sealed scroll compre
33
-5.0
43.0
-20.0
15.5
80.9 (4)
68.3 (4)
60.0 (5)
R-410A
2,087.5
21.5
10.3
Synthetic (ether) oil FVC68D
Braze connection
12,7
Braze connection
28.6
1,000 (6)
Reversed cycle
Inverter controlled
no
0.0
0.000
0.077
0.074
0.077
0.074
0.077
0.010
0.097
0.25
0.25
High pressure switch
Fan driver overload protecto
Inverter overload protector
PC board fuse
Leakage current detector
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
15.4 (7)
See note 8
No requirements
6,793 (9.000)
27.0 (10)
32 (11)
1.8 (12)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ16U7Y1B
4 x FXFQ63AVEB + 2 x FXFQ80AV
4 x FXSQ63A2VEB + 2 x FXSQ80A2
4 x FXMQ63P7VEB + 2 x FXMQ80P
45.0 (1)
23.2
50.0 (2)
6.50
5.05
4.0
4.1
4.0
6.0
5.9
5.8
236.5
234.2
230.4
157.8
159.5
156.8
2.1
45.0
3.9
33.2
7.7
21.3
14.2
9.5
2.1
45.0
3.8
33.2
7.6
21.3
14.0
9.5
2.1
45.0
3.7
33.2
7.4
21.3
14.1
9.5
2.2
23.2
-10
2.2
23.2
-10
2.6
20.5
3.5
12.5
6.3
8.0
8.6
4.9
2.6
20.5
3.5
12.2
6.3
8.0
8.7
5.0
2.2
23.2
-10
2.2
23.2
-10
2.6
20.5
3.5
12.5
6.2
8.0
8.6
4.9
2.2
23.2
-10
2.2
23.2
-10
16
Category II
Accumulator
415
64 (3)
200.0
520.0
1,685
1,240
765
1,820
1,305
860
275
291
Carton
2.2
Wood
14.0
Plastic
0.6
Daikin White
Painted galvanized steel plate
Cross fin coil
Air
Air
15,600
15,600
2
78
2
DC motor
750
2
Hermetically sealed scroll compre
33
-5.0
43.0
-20.0
15.5
85.6 (4)
68.6 (4)
63.0 (5)
R-410A
2,087.5
23.6
11.3
Synthetic (ether) oil FVC68D
Braze connection
12,7
Braze connection
28.6
1,000 (6)
Reversed cycle
Inverter controlled
no
0.0
0.000
0.077
0.074
0.077
0.074
0.077
0.010
0.097
0.25
0.25
High pressure switch
Fan driver overload protecto
Inverter overload protector
PC board fuse
Leakage current detector
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
18.0 (7)
See note 8
No requirements
7,547 (9.000)
31.0 (10)
40 (11)
2.6 (12)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ18U7Y1B
3 x FXFQ50AVEB + 5 x FXFQ63AV
3 x FXSQ50A2VEB + 5 x FXSQ63A2
3 x FXMQ50P7VEB + 5 x FXMQ63P
50.4 (1)
27.9
56.5 (2)
6.38
4.97
4.2
4.2
4.1
6.0
6.0
6.0
238.3
236.8
238.2
163.1
164.8
159.6
1.9
50.4
3.8
37.1
7.5
23.9
18.3
11.5
1.9
50.4
3.7
37.1
7.5
23.9
18.1
11.4
1.9
50.4
3.7
37.1
7.6
23.9
18.3
11.6
1.9
27.9
-10
1.9
27.9
-10
2.4
24.7
3.7
15.0
6.7
9.7
9.0
7.1
2.4
24.7
3.8
15.0
6.8
9.7
9.1
7.2
1.9
27.9
-10
1.9
27.9
-10
2.4
24.7
3.7
15.0
6.5
9.7
8.7
6.9
1.9
27.9
-10
1.9
27.9
-10
18
Category II
Accumulator
493
64 (3)
225.0
585.0
1,685
1,240
765
1,820
1,305
860
308
324
Carton
2.2
Wood
14.0
Plastic
0.6
Daikin White
Painted galvanized steel plate
Cross fin coil
Air
Air
15,060
15,060
2
78
2
DC motor
750
2
Hermetically sealed scroll compre
33
-5.0
43.0
-20.0
15.5
83.8 (4)
66.3 (4)
62.0 (5)
R-410A
2,087.5
24.4
11.7
Synthetic (ether) oil FVC68D
Braze connection
15,9
Braze connection
28.6
1,000 (6)
Reversed cycle
Inverter controlled
no
0.0
0.000
0.089
0.075
0.089
0.075
0.089
0.010
0.098
0.25
0.25
High pressure switch
Fan driver overload protecto
Inverter overload protector
PC board fuse
Leakage current detector
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
20.8 (7)
See note 8
No requirements
8,805 (9.000)
35.0 (10)
40 (11)
2.6 (12)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ20U7Y1B
2 x FXFQ50AVEB + 6 x FXFQ63AV
2 x FXSQ50A2VEB + 6 x FXSQ63A2
2 x FXMQ50P7VEB + 6 x FXMQ63P
52.0 (1)
31.0
63.0 (2)
5.67
4.42
4.0
4.0
3.9
5.9
5.9
5.9
233.7
233.9
233.1
156.6
158.2
153.4
1.9
52.0
3.7
38.3
7.3
24.6
18.3
11.5
1.9
52.0
3.6
38.3
7.3
24.6
18.9
10.9
1.9
52.0
3.6
38.3
7.3
24.6
18.3
11.6
1.8
31.0
-10
1.8
31.0
-10
2.1
27.4
3.6
16.7
6.5
10.7
9.1
7.1
2.2
27.4
3.7
16.7
6.5
10.7
9.2
7.2
1.8
31.0
-10
1.8
31.0
-10
2.1
27.4
3.6
16.7
6.3
10.7
8.7
6.9
1.8
31.0
-10
1.8
31.0
-10
20
Category II
Accumulator
493
64 (3)
250.0
650.0
1,685
1,240
765
1,820
1,305
860
308
324
Carton
2.2
Wood
14.0
Plastic
0.6
Daikin White
Painted galvanized steel plate
Cross fin coil
Air
Air
15,660
15,660
2
78
2
DC motor
750
2
Hermetically sealed scroll compre
33
-5.0
43.0
-20.0
15.5
87.9 (4)
67.0 (4)
65.0 (5)
R-410A
2,087.5
24.6
11.8
Synthetic (ether) oil FVC68D
Braze connection
15,9
Braze connection
28.6
1,000 (6)
Reversed cycle
Inverter controlled
no
0.0
0.000
0.089
0.075
0.089
0.075
0.089
0.010
0.098
0.25
0.25
High pressure switch
Fan driver overload protecto
Inverter overload protector
PC board fuse
Leakage current detector
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
26.9 (7)
See note 8
No requirements
9,812 (9.000)
39.0 (10)
50 (11)
2.6 (12)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ22U7Y1B
RXYQ10U
RXYQ12U
6 x FXFQ50AVEB + 4 x FXFQ63AV
6 x FXSQ50A2VEB + 4 x FXSQ63A2
6 x FXMQ50P7VEB + 4 x FXMQ63P
61.5 (1)
34.4
69.0 (2)
7.07
5.58
4.4
4.4
4.3
6.9
6.7
6.9
274.5
266.5
273.3
171.2
172.3
170.2
2.6
61.5
4.8
45.3
8.5
29.1
16.0
18.8
2.6
61.5
4.6
45.3
8.2
29.1
15.6
18.4
2.5
61.5
4.8
45.3
8.5
29.1
15.8
18.8
2.3
34.4
-10
2.3
34.4
-10
2.6
30.4
4.0
18.5
6.3
11.9
8.2
6.0
2.6
30.4
4.1
18.5
6.3
11.9
8.4
6.0
2.2
34.4
-10
2.2
34.4
-10
2.6
30.4
4.0
18.5
6.2
11.9
8.2
6.0
2.3
34.4
-10
2.3
34.4
-10
22
Category II
64 (3)
275.0
715.0
Air
Air
21,600
21,600
84.8 (4)
67.8 (4)
62.5 (5)
R-410A
2,087.5
no
0.0
0.000
0.103
0.081
0.103
0.081
0.103
0.009
0.113
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
22.9 (7)
See note 8
No requirements
11,573 (9.000)
46.0 (10)
63 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ24U7Y1B
RXYQ8U
RXYQ16U
4 x FXFQ50AVEB + 4 x FXFQ63AVEB + 2 x
4 x FXSQ50A2VEB + 4 x FXSQ63A2VEB + 2 x
4 x FXMQ50P7VEB + 4 x FXMQ63P7VEB + 2 x
67.4 (1)
36.9
75.0 (2)
6.81
5.42
4.3
4.3
4.2
6.8
6.6
6.7
269.9
262.6
265.3
167.0
167.1
165.5
2.5
67.4
4.6
49.7
8.6
31.9
15.2
15.8
2.4
67.4
4.5
49.7
8.4
31.9
14.7
15.4
2.5
67.4
4.5
49.7
8.4
31.9
15.2
15.7
2.5
36.9
-10
2.5
36.9
-10
2.8
32.6
3.7
19.9
6.3
13.0
8.9
5.7
2.7
32.6
3.7
19.9
6.3
13.1
9.0
5.7
2.4
36.9
-10
2.4
36.9
-10
2.7
32.6
3.7
19.9
6.3
12.9
8.9
5.7
2.4
36.9
-10
2.4
36.9
-10
24
Category II
64 (3)
300.0
780.0
Air
Air
25,320
25,320
86.3 (4)
69.6 (4)
64.0 (5)
R-410A
2,087.5
no
0.0
0.000
0.129
0.115
0.129
0.115
0.129
0.014
0.154
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
25.2 (7)
See note 8
No requirements
11,597 (9.000)
46.0 (10)
63 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ26U7Y1B
RXYQ12U
RXYQ14U
7 x FXFQ50AVEB + 5 x FXFQ63AV
7 x FXSQ50A2VEB + 5 x FXSQ63A2
7 x FXMQ50P7VEB + 5 x FXMQ63P
73.5 (1)
39.0
82.5 (2)
6.89
5.39
4.2
4.2
4.2
6.7
6.5
6.6
264.2
256.1
261.1
164.6
165.4
164.5
2.6
73.5
4.6
54.2
8.2
34.8
14.2
16.2
2.6
73.5
4.4
54.1
7.9
34.8
13.6
15.7
2.5
73.5
4.5
54.2
8.1
34.8
14.0
16.0
2.3
39.0
-10
2.3
39.0
-10
2.6
34.5
3.8
21.0
6.1
13.5
8.8
6.0
2.6
34.5
3.8
21.0
6.1
13.1
8.9
6.0
2.2
39.0
-10
2.2
39.0
-10
2.6
34.5
3.8
21.0
6.1
13.5
8.8
6.0
2.2
39.0
-10
2.2
39.0
-10
26
Category II
64 (3)
325.0
845.0
Air
Air
24,480
24,480
85.3 (4)
69.9 (4)
63.5 (5)
R-410A
2,087.5
no
0.0
0.000
0.129
0.115
0.129
0.115
0.129
0.014
0.154
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
28.1 (7)
See note 8
No requirements
12,831 (9.000)
51.0 (10)
63 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ28U7Y1B
RXYQ12U
RXYQ16U
6 x FXFQ50AVEB + 4 x FXFQ63AVEB + 2 x
6 x FXSQ50A2VEB + 4 x FXSQ63A2VEB + 2 x
6 x FXMQ50P7VEB + 4 x FXMQ63P7VEB + 2 x
78.5 (1)
41.6
87.5 (2)
6.69
5.23
4.2
4.2
4.2
6.5
6.3
6.4
257.8
249.3
253.1
166.0
166.8
165.0
2.3
78.5
4.4
57.8
8.1
37.2
14.3
16.5
2.3
78.5
4.3
57.8
7.8
37.2
13.8
16.5
2.3
78.5
4.3
57.8
8.0
37.2
14.1
16.6
2.2
41.6
-10
2.2
41.6
-10
2.6
36.8
3.8
22.4
6.2
14.4
9.0
6.4
2.6
36.8
3.8
22.4
6.3
14.4
9.1
6.4
2.2
41.6
-10
2.2
41.6
-10
2.6
36.8
3.8
22.4
6.2
14.4
9.0
6.4
2.2
41.6
-10
2.2
41.6
-10
28
Category II
64 (3)
350.0
910.0
Air
Air
26,700
26,700
87.6 (4)
70.1 (4)
65.1 (5)
R-410A
2,087.5
no
0.0
0.000
0.129
0.115
0.129
0.115
0.129
0.014
0.154
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
30.7 (7)
See note 8
No requirements
13,585 (9.000)
55.0 (10)
63 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ30U7Y1B
RXYQ12U
RXYQ18U
9 x FXFQ50AVEB + 5 x FXFQ63AV
9 x FXSQ50A2VEB + 5 x FXSQ63A2
9 x FXMQ50P7VEB + 5 x FXMQ63P
83.9 (1)
46.3
94.0 (2)
6.60
5.17
4.3
4.3
4.3
6.5
6.3
6.5
256.8
249.8
256.1
169.8
170.6
167.0
2.1
83.9
4.3
61.8
8.2
39.7
16.8
21.0
2.1
83.9
4.2
61.8
7.9
39.7
16.1
20.5
2.1
83.9
4.3
61.8
8.2
39.7
16.6
21.0
2.1
46.3
-10
2.1
46.3
-10
2.6
41.0
3.9
24.9
6.5
16.0
9.0
7.1
2.6
41.0
3.9
24.9
6.6
16.0
9.1
7.2
2.1
46.3
-10
2.1
46.3
-10
2.5
41.0
3.9
24.9
6.3
16.0
8.6
7.1
2.1
46.3
-10
2.1
46.3
-10
30
Category II
64 (3)
375.0
975.0
Air
Air
26,160
26,160
86.6 (4)
68.7 (4)
64.5 (5)
R-410A
2,087.5
no
0.0
0.000
0.141
0.116
0.141
0.116
0.141
0.014
0.155
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
33.5 (7)
See note 8
No requirements
14,843 (9.000)
59.0 (10)
80 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ32U7Y1B
RXYQ16U
RXYQ16U
8 x FXFQ63AVEB + 4 x FXFQ80AV
8 x FXSQ63A2VEB + 4 x FXSQ80A2
8 x FXMQ63P7VEB + 4 x FXMQ80P
90.0 (1)
46.4
100.0 (2)
6.50
5.05
4.2
4.2
4.1
6.4
6.3
6.2
251.7
248.3
244.2
163.1
164.6
161.9
2.3
90.0
4.3
66.3
8.1
42.6
14.3
19.0
2.2
90.0
4.2
66.3
8.0
42.6
14.0
18.9
2.2
90.0
4.1
66.3
7.8
42.6
13.8
19.0
2.4
46.4
-10
2.4
46.4
-10
2.7
41.0
3.6
25.0
6.3
16.1
9.0
7.1
2.7
41.0
3.6
25.0
6.3
16.1
9.1
7.1
2.4
46.4
-10
2.4
46.4
-10
2.7
41.0
3.6
25.0
6.3
16.1
9.0
7.1
2.4
46.4
-10
2.4
46.4
-10
32
Category II
64 (3)
400.0
1,040.0
Air
Air
31,200
31,200
88.6 (4)
71.6 (4)
66.0 (5)
R-410A
2,087.5
no
0.0
0.000
0.154
0.149
0.154
0.149
0.154
0.019
0.195
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
36.0 (7)
See note 8
No requirements
15,094 (9.000)
62.0 (10)
80 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ34U7Y1B
RXYQ16U
RXYQ18U
3 x FXFQ50AVEB + 9 x FXFQ63AVEB + 2 x
3 x FXSQ50A2VEB + 9 x FXSQ63A2VEB + 2 x
3 x FXMQ50P7VEB + 9 x FXMQ63P7VEB + 2 x
95.4 (1)
51.1
106.5 (2)
6.44
5.01
4.2
4.3
4.2
6.4
6.3
6.3
253.3
250.9
249.8
166.2
167.7
164.2
2.1
95.4
4.2
70.3
8.1
45.2
16.8
20.1
2.1
95.4
4.2
70.3
8.1
45.2
16.5
20.1
2.1
95.4
4.1
70.3
8.0
45.2
16.6
20.1
2.2
51.1
-10
2.2
51.1
-10
2.6
45.2
3.7
27.5
6.5
17.7
8.8
7.9
2.6
45.2
3.8
27.5
6.6
17.7
8.9
7.9
2.2
51.1
-10
2.2
51.1
-10
2.6
45.2
3.7
27.5
6.4
17.7
8.9
7.9
2.2
51.1
-10
2.2
51.1
-10
34
Category II
64 (3)
425.0
1,105.0
Air
Air
30,660
30,660
87.8 (4)
70.6 (4)
65.5 (5)
R-410A
2,087.5
no
0.0
0.000
0.166
0.150
0.166
0.150
0.166
0.019
0.196
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
38.8 (7)
See note 8
No requirements
16,352 (9.000)
66.0 (10)
80 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ36U7Y1B
RXYQ16U
RXYQ20U
2 x FXFQ50AVEB + 10 x FXFQ63AVEB + 2 x
2 x FXSQ50A2VEB + 10 x FXSQ63A2VEB + 2 x
2 x FXMQ50P7VEB + 10 x FXMQ63P7VEB + 2
97.0 (1)
54.2
113.0 (2)
6.02
4.68
4.1
4.2
4.1
6.3
6.3
6.3
250.8
248.7
247.2
162.4
164.1
159.9
2.1
97.0
4.1
71.5
7.9
45.9
16.7
20.4
2.1
97.0
4.1
71.5
7.9
45.9
16.5
20.4
2.1
97.0
4.0
71.5
7.8
45.9
16.5
20.4
2.1
54.2
-10
2.1
54.2
-10
2.5
47.9
3.7
29.2
6.4
18.8
8.6
8.3
2.5
47.9
3.7
29.2
6.5
18.8
8.8
8.3
2.2
54.2
-10
2.2
54.2
-10
2.4
47.9
3.6
29.2
6.3
18.8
8.3
8.3
2.1
54.2
-10
2.1
54.2
-10
36
Category II
64 (3)
450.0
1,170.0
Air
Air
31,260
31,260
89.9 (4)
70.9 (4)
67.1 (5)
R-410A
2,087.5
no
0.0
0.000
0.166
0.150
0.166
0.150
0.166
0.019
0.196
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
44.9 (7)
See note 8
No requirements
17,359 (9.000)
70.0 (10)
80 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ38U7Y1B
RXYQ8U
RXYQ10U
RXYQ20U
6 x FXFQ50AVEB + 10 x FXFQ63A
6 x FXSQ50A2VEB + 10 x FXSQ63A
6 x FXMQ50P7VEB + 10 x FXMQ63
102.4 (1)
60.7
119.5 (2)
6.36
5.03
4.3
4.3
4.2
6.9
6.8
6.9
272.4
269.2
272.2
167.5
168.4
164.8
2.4
102.4
4.5
75.5
8.5
48.5
17.9
21.6
2.3
102.4
4.5
75.4
8.4
48.5
17.8
21.6
2.4
102.4
4.5
75.5
8.5
48.5
17.9
21.6
2.2
60.7
-10
2.2
60.7
-10
2.5
53.7
3.9
32.7
6.5
21.3
8.7
13.1
2.5
53.7
3.9
32.7
6.5
21.3
8.8
13.2
2.3
60.7
-10
2.3
60.7
-10
2.5
53.7
3.8
32.7
6.3
21.2
8.5
12.9
2.2
60.7
-10
2.2
60.7
-10
38
Category II
64 (3)
475.0
1,235.0
Air
Air
35,880
35,880
88.8 (4)
69.9 (4)
66.2 (5)
R-410A
2,087.5
no
0.0
0.000
0.192
0.157
0.192
0.157
0.192
0.019
0.211
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
44.3 (7)
See note 8
No requirements
19,397 (9.000)
76.0 (10)
100 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ40U7Y1B
RXYQ10U
RXYQ12U
RXYQ18U
9 x FXFQ50AVEB + 9 x FXFQ63AV
9 x FXSQ50A2VEB + 9 x FXSQ63A2
9 x FXMQ50P7VEB + 9 x FXMQ63P
111.9 (1)
62.3
125.5 (2)
6.74
5.29
4.3
4.4
4.3
6.7
6.6
6.7
263.5
259.2
263.2
170.0
171.3
167.8
2.2
111.9
4.5
82.5
8.3
53.0
16.0
23.6
2.2
111.9
4.4
82.4
8.1
53.0
15.9
23.6
2.2
111.9
4.4
82.5
8.4
53.0
16.1
23.6
2.2
62.3
-10
2.2
62.3
-10
2.6
55.1
4.0
33.5
6.5
21.6
8.7
13.1
2.6
55.1
4.0
33.5
6.5
21.6
8.8
13.2
2.2
62.3
-10
2.2
62.3
-10
2.6
55.1
3.9
33.5
6.4
21.6
8.4
12.8
2.2
62.3
-10
2.2
62.3
-10
40
Category II
64 (3)
500.0
1,300.0
Air
Air
36,660
36,660
87.3 (4)
70.2 (4)
65.2 (5)
R-410A
2,087.5
no
0.0
0.000
0.192
0.157
0.192
0.157
0.192
0.019
0.211
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
43.7 (7)
See note 8
No requirements
20,378 (9.000)
81.0 (10)
100 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ42U7Y1B
RXYQ10U
RXYQ16U
RXYQ16U
12 x FXFQ63AVEB + 4 x FXFQ80A
12 x FXSQ63A2VEB + 4 x FXSQ80A
12 x FXMQ63P7VEB + 4 x FXMQ80
118.0 (1)
62.4
131.5 (2)
6.65
5.19
4.2
4.3
4.2
6.6
6.6
6.5
261.2
259.3
255.4
165.5
167.3
164.4
2.3
118.0
4.4
86.9
8.2
55.9
15.4
24.8
2.3
118.0
4.4
86.9
8.2
55.9
15.3
24.8
2.3
118.0
4.3
87.0
8.0
55.9
15.2
24.8
2.4
62.4
-10
2.4
62.4
-10
2.7
55.2
3.7
33.6
6.3
21.6
8.6
9.9
2.7
55.2
3.7
33.6
6.4
21.6
8.7
10.0
2.4
62.4
-10
2.4
62.4
-10
2.7
55.2
3.7
33.6
6.3
21.6
8.6
9.9
2.4
62.4
-10
2.4
62.4
-10
42
Category II
64 (3)
525.0
1,365.0
Air
Air
41,700
41,700
89.1 (4)
72.4 (4)
66.5 (5)
R-410A
2,087.5
no
0.0
0.000
0.206
0.190
0.206
0.190
0.206
0.024
0.251
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
46.2 (7)
See note 8
No requirements
20,629 (9.000)
84.0 (10)
100 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ44U7Y1B
RXYQ12U
RXYQ16U
RXYQ16U
6 x FXFQ50AVEB + 8 x FXFQ63AVEB + 4 x
6 x FXSQ50A2VEB + 8 x FXSQ63A2VEB + 4 x
6 x FXMQ50P7VEB + 8 x FXMQ63P7VEB + 4 x
123.5 (1)
64.8
137.5 (2)
6.62
5.17
4.2
4.2
4.2
6.5
6.3
6.3
255.9
249.2
250.1
164.5
165.6
163.5
2.3
123.5
4.4
91.0
8.1
58.5
14.4
26.0
2.3
123.5
4.3
91.0
7.9
58.5
14.0
26.0
2.3
123.5
4.3
91.0
7.9
58.5
14.2
26.0
2.3
64.8
-10
2.3
64.8
-10
2.7
57.3
3.7
34.9
6.3
22.4
8.6
10.0
2.7
57.3
3.7
34.9
6.3
22.4
8.7
10.0
2.3
64.8
-10
2.3
64.8
-10
2.6
57.3
3.7
34.9
6.2
22.4
8.6
10.0
2.3
64.8
-10
2.3
64.8
-10
44
Category II
64 (3)
550.0
1,430.0
Air
Air
42,300
42,300
89.8 (4)
72.4 (4)
67.2 (5)
R-410A
2,087.5
no
0.0
0.000
0.206
0.190
0.206
0.190
0.206
0.024
0.251
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
48.7 (7)
See note 8
No requirements
21,132 (9.000)
86.0 (10)
100 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ46U7Y1B
RXYQ14U
RXYQ16U
RXYQ16U
1 x FXFQ50AVEB + 13 x FXFQ63AVEB + 4 x
1 x FXSQ50A2VEB + 13 x FXSQ63A2VEB + 4 x
1 x FXMQ50P7VEB + 13 x FXMQ63P7VEB + 4
130.0 (1)
67.0
145.0 (2)
6.60
5.13
4.1
4.2
4.1
6.4
6.4
6.3
254.9
252.2
248.3
162.0
163.5
161.3
2.4
130.0
4.4
95.8
8.1
61.6
14.3
27.4
2.3
130.0
4.3
95.8
8.1
61.6
14.0
27.4
2.3
130.0
4.2
95.8
7.9
61.6
13.9
27.4
2.4
67.0
-10
2.4
67.0
-10
2.7
59.3
3.6
36.1
6.2
23.2
8.7
10.3
2.7
59.3
3.6
36.1
6.3
22.8
8.8
10.3
2.4
67.0
-10
2.4
67.0
-10
2.7
59.3
3.6
36.1
6.2
23.2
8.7
10.3
2.4
67.0
-10
2.4
67.0
-10
46
Category II
64 (3)
575.0
1,495.0
Air
Air
44,580
44,580
89.3 (4)
73.3 (4)
67.0 (5)
R-410A
2,087.5
no
0.0
0.000
0.231
0.223
0.231
0.223
0.231
0.029
0.292
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
51.4 (7)
See note 8
No requirements
21,887 (9.000)
89.0 (10)
100 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ48U7Y1B
RXYQ16U
RXYQ16U
RXYQ16U
12 x FXFQ63AVEB + 6 x FXFQ80A
12 x FXSQ63A2VEB + 6 x FXSQ80A
12 x FXMQ63P7VEB + 6 x FXMQ80
135.0 (1)
69.6
150.0 (2)
6.50
5.05
4.1
4.2
4.1
6.4
6.3
6.2
251.7
248.3
244.2
162.8
164.3
161.7
2.3
135.0
4.3
99.5
8.1
64.0
14.3
28.4
2.2
135.0
4.2
99.5
8.0
63.9
14.0
28.4
2.2
135.0
4.1
99.5
7.8
63.9
13.8
28.4
2.4
69.6
-10
2.4
69.6
-10
2.7
61.6
3.6
37.5
6.3
24.1
8.8
10.7
2.7
61.6
3.6
37.5
6.3
24.1
8.9
10.7
2.4
69.6
-10
2.4
69.6
-10
2.7
61.6
3.6
37.5
6.3
24.1
8.8
10.7
2.4
69.6
-10
2.4
69.6
-10
48
Category II
64 (3)
600.0
1,560.0
Air
Air
46,800
46,800
90.4 (4)
73.4 (4)
67.8 (5)
R-410A
2,087.5
no
0.0
0.000
0.231
0.223
0.231
0.223
0.231
0.029
0.292
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
54.0 (7)
See note 8
No requirements
22,641 (9.000)
93.0 (10)
125 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ50U7Y1B
RXYQ16U
RXYQ16U
RXYQ18U
3 x FXFQ50AVEB + 13 x FXFQ63AVEB + 4 x
3 x FXSQ50A2VEB + 13 x FXSQ63A2VEB + 4 x
3 x FXMQ50P7VEB + 13 x FXMQ63P7VEB + 4
140.4 (1)
74.3
156.5 (2)
6.46
5.02
4.2
4.2
4.2
6.4
6.3
6.3
252.8
250.0
248.0
165.2
166.7
163.2
2.1
140.4
4.2
103.4
8.1
66.5
15.9
29.6
2.1
140.4
4.2
103.5
8.0
66.5
15.6
29.6
2.1
140.4
4.1
103.5
7.9
66.5
15.6
29.6
2.3
74.3
-10
2.3
74.3
-10
2.7
65.7
3.7
40.0
6.5
25.7
8.9
12.0
2.7
65.7
3.7
40.0
6.5
25.7
9.0
12.2
2.3
74.3
-10
2.3
74.3
-10
2.6
65.7
3.6
40.0
6.4
25.7
8.7
11.8
2.2
74.3
-10
2.2
74.3
-10
50
Category II
64 (3)
625.0
1,625.0
Air
Air
46,260
46,260
89.8 (4)
72.7 (4)
67.5 (5)
R-410A
2,087.5
no
0.0
0.000
0.243
0.224
0.243
0.224
0.243
0.029
0.293
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
56.8 (7)
See note 8
No requirements
23,899 (9.000)
97.0 (10)
125 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ52U7Y1B
RXYQ16U
RXYQ18U
RXYQ18U
6 x FXFQ50AVEB + 14 x FXFQ63AVEB + 2 x
6 x FXSQ50A2VEB + 14 x FXSQ63A2VEB + 2 x
6 x FXMQ50P7VEB + 14 x FXMQ63P7VEB + 2
145.8 (1)
79.0
163.0 (2)
6.42
4.99
4.3
4.3
4.2
6.4
6.4
6.4
253.7
251.6
251.5
167.2
168.7
164.4
2.0
145.8
4.2
107.4
8.1
69.1
17.6
30.7
2.0
145.8
4.1
107.4
8.1
69.0
17.4
30.7
2.0
145.8
4.1
107.4
8.0
69.1
17.5
30.7
2.2
79.0
-10
2.2
79.0
-10
2.6
69.9
3.8
42.5
6.6
27.4
9.0
14.2
2.6
69.9
3.8
42.6
6.7
27.4
9.1
14.4
2.2
79.0
-10
2.2
79.0
-10
2.6
69.9
3.7
42.5
6.4
27.3
8.7
13.7
2.2
79.0
-10
2.2
79.0
-10
52
Category II
64 (3)
650.0
1,690.0
Air
Air
45,720
45,720
89.3 (4)
72.0 (4)
67.1 (5)
R-410A
2,087.5
no
0.0
0.000
0.255
0.225
0.255
0.225
0.255
0.029
0.294
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
59.6 (7)
See note 8
No requirements
25,157 (9.000)
101.0 (10)
125 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit
RXYQ54U7Y1B
RXYQ18U
RXYQ18U
RXYQ18U
9 x FXFQ50AVEB + 15 x FXFQ63A
9 x FXSQ50A2VEB + 15 x FXSQ63A
9 x FXMQ50P7VEB + 15 x FXMQ63
151.2 (1)
83.7
169.5 (2)
6.38
4.97
4.3
4.3
4.2
6.4
6.4
6.4
254.1
252.5
253.9
169.4
170.8
166.0
1.9
151.2
4.1
111.4
8.1
71.6
19.1
34.4
1.9
151.2
4.1
111.4
8.1
71.6
18.9
34.1
1.9
151.2
4.1
111.4
8.2
71.6
19.1
34.7
2.1
83.7
-10
2.1
83.7
-10
2.6
74.0
3.9
45.1
6.8
29.0
9.0
14.2
2.6
74.0
3.9
45.1
6.8
29.0
9.1
14.4
2.1
83.7
-10
2.1
83.7
-10
2.5
74.0
3.8
45.1
6.5
29.0
8.7
13.7
2.1
83.7
-10
2.1
83.7
-10
54
Category II
64 (3)
675.0
1,755.0
Air
Air
45,180
45,180
88.6 (4)
71.1 (4)
66.8 (5)
R-410A
2,087.5
no
0.0
0.000
0.267
0.226
0.267
0.226
0.267
0.029
0.294
0.25
0.25
1
1
1
Y1
3N~
50
380-415
Both indoor and outdoor uni
-10
10
62.4 (7)
See note 8
No requirements
26,415 (9.000)
105.0 (10)
125 (11)
5G
2
F1,F2
(1) - Cooling: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; equiv
(2) - Heating: indoor temp. 20°CDB; outdoor temp. 7°CDB, 6°CWB; equivale
(3) - Actual number of connectable indoor units depends on the indoor unit type (VRV indoor, Hydrobox, RA in
(4) - Sound power level is an absolute value that a s
(5) - Sound pressure level is a relative value, depending on the distance and acoustic environ
(6) - Refer to refrigerant pipe selection or ins
(7) - RLA is based on following conditions: indoor temp. 27°CDB
(8) - MSC means the maximum current during start up of the compressor. VRV IV uses only inve
(9) - In accordance with EN/IEC 61000-3-12, it may be necessary to consult the distribution network operator to e
(10) - MCA must be used to select the correct field wiring size. The MCA can
(11) - MFA is used to select the circuit breaker and the ground fault circu
(12) - FLA means the nominal running curr
(13) - Maximum allowable voltage range variation
(14) - Voltage range: units are suitable for use on electrical systems where voltage suppli
(15) - The AUTOMATIC ESEER value corresponds with normal VRV4 Heat Pump operation, taking into account a
(16) - The STANDARD ESEER value corresponds with normal VRV4 Heat Pump operation, not ta
(17) - Sound values are measured in a semi-
(18) - Soundpressure system [dBA] = 10*log[10^(A/10)+10^(B/10)+10^(C/10)] ,
(19) - EN/IEC 61000-3-12: European/international technical standard setting the limits for harmonic currents produced by eq
(20) - Ssc: Short-circuit powe
(21) - For detailed contents of standard accessories, see in
(22) - Multi combination (22~54HP) data is corresponding wit