Sie sind auf Seite 1von 4

ATEX Float Valve (AXFV)

Technical Data Flower Velocity Limit

Working Principle • Freely adjustable up to 30m/s


• Easy on-site conversion can be
Under normal operating conditions, the performed by the plant operator
medium flows through the ATEX Float
valve with low turbulence, saving Installation, position and explosion
energy. The adjusted internal closure direction
element is held in central position by a
unique patented ball and spring • Easy on-site conversion, can be
system. This ensures the safe operation performed by the plant operator
even at higher flow velocities, and if
installed before or after pipe bends. Product temperature

In the event of an explosion, the valve Independent of product temperature


closes automatically with the kinetic by guaranteed flame arresting without
energy of the pressure wave preceding internal seals
the flame front. The closing element is
pressed axially against the pipe body of Options
the valve and flame propagation proof
arrested by a locking device. Signal • Electrical switch contacts for
generators can indicate the closed signalling of "closed" position,
position of the valve. also suitable for use in explosive
areas
Materials • Additional stainless steel
versions
• Aluminium housing • Customised surface finishing
• Mile steel ST 37, painted red • Increased product temperature
• Stainless steel W 1.4301 or w • Gas proof version up to max.
1.4571 operating pressure
• Internal parts stainless steel W
1.4301 or W 1.4571 Technical charges reserved, E&OE

Features Project Planning Information

• Dust loads permissible • Housing materials: Painted steel,


• High temperature resistance stainless steel DN100 & DN150
• No wearing parts additionally aluminium
• Directly acting • Valve prepared for assembly of
• Product deposits permissible an initiator M12X1 for signalling
• No closure by volume flow CLOSED valve position
• Triggering pressure adjustable • Available with flanges acc. to
• Short installation length DIN or ANSI
• Maximum flow velocity infinitely
adjustable depending on process
and protection concept

ATEX Passive Explosion


Isolation Valve

Features:

• No dust loading limits


• No gasket temperature limits
• No wear and tear issues
• No active detection required
• No active powder monitoring
required
• No valve closure from normal
air flows
• Field adjustable pressure
release
• Full 14 bar (200+ psi) strength
• For ST1 and ST2 dusts

Technical Data: ATEX- Float


Valve
Dimensions/Weights: ATEX- Float Valve

Euratex Limited
22 Prospect Place
Hipley Street
GU229LP

Tel: +44 (0) 1483 901 311


Fax: +44 (0) 1483 433 313

www.euratex.co.uk

Das könnte Ihnen auch gefallen