Sie sind auf Seite 1von 1

Section C - Electrics

Basic System Operation


EMS Set + Mode Menu

EMS Set + Mode Menu

When the SET and MODE buttons on the EMS are to set option configurations. The following functions are
pressed together a sub menu appears, enabling the available:
technician to view more detailed data on the machine and

MODEL NAME Displays the model type.


HRDWARE VER Displays the hardware version
SFTWARE VER Displays the software version.
SCRAP MAG The current status of the scrap magnet function is displayed. The up arrows changes the status
to "ON" and the down arrows change it to "OFF". If the "ACK" is pressed the display shows the
scrap magnet rev/min.
SENSOR VOLT Displays the sensor circuit voltage in volts.
BATT VOLTS Displays the battery voltage in volts.
ALT VOLTS Displays the alternator output voltage in volts.
THRTTLE POT Displays the throttle volume dial value in Ohms
FUEL LEVEL Displays the fuel level sensor value in%
FAN DUTY Displays the current duty cycle of the fan control solenoid in %." On machines with a Viscous
Clutch Fan, this menu item shows the duty cycle (in %) of the PWM output from the ECU1 to the
fan, 100% = idling and 0% = fully on.
BAROMETER Displays the current barometric pressure in kPa
WATER TEMP Displays the current engine coolant temperature in °C
HYD TEMP Displays the current hydraulic oil temperature in °C
PILOT SWTCH Displays the status of the pressure switches. Use the scroll keys to go through the following
switches, the current status will be displayed:
TRAVEL Travel Pressure switch status
AUTO Auto mode Pressure switch status
BOOST Boost Pressure switch status
BOOM Boom Pressure switch status
UPPER Upper Pressure switch status
SLEW Slew Pressure switch status
HAMMER (1) Hammer Pressure switch status
PUMP AMPS Displays the current duty cycle of the pump control solenoid in mA
RPM VALUE Displays the current value of the engine speed in RPM.
SERIAL NO Displays the serial number.

(1) If enabled

C-115 9803/9800-3 C-115

Das könnte Ihnen auch gefallen