Beruflich Dokumente
Kultur Dokumente
Task No 1
Tool used: Proteus 8.0
Components
Breadboard
Three resistances of 330 ohm
Led yellow
Two NPN transistors
Five jumpers
Two push buttons
9 v battery
Combination (1,0)
Combination (1,1)
BREADBOARD DIAGRAM
Combination (0,0)
Combination (0,1)
Combination (1,0)
Combination (1,1)
Explanation
I took a breadboard. Then I put 9v battery’s red wire on positive row and black wire on
negative row. Then I took yellow led and put positive jumper’s input on positive Colum of
led and took 330 ohm resister and put its one leg on the negative Colum of the led. Then I
took NPN transistor and put resister’s second leg on collector Colum and took another
transistor and joined emitter of transistor with the emitter of second transistor with the help of
jumper. Then I took another resister of 330 ohm and put its first leg on first emitter’s base
Colum and ground the second transistor’s collector with joining it with negative side of the
battery with the help of jumper. Then I took two push buttons and put push button’s left leg
on the Colum where the resistance’s second leg is connected whose first leg is connected
with the collector of first transistor. Then put positive side of the battery on push button’s
right leg. Then I took other push button and connect its left leg on the Colum where the
residence’s second leg is connect whose first leg is connected with collector f the second
transistor. Then I joined batteries positive terminal with the help of jumper.
Lab # 7
Task No 2
Tool used: Proteus 8.0
Components
Breadboard
Three resistances of 330 ohm
Led yellow
Two NPN transistors
Six jumpers
Two push buttons
9 v battery
Combination (0,0)
Combination (0,1)
Combination (1,0)
Combination (1,1)
BREADBOARD DIAGRAM COMBINATION (0,0)
Combination (0,1)
Combination (1,0)
Combination (1,1)
Explanation
I took a breadboard. Then I put 9v battery’s red wire on positive row and black wire on
negative row. Then I took yellow led and put positive jumper’s input on positive Colum of
led and took 330 ohm resister and put its one leg on the negative Colum of the led. Then I
took NPN transistor and put resister’s second leg on collector Colum and took another
transistor and joined emitter of transistor with the collector of second transistor with the help
of jumper. Then I took another resister of 330 ohm and put its first leg on first emitter’s base
Colum and ground the second transistor’s collector with joining it with negative side of the
battery with the help of jumper. Then I took two push buttons and put push button’s left leg
on the Colum where the resistance’s second leg is connected whose first leg is connected
with the collector of first transistor. Then put positive side of the battery on push button’s
right leg. Then I took other push button and connect its left leg on the Colum where the
residence’s second leg is connect whose first leg is connected with collector f the second
transistor. Then I joined batteries positive terminal with the help of jumper.