Beruflich Dokumente
Kultur Dokumente
ASSIGNMENT QUESTIONS
Figure 3
Figure 1 4. A curved link of the mechanism made from
2. A crane hook is shown in figure. Plot the a round steel bar is shown in Fig. The
distribution of stress across section A-A of material of the link is plain carbon steel
the crane hook, consider the cross section as 30C8 (Syt = 400 N/mm2) and the factor of
rectangular with thickness as 20 mm and safety is 3.5. Determine the dimensions of
take load P of 20 kN. the link.
Figure 4
Figure 2
7. An open S link is made from a φ30 mm rod
as shown in figure to carry a load of 500 N.
5. A utility hook was formed from a round rod Find the maximum tensile and shear
of diameter d = 20 mm into the geometry stresses.
shown in the figure. What are the stresses at
the inner and outer surfaces at section A–A if
F = 4 kN, L = 250 mm, and Di = 75 mm?
Figure 7
Figure 5
8. An offset bar is loaded as shown in figure.
The weight of the bar can be neglected.
6. The steel eyebolt shown in the figure is
loaded with a force F = 300 N. The bolt is What is the maximum offset (dimension X),
formed from wire of diameter d= 6 mm to a if the allowable stress in tension is limited to
radius Ri= 10 mm in the eye end at the 55 MPa?
shank. Estimate the stresses at the inner and
outer surfaces at section A–A.
Figure 8
Figure 6