Beruflich Dokumente
Kultur Dokumente
Overview
Use this assessment to test what you learned in this module. The correct answers are found in
the Module Assessment Answer Key.
Objectives
This activity tests your knowledge on how to meet these objectives:
Identify and describe the elements of an MPLS implementation
Describe how packets traverse an MPLS network
Identify the commands that are necessary to configure MPLS in a framemode network
Identify the components that are necessary to implement VPNs
Identify the commands that are necessary to implement a simple MPLS VPN
implementation
Instructions
Complete these steps:
Step 1 Answer all questions in this quiz by selecting the best answer(s) to each question.
Step 2 Verify your results against the answer key at the end of this quiz.
Step 3 Review the related lesson for each question that you answered incorrectly.
Quiz
Answer these questions:
Q1) Which of the following best describes the term “a simple labelbased forwarding
engine?”
A) control plane
B) ground plane
C) data plane
D) routing plane
Q2) What does the term “pop” mean when you are describing penultimate hop popping?
A) swap the top label with a new label, which is contained in the LIB
B) swap the top label with a new label, which is contained in the LFIB
C) remove the top label instead of swapping it with the nexthop label
D) remove the bottom label instead of swapping it with the nexthop label
Q3) The MPLS MTU is increased to _____________ to support 1500byte IP packets and
MPLS stacks up to three levels deep.
Q4) Why do MPLS VPNs implement route targets?
A) to identify different customer VPNs
B) to allow a site to participate in more than one VPN
C) to convert a customer address to an MPBGP address
D) to convert a nonunique IP address into a unique VPNv4 address
1-80 Implementing Cisco MPLS Traffic Engineering and Other Features (MPLST) v2.0 Copyright © 2004, Cisco Systems, Inc.
Q5) What happens to the interface of an existing IP address when you associate the
interface with a VRF table?
A) It remains unchanged.
B) It is removed from the interface.
C) It is changed to the loopback 0 address.
D) It is moved to under the VRF table configuration.
Scoring
You have successfully completed the quiz for this lesson when you earn a score of 80 percent
or better.
Q2) C
Relates to: Label Distribution in Frame-Mode MPLS
Q3) 1512
Relates to: Configuring MPLS
Q4) B
Relates to: MPLS VPN Routing Model and Packet Forwarding
Q5) B
Relates to: Configuring Simple MPLS VPNs
1-82 Implementing Cisco MPLS Traffic Engineering and Other Features (MPLST) v2.0 Copyright © 2004, Cisco Systems, Inc.