Beruflich Dokumente
Kultur Dokumente
WA200-5
WA
WA
250
200
WHEEL LOADER
WA200-5 W HEEL L OADER WHEEL LOADER
WA200-5
OPERATING WEIGHT
9425 – 9555 kg
20,779 – 21,065 lb
Swing-out hydraulic
radiator fan
Komatsu-integrated
design offers the best Side-by-side type coolers
for easy access and cleaning
value, reliability, and versatility.
Hydraulics, powertrain, frame, Overrun protection system
and all other major components
are engineered by Komatsu. Ground level servicing
You get a machine whose and fluid checks
2 3
WA200-5 W HEEL L OADER WHEEL LOADER
WA200-5
● When high drive torque is needed for digging, climbing For v-cycles, the operator can set the speed control switch to switch in the “ON” position limits the maximum amount of
Powerful Engine
or initiating movement, the pump feeds both motors. This 1 or 2, which will tractive effort.
A powerful SAA6D102E-2 turbocharged air-to-air after-
combination makes the loader very aggressive and give him aggres- Traction control will
cooled diesel engine provides an output (net) of 92 kW
quick. sive digging, quick be an advantage in
123 HP for the WA200-5.
● Under deceleration, the HST system acts as a dynamic response and fast certain appplica-
Low Fuel Consumption brake on the mechanical drive system. The dynamic hydraulics. For tions such as trans-
The fuel consumption is reduced up to 15%* due to the high- brake can hold the loader in position on most workable load and carry, he fer stations where
torque engine and Hydrostatic Transmission (HST) with maxi- slopes. This can be an advantage in stockpiling and can select 3 or 4 the loader may be
mum efficiency in the low-speed range. ramp loading. which will still give working on slippery
*V-shape loading (25 sec. cycle time) ● As the machine moves and gains ground speed, the aggressive digging concrete.
Electronically-Controlled HST Using a 1-Pump, torque demand decreases and the low speed motor is but with much
2-Motor System effectively removed from the drive system by a clutch. At faster travel
this point, the flow is going to the high-speed motor and speed.
● The 1-pump, 2-motor system allows for high-efficiency
the low-speed motor is not causing a drag on the sys-
and high tractive effort. Engine power is transmitted The variable shift
tem.
hydraulically to a transfer case, then manually out to the switch allows the
differentials and out to the four driving wheels. ● An inching pedal gives the operator excellent simultane-
ous control of his travel and equipment hydraulic speeds. operator to adjust his machine speed in confined v-loading
● HST provides quick travel response and aggressive drive applications. When in 1, the operator can adjust his travel
By depressing the inching pedal, drive pump flow to the
into the pile. The variable displacement system automati- speed using the variable shift switch to match his machine
motors will decrease, reducing ground speed and allow-
cally adjusts to the tractive effort demand to provide
ing the operator to use his accelerator to increase flow to speed and hydraulics to the distance he must travel.
maximum power and efficiency.
his equipment hydraulics. Depressing the inching pedal
● Full auto-shifting eliminates any gear shifting and kick- further will activate the service brakes.
down operation to allow the operator to concentrate on
digging and loading. Variable Shift Control Traction Control
Reduced
Tractive effort
Tractive effort
Transfer case
Variable range
Low speed of travel speed
piston
motor
4 5
WA200-5 W HEEL L OADER WHEEL LOADER
WA200-5
INCREASED RELIABILITY AND SERVICEABILITY Fully Hydraulic Wet Multi-disc Service Brakes
The dual wet disc brakes at each wheel are fully sealed and
Flat Face-to-Face O-Ring Seals
Sealed DT Connectors
Extended Service Interval Main harnesses and controller connectors are equipped with
sealed DT connectors providing high reliability and dust and
Swing-Out Radiator
Extended engine oil change interval: corrosion resistance.
The new Komatsu 250 H 500 H
Komatsu Components
cooling system is Extended drive shaft greasing interval:
isolated from the Komatsu manufactures
1,000 H 4,000 H Komatsu Components
engine to provide the engine, transfer Engine
6 7
WA200-5 W HEEL L OADER WHEEL LOADER
WA200-5
Low-noise Design
8 9
WA200-5 W HEEL L OADER WHEEL LOADER
WA200-5
SPECIFICATIONS DIMENSIONS
m3 yd3
17.5-25-12PR (L3) 105 kg 231 lb 80 kg 176 lb 70 kg 154 lb 2375 mm 7'10" 425 mm 1'5" 0 mm 0" 0 mm 0"
Bucket capacity: m3 yd3
STEERING SYSTEM
Light Material Bucket 20.5-25-12PR (L2) 450 kg 992 lb 240 kg 529 lb 220 kg 485 lb 2470 mm 8'1" 495 mm 1'8" 70 mm 2.8" –75 mm –3.0"
2.4 3.1 (Scooping and loading of light material)
Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Full-hydraulic power 20.5-25-12PR (L3) 665 kg 1,466 lb 355 kg 783 lb 320 kg 705 lb 2470 mm 8'1" 495 mm 1'8" 70 mm 2.8" –75 mm –3.0"
Stockpile Bucket
steering independent of engine rpm (Loading and excavating of soil, sand and a Install ROPS canopy (instead of cab) –250 kg –551 lb –250 kg –551 lb –220 kg –485 lb
2.0 2.6
Steering angle . . . . . . . . . . . . . . . . . . . . . . . . . . . 40° each direction variety of other commonly handled material)
Additional counterweight 300 kg 661 lb 590 kg 1,301 lb 510 kg 1,124 lb
Minimum turning radius at the Excavating Bucket
1.7 2.2 (Loading and excavating of crushed or blasted rock) Air conditioner 70 kg 154 lb 60 kg 132 lb 50 kg 110 lb
center of outside tire . . . . . . . . . . . . . . . . . . . . . . . 4880 mm 16'0"
1000 1200 1400 1600 1800 2000 2200
1686 2023 2360 2698 3035 3372 3709
Material density: kg/m3 lb/yd3
10 11
STANDARD EQUIPMENT
● Alternator, 35A, 24 volt —Lights (Axle oil temperature, battery ● Mono-lever loader control
● Axles, semi floating charge, brake oil pressure, central warn- ● Parking brake, wet disc
● Back-up alarm ing, directional indicator, engine oil pres- ● Radiator mask, hinged
● Back-up light, rear sure, engine pre-heater, HST oil filter ● Seat belt, 3" wide
● Batteries, 110 Ah/2 x 12 V, clogging, high beam, maintenance, park- ● Seat, rigid type, reclining
● Bucket positioner, automatic ing brake reminder, parking brake warn- with a document holder
● Cab (ROPS/FOPS) with cigarette ing, steering oil pressure, transmission ● Service brakes, hydraulic, wet multi-disc,
lighter/ash tray, dome light, floor mat, speed range, turn signals) inboard
front (intermittent) and rear wiper/washer, ● Engine, Komatsu SAA6D102E-2 ● Speedometer (km/h)
rear view mirrors (2 outside, 1 inside), ● Engine shut-off system, electric ● Starting aid, intake manifold preheater
right hand and left hand door access with ● Engine water separator ● Starting motor, 4.5 kW/24 V
steps, sun visor ● Fan, hydraulic driven, swing out ● Steering wheel, tiltable
● Counterweight ● Fenders, rear ● Tires 17.5-25-12PR (L2), tubeless and
● Differentials, torque proportioning ● Hard water area arrangement rims
● EMMS (Equipment Management (corrosion resister) ● Transmission (Hydrostatic with speed
Monitoring System) ● Horn, electric range select), automatic
—Gauges (Speedometer, engine water ● Lift cylinders and bucket cylinder ● Transmission control, electric,
temperature, fuel level, HST oil tempera- ● Lifting eyes steering column
ture) ● Lights ● 2-spool valve for boom and bucket
—LCD displays (filter/oil replacement —Stop and tail controls with PPC
time, HST selection, odometer, service —Turn signal (2 front, 2 rear)
meter, trouble shooting) —Working (2 front, 2 rear, 2 outside cab)
● Loader linkage with standard lift boom
OPTIONAL EQUIPMENT
● Air conditioner with heater/defroster/ ● Fenders, front ● Seat, vinyl, suspension, reclining with
pressurizer ● Fenders, rear full armrests, headrest, and a document
● Alternator, 60A, 24V ● Heater and defroster holder
● Auxiliary steering ● Hydraulic adapter kit (3rd spool), includes ● Seat belt, retractable, 3" wide
● Boom kick-out valve, lever, and piping ● Spare parts
● Bucket, excavating, 1.7 m3 2.2 yd3 ● Limited-slip differential, front and rear ● 3-spool valve, lever, piping
● Bucket, stockpile, 2.0 m3 2.6 yd3 ● Radio, AM/FM ● Tires (bias ply)
● Bucket, light material, 2.4 m3 3.1 yd3 ● Radio, AM/FM stereo with cassette —17.5-25-12PR (L3)
● Bucket teeth, bolt-on ● Rims only, less tires —20.5-25-12PR (L2)
● Cold area arrangement —Fits 17.5-25 and 20.5-25 tire —20.5-25-12PR (L3)
● Counterweight, additional ● ROPS canopy ● Tool kit
● Cutting edge, bolt-on, reversible ● Seat, cloth, suspension, reclining with ● Vandalism protection kit
● ECSS (Electronically Controlled armrests, headrest, and a document
Suspension System) holder