Beruflich Dokumente
Kultur Dokumente
b. begin carving the distal bucco-cervical, then the distal linguo-cervical, and finally the
mesial linguo-cervical and mesial bucco-cervical areas.
c. begin carving the mesio linguo-cervical and mesial bucco-cervical areas, then the
distal bucco-cervical, and finally the distal linguo-cervical.
1. All of the following are true for Class II Amalgam preparations EXCEPT:
a. Proximal retention locks if placed, should be entirely in dentin, and are deeper
gingivally than occlusally
e. The buccal and lingual walls should converge to provide mechanical retention to
the restorative material
2. Which of the following statements are true about a Class II Amalgam restoration:
a. The procedure for the removal of the carious lesion is the same as that of a class I
b. A Class II carious lesion develops apical to the contact area on the proximal
surfaces of posterior teeth
c. Any remaining carious lesion is removed only after establishment of the ideal
internal and external outline forms.
e. Reverse curve
a. Occlusal plane
b. Marginal Ridge
c. Proximals
b. mark the centric stops using articulating paper and tap the teeth together into
centric occlusion
c. extending the external walls to sound tooth structure and by thinning the defective
marginal ridge as much as possible.
6. What is the proper depth of the dentin in an ideal Class II amalgam preparation?
a. 0.5mm
b. 2 mm
c. 1.5 mm
a. Bur should change to satisfy the direction for the different occlusal walls of the
cavity
b. The bur should be rotating when it is applied and it should not stop rotating until
it is removed from the tooth.
c. The marginal ridge is thinned out as much as possible. This thinned out shell of
enamel provides protection for the adjacent tooth
8. In checking the occlusal segment of the Class II amalgam cavity preparation, which
of the following are seen?
a. the bucco-proximal wall on the manidibular molar makes a less acute angle with
the gingival floor and the linguo-proximal wall makes an acute angle
b. The initial step in preparing the proximal segment is to place the cutting end of
the bur on the DEJ
c. Pressure is directed gingivally and lightly toward the enamel shell to keep the bur
against the proximal enamel.
10. Which of the following statements are true in checking an ideal Class II Amalgam
cavity preparation?
b. All walls were connected with a smooth curve and there are no catches in the
groove area.
c. The axial wall was rounded to follow the external outline of the tooth structure
and is 0.5-0.8 mm into the dentin.
d. The gingival cavosurface margin was planed and unsupported enamel removed.