Beruflich Dokumente
Kultur Dokumente
Picture 11-3-3-1
2)Click the “user manager”, press “add” button to enter “user manager” setting
page, see picture 11-3-3-2。
Picture 11-3-3-2
Picture 11-3-4-1
3、 When it is SETTING page, Press Page down key to go to SYSTEM IP SETTING page,
to set IP address the same network with the PC, others are the same with PC.
The “actual address”can be set according to the actual address, or no need
to set, see picture 11-3-4-2。
Picture 11-3-4-2
4、PC Setting:
1)Click the computer "My Network Places", right-click the "local connection"
attribute appears internet protocol is shown see Picture 11-3-4-3。
Picture 11-3-4-3
2)The IP address of CNC can’t be same with the IP address of PC, Subnet mask and default
gateway should be same.
interface, then press soft key,to enter network transfer page, there
are USER NAME, PASSWORD, LOG IN, move the cursor left or right to enter user
name, password, then press “ENTER” to log in. if want to log out please press
“ENTER” again. See picture 11-3-4-4)
Picture 11-3-4-4
NOTE: The files on the left is belong to CNC, the files on the right below to the PC.
6、Then press the【Network transfer】soft key,to download, upload files and proceed DNC
machining.
Picture 11-3-4-5
Picture 11-3-4-6
from the PC end window;press key ,system will show “do delete
key to quit.