Beruflich Dokumente
Kultur Dokumente
The BA15218, BA15218F, and BA15218N are monolithic ICs with two built-in low-noise, low-distortion operational
amplifiers featuring internal phase compensation.
Either a dual or single power supply can be driven, and these products can be driven by a digital system 5V single
power supply.
The following packages are available: 8-pin DIP (BA15218), 8-pin SOP (BA15218F), and 8-pin SIP (BA15218N).
•1)Features
Low-voltage operation and single power supply drive 4) Low offset voltage. (VIO = 0.5mV typ.)
enabled. 5) High gain and low distortion. (GVO = 110dB, THD =
(Single power supply: 4 to 32V, dual power supply: 0.0015%)
±3 to ±16V) 6) Pin connections are the same as with standard dual
2) Low noise level. (Vn = 1.0µVrms typ. : RIAA) operational amplifiers, and outstanding characteris-
3) High slew rate. (SR = 3V / µs, GBW = 10MHz typ.) tics make these products compatible with the 4558
and 4560 models.
•Block diagram
BA15218 / BA15218F BA15218N
OUT1 1 8 VCC
+ +
– IN1 2 7 OUT2 1ch 2ch
1ch – –
– +
2ch
+ IN1 3 + – 6 – IN2
1
VEE 4 5 + IN2
OUT1
– IN1
+ IN1
VEE
+ IN2
– IN2
OUT2
VCC
1
Standaed ICs BA15218 / BA15218F / BA15218N
Q5 Q8
Q13 Q18 Q19
Q11
– IN Q9
Q1 Q2 R6
Q10
+ IN C2 R5 OTHER
R7 CH
Q16 Q17
D1 R8
Q6 Q12
Q15
Q3 Q4 Q7 Q14
R9
C1
R2 R3 R4
VEE
OUT
2
Standaed ICs BA15218 / BA15218F / BA15218N
120
POWER DISSIPATION: Pd (mW)
1000
BA15218N
6
100
800
BA15218 80
600 4
60
400 BA15218F
40
2
200
20
0 0 0
0 25 50 75 85 100 125 150 0 ± 10 ± 20 1 10 100 1k 10k 100k 1M 10M
±
AMBIENT TEMPERATURE: Ta (°C) POWER SUPPLY VOLTAGE: V (V) FREQUENCY: f (Hz)
Fig.1 Power dissipation vs. ambient Fig.2 Quiescent current vs. power Fig.3 Open loop voltage gain vs.
temperature supply voltage frequency
3
Standaed ICs BA15218 / BA15218F / BA15218N
32 80 100
MAXIMUM OUTPUT VOLTAGE: VOM (V)
28
16 50
12
40
8 25
0 20
100 1k 10k 100k 1M – 20 0 20 40 60 80 0 10 20 30 40
Fig.4 Maximum output voltage vs. Fig.5 Input bias current vs. Fig.6 Input bias current vs.
frequency ambient temperature power supply voltage
30
OUTPUT VOLTAGE
5 RL = 2kΩ
VOUT (V)
20
0
–5
10
INPUT VOLTAGE
5 0
VIN (V)
0
– 10
–5
0 10 20 30 40 – 20
0 ± 10 ± 20
TIME (µs)
POWER SUPPLY VOLTAGE: V± (V)
•(1)Operation notes
Unused circuit connections
VCC
VEE
4
Standaed ICs BA15218 / BA15218F / BA15218N
6.5 ± 0.3
8 5
6.2 ± 0.3
4.4 ± 0.2
1 4
0.15 ± 0.1
7.62
0.51Min.
1 4
3.2 ± 0.2 3.4 ± 0.3
1.5 ± 0.1
0.3 ± 0.1
0.11
1.27 0.4 ± 0.1 0.3Min.
2.54 0.5 ± 0.1 0°~15°
0.15
DIP8 SOP8
BA15218N
1.2
1 8
3.5 ± 0.5
1.3
SIP8
5
Appendix
Notes
No technical content pages of this document may be reproduced in any form or transmitted by any
means without prior permission of ROHM CO.,LTD.
The contents described herein are subject to change without notice. The specifications for the
product described in this document are for reference only. Upon actual use, therefore, please request
that specifications to be separately delivered.
Application circuit diagrams and circuit constants contained herein are shown as examples of standard
use and operation. Please pay careful attention to the peripheral conditions when designing circuits
and deciding upon circuit constants in the set.
Any data, including, but not limited to application circuit diagrams information, described herein
are intended only as illustrations of such devices and not as the specifications for such devices. ROHM
CO.,LTD. disclaims any warranty that any use of such devices shall be free from infringement of any
third party's intellectual property rights or other proprietary rights, and further, assumes no liability of
whatsoever nature in the event of any such infringement, or arising from or connected with or related
to the use of such devices.
Upon the sale of any such devices, other than for buyer's right to use such devices itself, resell or
otherwise dispose of the same, no express or implied right or license to practice or commercially
exploit any intellectual property rights or other proprietary rights owned or controlled by
ROHM CO., LTD. is granted to any such buyer.
Products listed in this document use silicon as a basic material.
Products listed in this document are no antiradiation design.
The products listed in this document are designed to be used with ordinary electronic equipment or devices
(such as audio visual equipment, office-automation equipment, communications devices, electrical
appliances and electronic toys).
Should you intend to use these products with equipment or devices which require an extremely high level of
reliability and the malfunction of with would directly endanger human life (such as medical instruments,
transportation equipment, aerospace machinery, nuclear-reactor controllers, fuel controllers and other
safety devices), please be sure to consult with our sales representative in advance.
Appendix1-Rev1.0