Beruflich Dokumente
Kultur Dokumente
Release Notes
Introduction
In these release notes, you will find information to help you install and use the
FIP-400B Fiber Inspection Probe and ConnectorMax2 on your computer.
IMPORTANT
The installation of ConnectorMax2 takes several minutes.
For more information about the FIP-400B Fiber Inspection Probe and
ConnectorMax2, refer to the online help.
System Requirements
To be able to install and run ConnectorMax2 on your computer, you must meet the
minimum requirements below:
Installing ConnectorMax2
ConnectorMax2 is the application that is used to view and analyze the fibers you
want to inspect. For more information about the application, refer to the
corresponding documentation.
To install ConnectorMax2 on a computer:
1. Insert the installation DVD into the DVD-ROM drive of your computer.
2. Install ConnectorMax2 as follows:
2a. On the taskbar, click Start, and then select My Computer.
2b. Select your DVD-ROM drive.
2c. Locate the EXFO ConnectorMax 3.0.msi file on the DVD and click Open.
3. Click OK to start the installation.
4. From the welcome dialog box, click Next.
5. Read and accept the licence term agreement, then click Next to proceed to the
next step.
IMPORTANT
You have to disconnect the probe before removing the software.
Otherwise, you will not be able to reinstall the software.
Release History
This release of ConnectorMax2 includes the latest upgrades for your product.
All changes are identified below.