Beruflich Dokumente
Kultur Dokumente
Assessment System
Take Assessment - EWAN Final Exam - CCNA Exploration: Accessing the WAN (Version
4.0)
00:52:35
Time Remaining:
1 Which encapsulation protocol when deployed on a Cisco router over a serial interface is only compatible with another Cisco
router?
PPP
SLIP
HDLC
Frame Relay
3 An administrator is configuring a dual stack router with IPv6 and IPv4 using RIPng. The administrator receives an error
message when trying to enter the IPv4 routes into RIPng. What is the cause of the problem?
When IPv4 and IPv6 are configured on the same interface, all IPv4 addresses are over-written in favor of the newer technolog
5 Which characteristic of VPN technology prevents the contents of data communications from being read by unauthorized
parties?
QoS
latency
reliability
confidentiality
Refer to the exhibit. A network administrator is configuring Frame Relay on router HQ. It is desired that each Frame Relay
between the routers be in a separate subnet. Which two commands on HQ will accomplish this task for the connection to
(Choose two.)
HQ(config)# interface S0/0/0
7
Refer to the exhibit. Router1 and Router2 are directly connected over a point-to-point serial link. Router1 initiates a PPP
session with Router2. Which statement is true based on the configuration?
The password is sent in clear text.
8A technician has been asked to run Cisco SDM one-step lockdown on the router of a customer. What will be the result of t
process?
Traffic is only forwarded from SDM-trusted Cisco routers.
Security testing is performed and the results are saved as a text file stored in NVRAM.
The router is tested for potential security problems and any necessary changes are made.
All traffic entering the router is quarantined and checked for viruses before being forwarded.
9 Which two statements are true about creating and applying access lists? (Choose two.)
There is an implicit deny at the end of all access lists.
.
One access list per port, per protocol, per direction is permitted.
Access list entries should filter in the order from general to specific.
The term "inbound" refers to traffic that enters the network from the router interface where the ACL is applied.
Standard ACLs should be applied closest to the source while extended ACLs should be applied closest to the destination.
10
Refer to the exhibit. Company ABC expanded its business and recently opened a new branch office in another country. IP
addresses have been used for the company network. The data servers Server1 and Server2 run applications which requi
end-to-end functionality, with unmodified packets that are forwarded from the source to the destination. The edge routers
and R2 support dual stack configuration. What solution should be deployed at the edge of the company network in order
successfully interconnect both offices?
a new WAN service supporting only IPv6
Close Window
Assessment System
1. Assessment 2. Assessment
Selection Settings
Take Assessment - EWAN Final Exam - CCNA Exploration: Accessing the WAN (Version 4.0)
11 A company uses a PVC with a committed information rate (CIR) of 128 kb/s and a committed burst information rate (CB
64 kb/s. The link is used to periodically send updates at a rate of 144 kb/s. What will happen to the update traffic?
The traffic will be sent, but the company will be charged a penalty.
The traffic will be sent using the additional CBIR and will be guaranteed delivery.
The traffic will be dropped at the CO for exceeding the committed information rate.
The traffic will be sent, but the burst traffic will be marked for discard if congestion is encountered.
12
Refer to the exhibit. All devices are configured as shown in the exhibit. PC1 is unable to ping the default gateway. Wha
cause of the problem?
The default gateway is in the wrong subnet.
13 A system administrator must provide Internet connectivity for ten hosts in a small remote office. The ISP has assigned
public IP addresses to this remote office. How can the system administrator configure the router to provide Internet ac
to all ten users at the same time?
Configure DHCP and static NAT.
14
Refer to the exhibit. From the output of the show interfaces and ping commands, at which layer of the OSI model is a fa
indicated?
application
transport
network
data link
physical
15
Refer to the exhibit. Results of the show vlan and show vtp status commands for switches S1 and S2 are displayed in t
exhibit. VLAN 11 was created on S1. Why is VLAN 11 missing from S2?
There is a Layer 2 loop.
16
Refer to the exhibit. What is the effect of the extended ACL when applied inbound on the S0/0/0 interface on R2?
All IP traffic will be permitted during the specified days and time range.
Both IP and Telnet traffic will be permitted during the specified days and time range.
Only Telnet traffic destined for 172.16.10.0/24 will be permitted during the specified days and time range.
Telnet traffic will be permitted only during the specified days and time range. All other network traffic will be permitted any t
17 Which three guidelines would help contribute to creating a strong password policy? (Choose three.)
Once a good password is created, do not change it.
Write passwords in locations that can be easily retrieved to avoid being locked out.
Use long words found in the dictionary to make passwords that are easy to remember.
18
Refer to the exhibit. How is the TCP/IP configuration information specified by the default-router and dns-server comma
made available?
The TCP/IP information is forwarded to a 10.0.1.3 to be supplied to DHCP clients.
The TCP/IP information is used by DNS clients to forward all data to the default gateway on R1 of 10.0.1.3.
The TCP/IP information is supplied to any DHCP client on the network connected to the FastEthernet 0/0 interface of R1.
The TCP/IP information is applied to each packet that enters R1 through the FastEthernet 0/0 interface that are hosts on th
10.0.1.0 /24 network except packets from addresses 10.0.1.2, 10.0.1.16, and 10.0.1.254.
source IP address
destination IP address
20When configuring a Frame Relay connection, what is the purpose of Inverse ARP?
to assign a DLCI to a remote peer
to negotiate LMI encapsulations between local and remote Frame Relay peers
Showing 2 of 6 <Prev 2
Page:
Close Window
Assessment System
1. Assessment 2. Assessment
Selection Settings
Take Assessment - EWAN Final Exam - CCNA Exploration: Accessing the WAN (Version 4.0)
21 An issue of response time has recently arisen on an application server. The new release of a software package has als
installed on the server. The configuration of the network has changed recently. To identify the problem, individuals fro
teams responsible for the recent changes begin to investigate the source of the problem. Which statement applies to t
situation?
Scheduling will be easy if the network and software teams work independently.
It will be difficult to isolate the problem if two teams are implementing changes independently.
Results from changes will be easier to reconcile and document if each team works in isolation.
Only results from the software package should be tested as the network is designed to accommodate the proposed softwa
platform.
22What is the result when the command permit tcp 10.25.132.0 0.0.0.255 any eq smtp is added to a named access control
and applied on the inbound interface of a router?
TCP traffic with a destination to the 10.25.132.0/24 is permitted.
23 At what point in the PPP connection process does the authentication phase occur?
after NCP establishes Layer 3 parameters
after the link initiator receives a Configure-Ack message from the responder
24An administrator is unable to receive e-mail. While troubleshooting the problem, the administrator is able to ping the lo
mail server IP address successfully from a remote network and can successfully resolve the mail server name to an IP
address via the use of the nslookup command. At what OSI layer is the problem most likely to be found?
physical layer
network layer
application layer
25
Refer to the exhibit. Which statement is true about the Frame Relay connection?
The Frame Relay connection is in the process of negotiation.
The “ACTIVE” status of the Frame Relay connection indicates that the network is experiencing congestion.
Only control FECN and BECN bits are sent over the Frame Relay connection. No data traffic traverses the link.
26A light manufacturing company wishes to replace its DSL service with a non-line-of-sight broadband wireless solution
offers comparable speeds. Which solution should the customer choose?
Wi-Fi
satellite
WiMAX
Metro Ethernet
27
Refer to the exhibit. This router is being configured to use SDM, but the SDM interface of the router cannot be accesse
What is the cause of the problem?
The VTY lines are not configured correctly.
28Which option correctly defines the capacity through the local loop guaranteed to a customer by the service provider?
BE
DE
CIR
CBIR
29
Refer to the exhibit. What is placed in the address field in the header of a frame that will travel from the DC router to th
Orlando router?
DLCI 123
DLCI 321
10.10.10.25
10.10.10.26
30Where does a service provider assume responsibility from a customer for a WAN connection?
local loop
demarcation point
demilitarized zone
Showing 3 of 6 <Prev 3
Page:
Assessment System
31 A company is looking for a WAN solution to connect its headquarters site to four remote sites. What are two advantages
dedicated leased lines provide compared to a shared Frame Relay solution? (Choose two.)
reduced jitter
reduced costs
reduced latency
the ability to borrow unused bandwidth from the leased lines of other customers
32
Refer to the exhibit. A host connected to Fa0/0 is unable to acquire an IP address from the DHCP server. The output of th
debug ip dhcp server command shows "DHCPD: there is no address pool for 192.168.3.17". What is the problem?
The address 192.168.3.17 address is already in use by Fa0/0.
The 192.168.3.17 address has not been excluded from the 192Network pool.
33 A network administrator is tasked with maintaining two remote locations in the same city. Both locations use the same
service provider and have the same service plan for DSL service. When comparing download rates, it is noticed that the
location on the East side of town has a faster download rate than the location on the West side of town. How can this be
explained?
The West side has a high volume of POTS traffic.
34Which data link layer encapsulation protocol is used by default for serial connections between two Cisco routers?
ATM
Frame Relay
HDLC
PPP
SDLC
35 Which additional functionality is available on an interface when the encapsulation is changed from HDLC to PPP?
flow control
error control
authentication
synchronous communication
36When NAT is in use, what is used to determine the addresses that can be translated on a Cisco router?
access control list
routing protocol
inbound interface
ARP cache
37
Refer to the exhibit. What statement is true about the core router devices?
They use multiport internetworking devices to switch traffic such as Frame Relay, ATM, or X.25 over the WAN.
They provide internetworking and WAN access interface ports that are used to connect to the service provider network.
They provide termination for the digital signal and ensure connection integrity through error correction and line monitoring.
They support multiple telecommunications interfaces of the highest speed and are able to forward IP packets at full speed on
interfaces.
38
Refer to the exhibit. A network administrator has issued the commands that are shown on Router1 and Router2. A later r
routing tables reveals that neither router is learning the LAN network of the neighbor router. What is most likely the prob
RIPng configuration?
The serial interfaces are in different subnets.
The RIPng network command is missing from the IPv6 RIP configuration.
39 Which two protocols in combination should be used to establish a link with secure authentication between a Cisco and a
non-Cisco router? (Choose two.)
HDLC
PPP
SLIP
PAP
CHAP
40
Refer to the exhibit. This serial interface is not functioning correctly. Based on the output shown, what is the most likely
cause?
improper LMI type
interface reset
unplugged cable
Close Window
Assessment System
Take Assessment - EWAN Final Exam - CCNA Exploration: Accessing the WAN (Version
4.0)
NCP tests the link to ensure that the link quality is sufficient.
42
Refer to the exhibit. Which statement correctly describes how Router1 processes an FTP request packet that enters inter
S0/0/0, and is destined for an FTP server at IP address 172.16.1.5?
The router matches the incoming packet to the statement that is created by access-list 201 permit ip any any command an
allows the packet into the router.
The router reaches the end of ACL 101 without matching a condition and drops the packet because there is no statement tha
was created by access-list 101 permit ip any any command.
The router matches the incoming packet to the statement that was created by the access-list 101 permit ip any 172.16.1.0
0.0.0.255 command, ignores the remaining statements in ACL 101, and allows the packet into the router.
The router matches the incoming packet to the statement that was created by the access-list 201 deny icmp 172.16.1.0
0.0.0.255 any command, continues comparing the packet to the remaining statements in ACL 201 to ensure that no subsequ
statements allow FTP, and then the router drops the packet.
43
Refer to the exhibit. RIPv2 has been configured on all routers in the network. Routers R1 and R3 have not received any R
routing updates. What will fix the issue?
Enable RIP authentication on R2.
Enable CDP on R2 so that the other routers will receive routing updates.
44
Refer to the exhibit. What happens if the network administrator issues the commands shown when an ACL called Manag
already exists on the router?
The commands overwrite the existing Managers ACL.
The commands are added at the end of the existing Managers ACL.
The network administrator receives an error stating that the ACL already exists.
The commands will create a duplicate Managers ACL containing only the new commands being entered.
45 Which security solution has the responsibility of monitoring suspicious processes that are running on a host and that m
indicate infection of Trojan horse applications?
antivirus application
A wildcard mask uses a "1" to identify IP address bits that must be checked.
47
Refer to the exhibit. A network administrator is trying to backup the IOS software on R1 to the TFTP server. He receives t
error message that is shown in the exhibit, and cannot ping the TFTP server from R1. What is an action that can help to i
this problem?
Use correct source file name in the command.
Check that R1 has a route to the network where the TFTP server resides.
48
Refer to the exhibit. A network administrator is creating a prototype to verify the new WAN design. However, the
communication between the two routers cannot be established. Based on the output of the commands, what can be done
solve the problem?
Replace the serial cable .
49
Refer to the exhibit. From the output of the show interface commands, at which OSI layer is a fault indicated?
application
transport
network
data link
physical
50Which type of ACL will permit traffic inbound into a private network only if an outbound session has already been
established between the source and destination?
extended
reflexive
standard
time-based
Close Window
Assessment System
Take Assessment - EWAN Final Exam - CCNA Exploration: Accessing the WAN (Version
4.0)
51 Which IEEE 802.16 broadband wireless technology allows users to connect to the ISP at speeds comparable to DSL and
cable?
Wi-Fi
satellite
WiMAX
Metro Ethernet
Extended ACLs should be applied closest to the source that is specified by the ACL.
Showing 6 of 6 <Prev 6 Next>
Page: