Beruflich Dokumente
Kultur Dokumente
Vane Pumps
nINCLUDED IN DOUBLE
SHAFT SEAL KIT 920073.
F3 EQUIVALENT SEAL
KIT 920075.
270679 COVER
(4 BOLT FLANGE)
379585 HOUSING
*NOTE S/A (INLET)
INSTALL INTO COVER BEFORE 418108 PIN
INSTALLATION OF CARTRIDGE KIT. (2 REQ’D)
NOTE
BRONZE FACES MUST
BE INSTALLED TOWARD
THE ROTOR.
2
MOUNTING ASSEMBLY
ASSEMBLE SEAL FLUSH TO 4535VQ**A**F-***-20(*)
PILOT FACE WITH SPRING FACING INCLUDED IN FOOT SCREW MOUNTING
INWARD AS SHOWN. BRACKET KIT NO. (2 REQ’D) BRACKET
FB-C-10 205533 205077
ASSEMBLE SEAL WITH
SPRING TOWARD BEARING. n SECONDARY SHAFT SEAL
SHAFT TYPE SHAFT SEC. KEY (SEE TABLE ) (USE ON ‘S’ FLANGE
NO. P/N SHAFT MOUNTED MODELS ONLY.)
SEAL
1 STR. KEYED 289083 217596
11 SPLINE 289084
86 STR. KEYED 361763 239751
HEAVY DUTY
114 SPLINE 413027 429282
394974
PRIMARY SHAFT SEAL
131812 BEARING
102949 RETAINING RING
158630 SPIROLOX RING
SCREW PIN (2 INLET SEAL FLEX- ROTOR VANE KIT RING OUTLET CART. F3
MODEL (2 REQ’D) SUPPORT PACK SIDE– (10 VANES & SUPPORT ‘‘O’’ RING SEAL ‘‘O’’ RING BACK-UP KIT CART.
REQ’D) PLATE (4 REQ’D) PLATE KIT 10 INSERTS) PLATE RING RING KIT
1 2 3 4 5 6 7 8 9 10 11 12
NOTE
Cover end cartridge R. H. Rotation Shaft end cartridge R. H. Rotation Standard right hand shaft rotation
cartridges shown. Reverse for left hand
rotation; refer to note.
LH RH LH RH
NOTE
To reverse cartridge kit rotation,
remove the two screws and reverse
RH LH RH LH the location of the inlet support plate
and the outlet support plate. Reinstall
the two screws hand tight. Use pump
cover to align all sections of the
Sharp Edges of Vane Must Lead in Sharp Edges of Vane Must Lead in cartridge. Carefully remove the cover
Direction of Rotation Direction of Rotation and tighten the screws.
For satisfactory service life of these components, use full flow filtration to provide fluid which meets ISO cleanliness code 16/13
or cleaner. Selections from pressure, return, and in-line filter series are recommended.
Printed in U.S.A.