Sie sind auf Seite 1von 7

INSPECTION CIRCLE, JABALPUR

TEST SCHEDULE

Microwave Link (15/18 GHz)


Document No TD/CM/GSM Ph- VII
No of Pages. 06
Issue No. I
Issued By: Inspection Circle, Jabalpur
Approved By: CGM, Inspection Circle
Date of Issue: 14/12/2012
Amendment No (If Any): I
Document No TD/CFA/TS-MW/GSM Ph- VII/30
No of Pages: 06
Issued by: Inspection Circle, Jabalpur
Date of Issue: 25/10/2013

Restricted use by BSNL Employees only

“FIX IT RIGHT AT THE FIRST INSTANCE”


INSPECTION CIRCLE GSM PHASE VII
JABALPUR MW LINK TS AMENDMENT-I

TEST SCHEDULE FOR MICROWAVE LINK


Part A Record:--
SITE NAME: ------------------------------------- SITE-id: --------------------------
BSC: ----------------------------------------------
Latitude at site one ----------- Latitude at other site -----------
Longitude at site one---------- Longitude at other site ----------
Survey report from Planning-----------
SACFA clearance------------------------
Check Hardware Conformity (As per vetted BoM):
Integration with EMS: Yes/No
Antenna size M Polarization---- Vertical Horizontal

Antenna Height
from Ground
(Mtrs)

HOP From Site Id Site Id

Microwave – E Line-up Record

Traffic Capacity 4E1 16E1

Configuration 1+0 1+1

Frequency Band 15Ghz System 18Ghz System


14.5 – 15.35 GHz 17.7 – 19.7 GHZ
Allotted Frequency
Measured Frequency

Check bit rate at MUX it should be


15Ghz System 18Ghz System Measured value
16x2.048Mbps @27.5 MHz BW @27.5 MHz BW
8x2.048Mbps @14 MHz BW @13.75 MHz BW
4x2.048Mbps @ 7 MHz BW @ 7.5 MHz BW

Frequency channel spacing for 16/8/4x2Mbps


.

Check Ethernet port bit rate for 10Mbps/100Mbps base-T

Near End Far End Specification


Site Name
Terminal NE ID
Microwave ID

TD/CFA/TS-MW/GSM Ph- VII/30 Page 1 of 6 Issue I


Dated 25/10/2013
INSPECTION CIRCLE GSM PHASE VII
JABALPUR MW LINK TS AMENDMENT-I

Alarm Indication test


Transmitter frequency
Calculated Receiver level as
per Survey level
Measured Receive level
Deviation (+3dB)

Part B:-

1. Maximum Trans power at antenna port 23dBm for 15 GHz and 26dBm for 18 GHz
Actual maximum Trans power at antenna port :
-To be tested in VT
Settable range of Tx power :
- The Test has been completed in VT. The result of VT Report is as under-
Setting verified at LCT
Minimum settable Power:15 GHz -5dBm, 18 GHz -6dBm
Maximum settable Power:15 GHz +25dBm, 18 GHz +24dBm
- This test may not be carried in field during AT.
2. Transmitter limits for spurious & harmonic emissions at Antennae port : <25 microwatt.
- The Test has been completed in VT. The result of VT Report is as under-

Result : As per VT report, test completed, result as under –


Spurious emission measured at antenna port :
15 GHz
fc-70 MHz - -59.79 dBm fc+70MHz -64.7dBm
18 GHz
fc-70 MHz - -57.60 dBm fc+70MHz -66.50dBm
is less than 25micro Watts(-16 dBm)

- As the test is equipment specific. This test may not be carried in field during AT.

3. Minimum distance between indoor & outdoor unit that the equipment should be able to
support: 120 m or more.
Actual distance : (between indoor & outdoor unit)

Pass criteria:- Actual Distance ≤ 120m


4. Max receive level at antenna port for no deterioration of quality (no errors) i.e. BER of
1x10 -10 or better should be: -20dBm or higher at antenna Port. - As the test is equipment
specific. This test may not be carried in field during AT.
- This Test has been completed in VT. The result of VT Report is as under-
Result : verified maximum Rx level upto -7.5 dBm for no error

3 & -6
5. Threshold at Antenna Port for BER of (i) 1x10 - (ii) 1x10 :
TD/CFA/TS-MW/GSM Ph- VII/30 Page 2 of 6 Issue I
Dated 25/10/2013
INSPECTION CIRCLE GSM PHASE VII
JABALPUR MW LINK TS AMENDMENT-I

- The Test has been completed in VT. The result of VT Report is as under-
15 GHz---- -87.5dBm & -87.0dBm
18 GHz---- -87.2dBm & -86.7dBm

- As the test is equipment specific. This test may not be carried in field during AT.
6. System performance value (Minimum):
Procedure:- Change Trans Power from 0 dbm to 23 dbm and check from LCT : the Tx Power ,Rx
Power and BER for each step.
Received Power should be -75 dBm or better and BER should be 1x10-10 or better for data
transmission at 16x2Mbps.

7. BER Performance:
-10
Better than 1x10 level for 5 minutes of duration.
OK/Not OK

Local Site Tests for both Sites

Installation Check & data (Visual check) OK/Not OK

Earthing of equipment I/D

Earthing of equipment O/D


Type Serial No HW rev SW rev
IDU
ODU1
ODU2

Verification of Power Link Signal


Status Activity level
Visual Indications for local & remote stations OK/Not OK

(i.e. Route failure, Equipment failure, Power supply o/p failure, Transmit power low, quality
deterioration, sync failure, No data input, status of protection switching, EI status, IDU/ODU
status)
Check local on-line monitoring through LCT/Laptop regarding health of the system
OK/Not OK

TD/CFA/TS-MW/GSM Ph- VII/30 Page 3 of 6 Issue I


Dated 25/10/2013
INSPECTION CIRCLE GSM PHASE VII
JABALPUR MW LINK TS AMENDMENT-I

(i.e. transmit power, Receive RF level, System BER performance, Equipment power
supply, System alarm, E1 utilization status, RF channel working status, software version &
Change-over of TX/RX path etc)

Test Results
Web LCT
Transmitter Power dbm dbm
Receiver input level dbm dbm
Transmitter Frequency MHz MHz
RX Frequency MHz MHz

Redundancy Check/Alarm simulation for IDU & ODU (only for 1 + 1) Y/N

Fan Unit in built Ok/Faulty

Check for sequential termination of E1s in DDF Y/N

Input E1 Alarm testing (Loop Back from DDF)


Speed Test

A. Test for Ethernet:


Use FE port and check that minimum 90Mbps throughput is available at Link Level. Ok/Not OK

B. Test for PCM:


1. 4 Port :
E1-1 Ok/Not OK
E1-2 Ok/Not OK
E1-3 Ok/Not OK
E1-4 Ok/Not OK
2. 16 Port :
E1-1 Ok/Not OK
E1-2 Ok/Not OK
E1-3 Ok/Not OK
E1-4 Ok/Not OK
E1-5 Ok/Not OK
E1-- Ok/Not OK
E1-16 Ok/Not OK

Omni/Selective OK
Not OK

Hop Related Tests

THROUGH TEST

TD/CFA/TS-MW/GSM Ph- VII/30 Page 4 of 6 Issue I


Dated 25/10/2013
INSPECTION CIRCLE GSM PHASE VII
JABALPUR MW LINK TS AMENDMENT-I

1. LINK STABILITY THROUGH Web LCT (15 mins/24 hrs)


AT ES UT SES Acceptable Range (ES) 0.018%

Acceptable Range (SES) 0.003%

2. LINK STABILITY THROUGH BER Meter (Max. 5 Mins)

AT ES UT SES Acceptable Range (ES) 0.018%

Acceptable Range (SES) 0.003%

E1 Testing on the hop using soft Loop at Far end

1. 4 Port:
E1-1 Ok/Not OK
E1-2 Ok/Not OK
E1-3 Ok/Not OK
E1-4 Ok/Not OK
2. 16 Port:
E1-1 Ok/Not OK
E1-2 Ok/Not OK
E1-3 Ok/Not OK
E1-4 Ok/Not OK
E1-5 Ok/Not OK
E1-- Ok/Not OK
E1-16 Ok/Not OK

Diagnostics from NMS:


1-Local loop back test OK/Not OK

2-Remote loop back test OK/Not OK

3-Loop back to remote end OK/Not OK

4-Receive power level determination OK/Not OK

5-Receive power signal quality determination OK/Not OK

6-Quasi random sequence generator OK/Not OK

TD/CFA/TS-MW/GSM Ph- VII/30 Page 5 of 6 Issue I


Dated 25/10/2013
INSPECTION CIRCLE GSM PHASE VII
JABALPUR MW LINK TS AMENDMENT-I

7-Data output failure OK/Not OK

8-System log capability for alarms and test results OK/Not OK

9-Check for remote supervisory & telecommand facilities through LCT/NMS or any other
Suitable mechanism. OK/Not OK

Date of commissioning

Annexure-I

TD/CFA/TS-MW/GSM Ph- VII/30 Page 6 of 6 Issue I


Dated 25/10/2013

Das könnte Ihnen auch gefallen