Beruflich Dokumente
Kultur Dokumente
1
CALAQUE’S REVIEW CENTER
c. Area of the plates 23. The standard method of is shorted, what is their 32. Which of the following is
d. Type of material used controlling the output equivalent resistance? the prepared test used to
in the plates. voltage of 440V, 60Hz ac a. 1.9-ohm check the switchgear
19. Sparking occurs when a generator is accomplished b. 0 insulation?
motor disconnected is by adjusting the c. 2.85-ohm a. Dc high potential test
switched off. This is due to a. Number of poles d. 1.333-ohm b. Mega-ohmmeter test
the high ____ of the b. Prime mover speed 28. What is the purpose of the c. Ac high potential test
motors windings c. Alternator’s field of poles and winding in a d. Varley loop test
a. Inductance excitation generator? 33. Three 10-ohm resistors are
b. Capacitance d. Load on the alternator a. To cut down the connected in wye
c. Resistance 24. How do you call the power magnetic flux lines configuration. What will
d. All of these lost in heat in the windings b. To neutralized the be the ohmmeter reading if
20. If a live conductor is due to flow of current effect of the armature the terminals of the meter
contacted accidentally, the through the copper reaction are connected between any
severity of the electric windings? c. To produce magnetic two lines terminals of the
shock is determined a. Hysteresis loss flux lines wye connections?
primarily by ______. b. Copper loss d. All of these a. 12 ohm
a. The size of the c. Eddy current loss 29. A single phase ac motor b. 5 ohm
conductors d. Stray load loss has a full load current of c. 30 ohm
b. The contact resistance 25. What is the purpose of 30A. the rating of the two d. 20 ohm
c. The current in the staggering brushes in a dc fuses for line protection is
conductor machine? a. 60A
d. Whether the current is a. To reduce chattering b. 100A
34. Short circuit test on a
ac or dc b. To cover more area of c. 30A
transformer is used to
21. What is the function of a the commutator for d. 90A
determine ______.
phase-balanced relay? more power 30. A new fully charge lead-
a. Transformation ratio
a. Open field contactor c. To even out the load acid battery will measure
b. Equivalent parameters
in case of unbalanced d. To prevent the uneven ____
on the high side
b. Keeps correct phase wear of the a. Exactly 12V
c. Polarity of the
balance commutator b. More than 12V
transformers
c. Interlock phases 26. When the mechanical load c. Below 12V
d. All of these
d. Close field contactor is removed, which of the d. None of these
35. Which of the following
in case of unbalance following motors run at a 31. If the multiplier of the
parts of an ac motor
22. Which of the following is a high speed? resistor is a silver color,
corresponds to the
typical resistance and a. Shunt motor the ohmic value of the
armature of the dc motor?
power rating of a carbon b. Compound motor resistor is expected to be
a. Field coils
composition resistors? c. Synchronous motor ___.
b. Rotor
a. 4700 ohm, 1 W d. Series motor a. Greater than 1 ohm
c. Stator
b. 100 ohm, 5W 27. Three resistance of 10, 4, b. Less than 1 ohm
d. Armature
c. 1000 ohm, 10W and 6 ohms respectively c. Either A or B
d. 6800 ohm, 100W are connected across each d. Neither A or B
other. If the 6-ohm resistor
2
CALAQUE’S REVIEW CENTER
3
CALAQUE’S REVIEW CENTER
1. A
2. C
3. A
4. B
5. B
6. C
7. B
8. A
9. D
10. A
11. A
12. D
13. B
14. A
15. C
16. A
17. B
18. D
19. A
20. B
21. A
22. A
23. B
24. B
25. D
26. D
27. B
28. C
29. D
30. B
31. B
32. C
33. D
34. B
35. C