Beruflich Dokumente
Kultur Dokumente
2. Vessel MAWP of existing vertical vessel will be affected for which of the
following?
a. 1100 mm
b. 1105 mm
c. 1095 mm
d. 1110 mm
4. In thickness formula for internal pressure for shell, term ‘E’ refers to:
a. 10 psi
b. 43.3 psi
c. 4.33 psi
d. None of the above
1
6. A new pressure vessel should be inspected to which of the
following codes?
a. API 510 ,
b. ASME Sec. 1,
c. ASME Sec. VIII Div. 1,
d. None of these
a. API 510
b. API 570
c. ASME Section VIII Div.1
d. None of above
a. Longitudinal joints
b. Circumferential joints, shell to shell
c. Shell to hemispherical head joint
d. a and c above
a. Torispherical
b. Hemispherical
c. Ellipsoidal
d. All will be same
a. 3 to 1 min
b. 4 to 1 min
c. 3 to 2 min
d. 1 to 2 min
11. ASME Sec VIII Div. 1 specifies different acceptance level for weld
reinforcement, which of the following statements are true in your
opinion?
2
c. Permitted reinforcement for long. seems is same as
circ. seems
d. Permitted reinforcement does not depend on
location of seems.
14. A Pressure Vessel is designed for 0.85 joint efficiency with full
penetration welds. RT requirement will be:
a. Nil
b. Spot
c. 100 %
d. T-joints radiography
a. 25 inch, 4 inch
b. 50 inch, 3 inch
c. 40 inch, 3¾ inch
d. 25 inch, 2 inch
16. If there is a conflict between ASME VIII & API 510 Code, for
vessels in-service:
17. Two head to shell joints, one joining a seamless Hemisph, head to
shell was radiographed for full length and the other joint joining
3
seamless std. torisph. head to shell was spot radiographed, The weld
joint efficiency for each of these heads respectively will be:
a. 1, 0.85
b. 1, 1
c. 0.85, 1
d. 0.85, 0.85
18. ASME Sec. VIII Div. 1 recommends use of U.T. in place of R.T. (for a
fully radiographed vessel) for:
19. Vessel MAWP for tall vertical vessel will normally be:
a. RT3 means E = 1
b. RT2 means E = 0.85
c. RT1 and RT2 may mean E = 1
d. RT4 means spot radiography
4
API 510 PREPARATORY
Exam 1 - Closed Book
ANSWER KEY