Beruflich Dokumente
Kultur Dokumente
Issue 01
Date 2015-12-30
and other Huawei trademarks are trademarks of Huawei Technologies Co., Ltd.
All other trademarks and trade names mentioned in this document are the property of their respective
holders.
Notice
The purchased products, services and features are stipulated by the contract made between Huawei and
the customer. All or part of the products, services and features described in this document may not be
within the purchase scope or the usage scope. Unless otherwise specified in the contract, all statements,
information, and recommendations in this document are provided "AS IS" without warranties, guarantees or
representations of any kind, either express or implied.
The information in this document is subject to change without notice. Every effort has been made in the
preparation of this document to ensure accuracy of the contents, but all statements, information, and
recommendations in this document do not constitute a warranty of any kind, express or implied.
Website: http://www.huawei.com
Email: support@huawei.com
Contents
1 Introduction.................................................................................................................................... 1
1.1 Appearance ....................................................................................................................................................... 1
1.2 Physical Ports ................................................................................................................................................... 1
1 Introduction
The MRFU can be used in an indoor cabinet or a protective outdoor cabinet. The MRFU can
modulate, demodulate, combine, and divide baseband and RF signals. It also processes
baseband and RF signal data. With the Software Defined Radio (SDR) technology, the MRFU
can work either in GU or GL dual-mode through software configuration modification.
1.1 Appearance
Figure 1-1 shows the appearance of the MRFU.
2 Technical Specifications
2.2 Capacity
Table 2-2 Single-mode capacity
Mode Capacity
GSM Each MRFU supports 6 TRXs.
UMTS (Only 900MHz MHz frequency band supported) Each MRFU supports 4
carriers.
LTE Each MRFU supports one carrier. The LTE bandwidth is 1.4, 3, 5, 10, 15,
or 20 MHz.
Mode Capacity
The receiver sensitivity of GSM, as recommended in 3GPP TS 51.021, is measured in the central
band (80% of the entire operating band, excluding the edge band) at the antenna connector on the
condition that the channel rate is 13 kbit/s and the Bit Error Rate (BER) is not higher than 2%.
The receiver sensitivity of UMTS, as recommended in 3GPP TS 25.104, is measured in the entire
operating band at the antenna connector on the condition that the channel rate is 12.2 kbit/s and the
BER is not higher than 0.001.
The receiver sensitivity of LTE, as recommended in 3GPP TS 36.104, is measured under a 5 MHz
channel bandwidth based on the FRC A1-3 in Annex A.1 (QPSK, R = 1/3, 25 RBs) standard.
Table 2-5 Typical output power of MRFU (900 MHz/1800 MHz, single-mode)
1 0 0 80 80 0 0 /
2 0 0 40 40 0 0 /
3 0 0 27 31 0 0 /
4 0 0 20 27 0 0 /
5 0 0 16 20 0 0 /
6 0 0 12 20 0 0 /
0 0 1 0 0 0 80 5, 10, 15,
20
Table 2-6 Typical output power of MRFU (900 MHz, UMTS, two combined)
1 (MIMO) 2x60
2 (MIMO) 2x40
3 (MIMO) 2x27
4 (MIMO) 2x20
Number of GSM Number of UMTS Output Power per Output Power per
Carriers Carriers GSM Carrier (W) UMTS Carrier (W)
1 1 80 40
1 2 40 20
2 1 20 40
2 1 30 20
2 2 20 20
3 1 20 20
3 2 16 10
3 2 10 20
4 1 12 20
4 2 10 10
5 1 10 20
Table 2-8 Typical output power of MRFU (900 MHz/1800 MHz, GL MSR)
2 1 20 30 1.4, 3, 5, 10, 15
3 1 20 20 1.4, 3, 5, 10, 15
4 1 12 20 10
5 1 10 20 10
Table 2-10 Power consumption of the BTS3900 (Ver.B) (-48 V) (configured with MRFU, 1800
MHz)
Table 2-12 Power consumption of the BTS3900A(Ver.B) (AC) (configured with MRFU , 1800
MHz)
Table 2-14 Power consumption of the BTS3900L (Ver.B) (-48V) (configured with MRFU , 1800
MHz)
Table 2-16 Power consumption of the BTS3900AL(Ver.A) (AC) (configured with MRFU , 1800
MHz)
Item Specifications
Dimensions (H x W x D) 9 U x 14 HP x 308.5 mm (including panels)
Weight 12 kg
Item Specifications
Number of CPRI ports 2
CPRI data rate 1.25 Gbit/s, 2.5 Gbit/s and 4.9 Gbit/s
Topology Star, and dual-star