Beruflich Dokumente
Kultur Dokumente
00
Overview
- Unit : tonf, m
- Beam Elements
- Beam Load
- Nodal Force
- Constraint
Result Evaluation
- Deformation
- Result Combination
- Moment Diagram
Step
This model is a 2D rahmen type model using Beam element, which is a 1D element. Columns and beam sections of rahmen are defined
by H-sections and analysis is performed by defining nodal loads and distributed loads of elements. Check the result of the bending
moment and save it with the Animation function.
Learning Target
How to model 1D Mesh using Geometry> Line, Auto Mesh> Edge function
1D Property Definition, Element Beam Load Definition
How to Save and View Contour Results with the Animation Function
Plane Frame 1
Step
02 Analysis Setting
Procedure
1 Model Type : [3D]
Procedure
1 Location : (0,0) , <0, 3>” 1
1 1
2 Click [OK] Button
X-Axis
6
1 ( ): “ABS x, y”, < >: “REL dx, dy”
(0) same as (0, 0)
P1 1 P2 2 P3
L1 L2
Step
Procedure
1 Select [ ] Displayed
[Hide All]
4
Plane Frame 3
Step
7
Step
1 Create [1D]
3
2 Select [Beam] tab
6 Section : “H-Section”
8 Offset : [Center-Center]
10
8 9
9
8
Step
Procedure
1
1 Select : “Change Property” , “1D”
Plane Frame 5
Step
3 Click “Isometric 1” 1
4
Step
4 5
1 i-End
Green (y)
j-End
Blue (z) Red (x)
Step
12 Click[Orientation]>BetaAngle:180 5
13
Click [OK] > Click [OK]
2
Plane Frame 7
Step
4
Step
6 Model Trees :
“Mesh – Frame” 5 6
5 Value : Fraction : 3
8
“x1(0), w1(-1), x2(1), w2(-2)”
6 Click [Apply] Button
4 9 2
7 Select 1 Element Marked by
“O” (See Figure) 5 10
7
8 Type : “Force – Concentrated”
9 Direction : “Global Z”
12
Step
Plane Frame 9
Step
1 Name : “Comb“
3 Factor : “1.0”
5 Factor : “0.5”
6
Step
[ActiveSets] Window
4 Check on “Solve Each Load Set
Independent ”
4 5
Procedure
1 Perform click
2 OK click
2
Step
21 Result :
Frame Analysis > Linear Static > 1D Element Forces/Moments
Procedure
1 Double Click [BENDING MOM.]
Plane Frame 11
Step
1 2