Beruflich Dokumente
Kultur Dokumente
2.A pair of spur gears has a module of 3 mm and face width 27 mm. It is used to connect
a prime mover of 3 kW power running at 1440 rpm with a machine requiring a torque of
59.683 N-m. The gears are made of alloy steel with ultimate tensile strength of 720MPa
with a hardness of 350 BHN. Determine the f.o.s based on bending and pitting if the total
tooth error is 40 microns and the deformation factor is 11200 N/mm 2. The number of
teeth on pinion is 12 and 20º stub involute profile is used for both the gears. Use
following data:
2 .64
Y =0 . 55−
z
Service factor 1.2
21 v (Ceb+ Pt )
Pd =
21 v + √ (Ceb+ Pt )
6 A pair of parallel helical gear consisting of 18 teeth pinion meshing with 63 teeth gear.
The pinion rotates at 1440rpm. The normal pressure angle is 20º while the helix angle is
23º. The face width is 30 mm and the normal module is 3 mm. The pinion and gear are
made of plain carbon steel 40C8 (Sut = 600 N/mm2). The service factor and F.O.S. are 1.5
and 2.0 respectively. Assume that the velocity factor accounts dynamic load. Calculate the
power transmitting capacity of the gears. [6]
5.6
cv=
5 . 6+ √ v
7 Obtain the expression for ratio factor used in wear strength equation of bevel gear
8 Define and explain strength rating and wear rating of worm gear
12 Draw the free body diagram for components of gear tooth forces when pinion rotates
clockwise direction when seen from left. Assume pinion having right hand threads and
its below the helical gear.
13 With neat sketch explain mounting of taper roller bearing. Write designation of
bearing no. 6307
14Write and explain load life relationship for rolling contact bearing
16A pair of worm gear designated as 2/52/10/4 transmit 10 kW power at 720 rpm supplied
to worm shaft. The coefficient of friction is 0.4 and pressure angle is 20º. Assume worm
is above the worm gear and rotates clockwise direction when viewed from left. If worm
is left hand, determine and show by neat sketch
i) Component of tooth forces acting on worm and worm gear
ii) Efficiency of worm gear.
20) A pair of worm gear designated as 3/60/10/6 transmit 5 kW power at 1440 rpm
supplied to worm shaft. The coefficient of friction is 0.112 and pressure angle is 20º.
Determine:
i) Component of tooth forces acting on worm and worm gear.
ii) Also represent the directions of the forces on the drawing if the worm rotates anti
clockwise.
iii) Efficiency of worm gear.
21) What is bearing characteristics number as applied to journal bearing and its
significance.