Sie sind auf Seite 1von 2

SAFETY DATA SHEET

Argon
PRODUCT: ARGON MSDS NR: EIGC-ARG-003 VERSION: 2.01 DATE: 1/8/04 PAGE: 1/2

1 IDENTIFICATION OF THE SUBSTANCE/ container handling instructions. Keep container below


PREPARATION AND OF THE COMPANY 50°C in a well ventilated place.
Product name Argon
9 EXPOSURE CONTROLS/PERSONAL
Chemical formula Ar PROTECTION
Emergency see below Ensure adequate ventilation.
phone Nos
10 FIRST AID MEASURES
2 HAZARDS IDENTIFICATION
Inhalation
Hazards identification Compressed gas In high concentrations may cause asphyxiation.
In high concentration Symptoms may include loss of mobility/consciousness.
may cause asphyxiation Victim may not be aware of asphyxiation. Remove
victim to uncontaminated area wearing self contained
3 COMPOSITION/INFORMATION ON INGREDIENTS breathing apparatus. Keep victim warm and rested. Call
a doctor. Apply artificial respiration if breathing stopped.
Substance/Preparation Substance
Ingestion
Components/Impurities Contains no other Ingestion is not considered a potential route of
components or impurities exposure.
which will influence the
classification of the 11 FIRE FIGHTING MEASURES
product.
Specific hazards Exposure to fire may cause
CAS Nr 07440-37-1 containers to rupture/explode. Non
flammable
4 PHYSICAL AND CHEMICAL PROPERTIES
Hazardous None
Molecular weight 40 combustion
products
Melting point -189 °C
Suitable All known extinguishants can be
Boiling point -186 °C
extinguishing used.
Critical temperature -122 °C media
Relative density, gas 1.38 (air=1) Specific methods If possible, stop flow of product.
Move away from the container and
Relative density, liquid Not applicable
cool with water from a protected
Vapour Pressure 20°C Not applicable position.
Solubility mg/l water 61 mg/l Special protective In confined space use self
equipment for contained breathing apparatus.
Appearance/Colour Colourless gas
fire fighters
Odour None
12 ACCIDENTAL RELEASE MEASURES
Other data Gas/vapour heavier than
air. May accumulate in Personal precautions
confined spaces, Evacuate area. Wear self-contained breathing
particularly at or below apparatus when entering area unless atmosphere is
ground level. proved to be safe. Ensure adequate air ventilation.
Environmental precautions
5 STABILITY AND REACTIVITY
Try to stop release. Prevent from entering sewers,
Stability and reactivity stable under normal conditions. basements and workpits, or any place where its
accumulation can be dangerous.
6 TOXICOLOGICAL INFORMATION
Clean up methods
No known toxicological effects from this product. Ventilate area.

7 ECOLOGICAL INFORMATION 13 DISPOSAL CONSIDERATIONS


No known ecological damage caused by this product. General to atmosphere in a well ventilated place. Do
not discharge into any place where its accumulation
8 HANDLING AND STORAGE could be dangerous. Contact supplier if guidance is
required.
Suck back of water into the container must be
prevented. Do not allow backfeed into the container.
14 TRANSPORT INFORMATION
Use only properly specified equipment which is suitable
for this product, its supply pressure and temperature. UN Nr 1006
Contact your gas supplier if in doubt. Refer to supplier's
Class 2.2
SAFETY DATA SHEET

Argon
PRODUCT: ARGON MSDS NR: EIGC-ARG-003 VERSION: 2.01 DATE: 1/8/04 PAGE: 2/2

ADR/RID 15 REGULATORY INFORMATION


Classification Code 2.1° A
Number in Annex I Not Included in Annex I
ADR/RID Hazard Nr 20 of Dir 67/548
Labelling ADR Label 2: non flammable Labelling of cylinders
non toxic gas - Symbols Label 2: non flammable non toxic
gas
Other transport information
Avoid transport on vehicles where the load space is not
16 OTHER INFORMATION
separated from the driver's compartment. Ensure
vehicle driver is aware of the potential hazards of the Ensure all national/local regulations are observed.
load and knows what to do in the event of an accident Asphyxiant in high concentrations. Keep container in
or an emergency. Before transporting product well ventilated place. Do not breathe the gas. The
containers ensure that they are firmly secured and: hazard of asphyxiation is often overlooked and must be
- cylinder valve is closed and not leaking stressed during operator training. Users of breathing
- valve outlet cap nut or plug (where provided) is apparatus must be trained. Before using this product in
correctly fitted any new process or experiment, a thorough material
- valve protection device (where provided) is correctly compatibility and safety study should be carried out.
fitted - there is adequate ventilation. Details given in this document are believed to be
- compliance with applicable regulations. correct at the time of going to press. Whilst proper care
has been taken in the preparation of this document, no
liability for injury or damage resulting from its use can
be accepted.

EMIRATES INDUSTRIAL GASES Co. L.L.C.


Toll Free Number: 8005414
Website: www.eigco.com
Email: tsales@eigco.com
DUBAI AL QUOZ: ABU DHABI
Dubai Sharjah Road: Tel: 00971-4-3382456 Al-Ruwais Industrial Gases Co. L.L.C.
Tel: 00971-4-2660649 / 2660775 Fax: 00971-4-3382666 Tel: 00971-2-5553809 / 5559295
Fax: 00971-4-2664168 Fax: 00971-2-5553979
FUJAIRAH AJMAN
Tel: 00971-9-2281060 Tel. 00971-6-7435211
Fax: 00971-9-2281070 Fax: 00971-6-7437907

Das könnte Ihnen auch gefallen