Beruflich Dokumente
Kultur Dokumente
Diameter of Bolt d = 24 mm
Thread Length l = 30 mm
Tensile Strength of Pad Plate Fu = 470 N/mm2 (4404TMBOSG0003T , Clause 5.4)
= 303.40 N/mm 2
= 144.80 N/mm 2
Allowable Tensile Stress for combined F = (44)2 4.39 fv2 (AISC, Chapter J, Table J3.3)
Allowable Diametral Pressure (Bolt Hole) Fp = 1.2 Fu (AISC, Chapter J3.7 Eq - J3-1)
= 564.00 N/mm 2
kN kN kN
Where
Fx 2
Fy 2
Tension Shear
N sAx T fv Remarks
Condition sAx / Ft fv / Fv
(kN) (N/mm2) (kN) (N/mm2)
Diametral Pressure:
Diametral pressure of bolt holes tp = T / (d x l)
Condition tp tl Remarks
tP / Fp tl / Fv
(N/mm ) 2
(N/mm ) 2
Diameter of Bolt d = 24 mm
Thread Length l = 30 mm
Tensile Strength of Pad Plate Fu = 470 N/mm2
gb = 1
gc = 1
Nbs = 150.064 kN
Nbt = 159.203 kN
kN kN kN
Bolt Forces
Nt = 70 kN
√(𝐹_𝑥^2+𝐹_𝑧^2 )/𝑁_𝐵𝑜𝑙𝑡
Maximum shear force per bolt Ns =
Ns = 40 kN
Safe
Diametral Pressure:
(1) = Fy(max)
(2) = Fy(min) (Negative value corresponds to Uplift forces)
Allowable Factor
In-Service 1.00
Tow / Sea Transport 1.33 1/3 increase
𝐹_𝑥/(0.707×
tlly = 〖𝑎 ×2×𝑙 〗 _𝑝𝑎𝑑 )
𝐹_𝑦/(0.707×
tllz = 〖𝑎 ×2×𝑙 〗 _𝑝𝑎𝑑 )
(𝐹_𝑧× √2/2
t^ = s^ = )/(0.707×𝑎×𝑁×𝑏𝑒𝑓
𝑓)
Allowable stresses
Yeild Stress Fy = 345 N/mm2
fu = 470 N/mm2
βw = 0.89
For In-Service η0 = 0.75
For Sea-Transport η0 = 0.80
Fz , R2 =
Condition t^ = s^ tllx tlly seq R1 = s^/(fu*η0)
KN σeq/(fu*η0/βw)
SEA-TRANS 210.00 118.26 0.00 74.44 269.38 0.24 0.48
IN-SERVICE 210.00 118.26 0.00 74.44 269.38 0.34 0.68