Beruflich Dokumente
Kultur Dokumente
com
API 5L-This International Standard specifies requirements for the manufacture of two product
specification levels(PSL 1 and PSL 2) of seamless and welded steel pipes for use in pipeline transportation
systems in the petroleum and natural gas industries.
ASTM A53-This Standard is Specification for Pipe, Steel, Black and Hot-Dipped, Zinc-Coated, Welded
and Seamless.Pipe ordered under this specification is intended for mechanical and pressure applications and
is also acceptable for ordinary uses in steam, water, gas, and air lines.
EN10219-This Standard is for Cold formed welded structural hollow sections of non-alloy and fine grain
steels.
Just because it's for different applications, and the thickness tolerance is different to each other.
SMLS pipe b
Note:
a If the purchase order specifies a minus tolerance for wall thickness smaller than the applicable value given
in this table, the plus tolerance for wall thickness shall be increased by an amount sufficient to maintain the
applicable tolerance range.
b For pipe with D W 355,6 mm (14.000 in) and t W 25,0 mm (0.984 in), the wall-thickness tolerance locally
may exceed the plus tolerance for wall thickness by an additional 0,05 t, provided that the plus tolerance for
mass (see 9.14) is not exceeded.
c The plus tolerance for wall thickness does not apply to the weld area.
d See 9.13.2 for additional restrictions.
API 5L, ISO 9001, ISO 14001, ISO18001 certified pipe manufacturer.
Contact Us at enquiry@hysteelpipe.com
HYSP Steel Pipe www.hysteelpipe.com
Weight (Mass)—The weight (mass) of the pipe shall not vary more than 6 10 % from its specified weight
(mass), as derived by multiplying its measured length by its specified weight (mass) per unit length.
Diameter—For pipe NPS 11⁄2 [DN 40] or smaller, the outside diameter at any point shall not vary more
than 6 1⁄64 in. [0.4 mm] from the specified outside diameter. For pipe NPS 2 [DN 50] or larger, the outside
diameter shall not vary more than 6 1 % from the specified outside diameter.
Thickness—The minimum wall thickness at any point shall be not more than 12.5 % under the specified
wall thickness.
3. EN10219-Thickness Tolerance
T ≤ 5 mm ± 10 %
T ≤ 5 mm ± 10%
Thickness (T) T > 5 mm ± 0,5 mm
T > 5 mm ± 0,5 mm
For D > 406,4 mm:
From the above table of three steel pipe standard, we can see the thickness tolerance in ASTM A53 is wide. Just
because of the application of ASTM A53 standard is very ordinary. So, the requirement of A53 steel tube is not so high.
We will compare other standard requirements for you in pipe field. You can comments below if there is anything
needed to be revised.
API 5L, ISO 9001, ISO 14001, ISO18001 certified pipe manufacturer.
Contact Us at enquiry@hysteelpipe.com