Beruflich Dokumente
Kultur Dokumente
JEE-ADVANCE-New Model-VII-P1-Model
Time: 3:00 Hours IMPORTANT INSTRUCTIONS Max Marks: 240
MATHEMATICS:
+Ve - Ve No.of Total
Section Question Type
Marks Marks Qs marks
Sec – I(Q.N : 1 – 5) Questions with Single Correct Choice 3 -1 5 15
Sec – II(Q.N : 6 – 10) Questions with Multiple Correct Choice 5 -2 5 25
Questions with Comprehension Type
Sec – III(Q.N : 11 – 16) (2 Comprehensions – 3 + 3 = 6Q) 4 -2 6 24
Sec – IV(Q.N : 17 – 20) Questions with three digit Integer Answer Type (000-999) 4 0 4 16
Total 20 80
PHYSICS:
+Ve - Ve No.of Total
Section Question Type
Marks Marks Qs marks
Sec – I(Q.N : 21 – 25) Questions with Single Correct Choice 3 -1 5 15
Sec – II(Q.N : 26 – 30) Questions with Multiple Correct Choice 5 -2 5 25
Questions with Comprehension Type
Sec – III(Q.N : 31 – 36) (2 Comprehensions – 3 + 3 = 6Q) 4 -2 6 24
Sec – IV(Q.N : 37 – 40) Questions with three digit Integer Answer Type (000-999) 4 0 4 16
Total 20 80
CHEMISTRY:
+Ve - Ve No.of Total
Section Question Type
Marks Marks Qs marks
Sec – I(Q.N : 41 – 45) Questions with Single Correct Choice 3 -1 5 15
Sec – II(Q.N : 46 – 50) Questions with Multiple Correct Choice 5 -2 5 25
Questions with Comprehension Type
Sec – III(Q.N : 51 – 56) (2 Comprehensions – 3 + 3 = 6Q) 4 -2 6 24
Sec – IV(Q.N : 57 – 60) Questions with three digit Integer Answer Type (000-999) 4 0 4 16
Total 20 80
Sec:Sr.IPLCO/IC/ISB/LIIT _Adv_Q.P space for rough work Page 2
Sri Chaitanya IIT Academy 21-04-16__ Sr.IPLCO/IC/ISB/LIIT _JEE-ADV_(New Model-VII_P1)_GTA-5_Q.P
1
1
C)
0
2
2 ex n x dx 1 1 x 1 dx
D)
0
2
2 ex n x dx 1 1 x 1 dx
1
dx
2. x 2
is equal to
1 x 1 x 4 3x 2 1
A) B) C) D)
2 4 3 8
3. There are twenty points A1 , A2 ,...., A20 on a circle. The number of ways of selecting 4
points such that there are atleast two points in between any two selected points is
A) 20
C1.11 C3 B) 5.11 C3 C) 5.10 C3 D) none of these
Sec:Sr.IPLCO/IC/ISB/LIIT _Adv_Q.P space for rough work Page 3
Sri Chaitanya IIT Academy 21-04-16__ Sr.IPLCO/IC/ISB/LIIT _JEE-ADV_(New Model-VII_P1)_GTA-5_Q.P
4. The perpendicular distance from origin to the line r.a 1, r .b 1,
a b ab a b a b
A) B) 2
C) D)
ab ab ab ab
B) If the coin tossed is fair and shows exactly 1 head then the probability that ‘’Z’’
3
takes 2 is
7
3
C) If the tossed coin is biased with a probability of for showing head and shows
4
8
exactly 1 head then the probability that ‘’Z’’ takes 2, is
11
3
D) If the tossed coin is biased with a probability of for showing head and shows
4
24
exactly 1 head then the probability that ‘’Z’’ takes 2, is
31
8. Normal at any point P on a rectangular hyperbola, meets its axes in “G” and ‘’g’’
and C be the centre of the rectangular hyperbola. Then which of the following
statement(s) is / are correct
A) PG Pg B) PG PC C) Pg PC D) PG 2 PC
R 3 13 3 14 3 15 ........ 3 1012
1012
I 3 x dx then which of the following is/are correct?
12
A) L R 2I B) R I C) L I D) L R 2I
Passage: 2
x2 y 2
Consider a parabola y2 4 x & an ellipse 1. Consider a point P h,k , where
50 8
h,k N 0 from which normals, are drawn to the parabola.
14. Which of the following is/ are correct
A)Number of points P h,k on the ellipse from which exactly two distinct normals
can be drawn, is 2
B) Number of points P h,k on the ellipse from which exactly two distinct normals
can be drawn, is 4
C) If k=0, then number of points P h,k inside the ellipse from which exactly three
normals can be drawn, 5
D) If k=0, then number of points P h,k inside the ellipse from which exactly
three normals can be drawn, 6
15. Which of the following is/ are correct
A) If h 6 , then number of points P h,k outside the ellipse from which exactly
three normals canbe drawn, is 2
B) If h 2 , then number of points P h,k inside the ellipse from which exactly one
normal can be drawn,is 6
C) If h 6 , then number of points P h,k outside the ellipse from which exactly
three normals can be drawn, is 6
D) If h 2 , then number of points P h,k inside the ellipse from which exactly one
normal can be drawn,is 8
is/are _________
20. If C cos ,cos 2 , cos 3 and S sin ,sin 2 ,sin 3 are equal sets then number of
values in 0, 2
A B
2 2
C1 r C1 r C1 r 2 C1 r 2
A) B) C) D)
6 6 9 9
22. One digital watch ‘A’ was showing 1 : 12 : 32 and an old watch ‘B’ not having
seconds hand was showing 1 : 10 ; at the moment actual time was 1 : 10 : 15
A) ‘A’ is more precise but less accurate than ‘B’
B) ‘A’ is less precise but more accurate than ‘B’
C) ‘A’ is both more accurate and precise
D) ‘B’ is both more accurate and precise
Sec:Sr.IPLCO/IC/ISB/LIIT _Adv_Q.P space for rough work Page 11
Sri Chaitanya IIT Academy 21-04-16__ Sr.IPLCO/IC/ISB/LIIT _JEE-ADV_(New Model-VII_P1)_GTA-5_Q.P
23. In the figure shown a uniform ring of mass m is placed on a rough horizontal
platform. The coefficient of friction between left half of ring and table is 1
whereas between right half and table is 2 . The ring has angular velocity in
clockwise sense. Find the magnitude of instantaneous acceleration of centre c
of ring. Given 1 0.6 , 2 0.2 and g 10 m / s 2 .
A) 4m / s 2 B) 2m / s 2 C) 1m / s 2 D) Zero
24. Figure shows an isolated system of two smooth spheres ‘A’ and ‘B’ at rest.
mA= mB = m ; 2RA=RB=R. Now an impulse is imparted to sphere A. Find the
maximum value of impulse such that sphere ‘A’ does not loose contact with ‘B’.
B
A
I
Gm3 2Gm3 4Gm3
A) B) C) D) Zero
3R 3R 3R
I X
O P
0 I 0 I 0 I
A) 0 I B) C) D)
2 4 8
SECTION – II
(MULTIPLE CORRECT ANSWER TYPE)
This section contains 5 multiple choice questions. Each question has 4 options (A), (B), (C) and (D) for its answer,
out of which MORE than ONE option can be correct.
Marking scheme: +5 for correct answer, 0 if not attempted and -2 in all other cases.
26. Figure shows two identical rods 1 and 2 having same length ( l ), same area of
cross-section (A) and made up of same material. Young’s modulus of material of
rods is ‘Y’. Constant and equal forces each of magnitude ‘F’ is applied at both
ends as shown below:
1 2
F
F
Sec:Sr.IPLCO/IC/ISB/LIIT _Adv_Q.P space for rough work Page 13
Sri Chaitanya IIT Academy 21-04-16__ Sr.IPLCO/IC/ISB/LIIT _JEE-ADV_(New Model-VII_P1)_GTA-5_Q.P
2Fl
A) Net deformation of two rod system is
AY
Fl
B) Net deformation of two rod system is
AY
2F2 l
C) Elastic potential energy stored in two rod system is
3AY
F2 l
D) Elastic potential energy stored in two rod system is
3AY
Kq q
27. Suppose the coloumbs law is defined as F12 13 2 rˆ21 . Then which of the following
r12
B) The electric potential due to a positive charge increases with distance from that
positive charge
A) Mutual inductance between the long wire and the loop is zero.
B) Net magnetic force acting on the loop due to the long wire is zero
C) Net torque due to magnetic force on the loop about Z-axis is zero.
D) Consider an ampere loop in the shape of a circle of radius ‘a’. Plane of the loop
is parallel to XZ-plane with its centre at 0, a / 2, 0 . Let B be the net magnetic field
in space. Then B. d l around the Ampere loop is zero.
A) P1 = P2 B) P1 > P2 C) V1 = V2 D) V1 < V2
30. One mole of a nuclides undergoe decay and turns completely into a stable
substance. Let dN be the number of particles that posses energies between E
dN
and E+dE. The plot of versus E is given below.
dE
dN
dE
E
2.82MeV
31. select correct option(s)
A) The reading of volt meter is
B) The reading of volt meter is zero
C) Current through two inductors is same
D) Both capacitors are uncharged
55cm 25cm
placed close to the mirror in the space between the mirror and lens as shown in
figure. The distance of the nearest surface of the slab from lens is 248 cm. An
object is placed 80 cm to the left of the lens. If the final position of the image
formed after the refraction from lens, refraction from slab, reflection from mirror,
refraction from the slab and lens is at the object O, find the distance x (in cm) of
the mirror from nearer surface of slab.
39. What is the temperature in °C of the steel-copper junction in the steady state of the
system shown in the figure. Length of the steel rod = 25 cm, length of the copper
rod = 50 cm, temperature of the furnace = 300 °C,
40. The ends of a spring are attached to blocks of masses 3 kg and 2 kg. The 3 kg
block rests on a horizontal surface and the 2 kg block which is vertically above
it is in equilibrium producing a compression of 1 cm of the spring initially. The
minimum value of the distance to which the 2 kg mass must be displaced down (in
mm), so that when it is released, the 3 kg block may be lifted off the ground is :
g 10 m / s
2
Cl H H Cl
CH3 CH3
H3PO4
P
O O O O
A) O B) C) D)
O O
O
SECTION – II
(MULTIPLE CORRECT ANSWER TYPE)
This section contains 5 multiple choice questions. Each question has 4 options (A), (B), (C) and (D) for its answer,
out of which MORE than ONE option can be correct.
Marking scheme: +5 for correct answer, 0 if not attempted and -2 in all other cases.
46. Which of the following reaction(s) are incorrect?
A) SnCl2 / HCl
C6 H 5 NC hydrolysis
C6 H 5CHO
B)
C) LiAlH 4
C6 H 5 NO2 C6 H 5 N NC6 H 5
COOAg Br
Br2/CCl 4
D)
C) D) OH
1 2 3 4
MOST BASIC P2O5 SnO B2O3 MgO
Highest MP AlCl3 AlF3 AlBr3 AlI3
Least solubility in NaHCO3 KHCO3 RbHCO3 LiHCO3
water
59. From the following choose the appropriate number as mentioned and report your
answer as a three digit number
1 2 3 4
Aromatic amino Tyrosine Threonine Methionine Aspargine
acid
Most stable SiH4 GeH4 SnH4 PbH4
Smallest KSP NiS CuS ZnS HgS
60.
COOH