Beruflich Dokumente
Kultur Dokumente
In this Volume 4 - Addendum 7, the following items have been modified or added:
Item Page
¶ 7.16.6.h................................................................................................................................................... 1
Table 7.45................................................................................................................................................. 2
Table 7.47................................................................................................................................................. 2
Table 7.48 ................................................................................................................................................ 2
Page 114.7
¶ 7.16.6.h
CURRENT: (Text to be deleted is underlined) CHANGE TO: (Amended text is underlined)
h. Pin Nose Diameter: The outside diameter of the h. Pin Nose Diameter: The outside diameter of the pin
pin nose shall be measured and shall meet the nose shall be measured at two locations 90 degrees
requirements shown in table 7.33 or 7.35, as apart and shall meet the requirements shown in
applicable. This dimension is not used to determine table 7.33 or 7.35, as applicable.
acceptance or rejection, but to test for pin nose swell
and the need to verify connection length.
5 Delta 527 G 3.750 6.065 0.250 6 6.5 6.468 6.248 5.250 5.241 4.713 4.666 5.486 5.423 5.255 5.248
25.60 S 3.750 6.065 0.250 6 6.5 6.468 6.248 5.250 5.241 4.713 4.666 5.486 5.423 5.255 5.248
V-150 3.750 6.135 0.250 6 6.5 6.468 6.248 5.250 5.241 4.713 4.666 5.486 5.423 5.255 5.248