Beruflich Dokumente
Kultur Dokumente
PROPERTIES:
Cold-rolled carbon steel sheet of drawing quality, aluminium killed.
The steel is intended for drawing or severe forming, including welding.
The steel is produced in thickness of 0.35 mm and thicker (commonly produced up to 4 mm) and in
widths of 600 mm and wider, in coils and lengths.
STANDARDS:
General requirements:
When reference to this MAT NO appears on FLS Drawing or FLS Parts List or in FLS Purchase Order the
data from the Primary Standard is used as acceptance criteria.
Specific deviations in requirements made in the FLS Parts List, the FLS Purchase Order or a FLS
Instruction always overrules this data sheet.
Alternatively accepted International Standards listed in this sheet may be used if the suppliers
documentation covers at least the documentation required in the Primary Listed Standard. This means that
supplementary tests in some cases will be necessary.
Primary Standard:
EN 10130:1991+A1 (1998), MATERIAL: DC01, MATERIAL No.: 1.0330
Cold rolled low carbon steel flat products for cold forming - Technical delivery conditions.
CHEMICAL COMPOSITION:
% C max or % Si max or % Mn max or % P max or % S max or % N max or % Al min or
Dim. mm
range range range range range range range
0.12 - 0.6 0.045 0.045 - -
DELIVERY CONDITIONS:
This material shall be delivered aluminium killed.
Revisions:
Rev. No. Rev. Date Change Responsible
0,60 31-01-2002 Text editions AnJo
Prepared & Approved changed
References to Alternative Standards added to supplier version
0,70 12-03-2003 Welding electrode number changed by adding 9000. Welding electrodes are AsK
transferred to Purchase Parts.
0,80 15-01-2004 Standards updated AsK
0,81 31-01-2005 Standards updated AsK
1,0 08-06-2005 Rev. no. changed to 1,0 AsK