Beruflich Dokumente
Kultur Dokumente
CRT5379
FH-X360UB/XNUW5
CD RDS RECEIVER
FH-X360UB /XNUW5
FH-X365UB /XNES
FH-X369UB /XNID
This service manual should be used together with the following manual(s):
Model No. Order No. Mech. Module Remarks
CX-3287 CRT4759 S11.6STD CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
SAFETY INFORMATION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
A Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.
Caution:
1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
2. During repair or tests, do not view laser beam for 10 seconds or longer.
CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
C SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
CAUTION
This product is a class 1 laser product classi-
fied under the Safety of laser products, IEC
60825-1:2007, and contains a class 1M laser
module. To ensure continued safety, do not re-
move any covers or attempt to gain access to
the inside of the product. Refer all servicing to
qualified personnel.
WARNING!
The AEL (accessible emission level )of the laser power output is less than CLASS 1
but the laser component is capable of emitting radiation exceeding the limit for
E
CLASS 1.
A specially instructed person should do servicing operation of the apparatus.
FH-X360UB/XNUW5
2
1 2 3 4
5 6 7 8
A
CAUTION
Danger of explosion if battery is incorrectly replaced.
Replaced only with the same or equivalent type recommended by the manufacturer.
Discord used batteries according to the manufacturer's instructions.
FH-X360UB/XNUW5
5 6 7 8
3
1 2 3 4
CONTENTS
SAFETY INFORMATION..................................................................................................................................... 2
1. SERVICE PRECAUTIONS ............................................................................................................................... 5
A
1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5
1.2 NOTES ON SOLDERING .......................................................................................................................... 5
2. SPECIFICATIONS ............................................................................................................................................ 6
2.1 SPECIFICATIONS ..................................................................................................................................... 8
2.2 DISC/CONTENT FORMAT ........................................................................................................................ 8
3. BASIC ITEMS FOR SERVICE.......................................................................................................................... 9
3.1 CHECK POINTS AFTER SERVICING....................................................................................................... 9
3.2 PCB LOCATIONS ...................................................................................................................................... 9
3.3 JIGS LIST ................................................................................................................................................ 10
3.4 CLEANING............................................................................................................................................... 10
4. BLOCK DIAGRAM.......................................................................................................................................... 12
5. DIAGNOSIS.................................................................................................................................................... 14
B 5.1 OPERATIONAL FLOWCHART ................................................................................................................ 14
5.2 ERROR CODE LIST ................................................................................................................................ 15
5.3 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 17
6. SERVICE MODE ............................................................................................................................................ 18
6.1 DISPLAY TEST MODE 1 ......................................................................................................................... 18
6.2 DISPLAY TEST MODE 2 ......................................................................................................................... 19
6.3 SOFTWARE VERSION UP METHOD ..................................................................................................... 20
6.4 CD TEST MODE ...................................................................................................................................... 21
7. DISASSEMBLY .............................................................................................................................................. 22
8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 27
8.1 CD ADJUSTMENT................................................................................................................................... 27
8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 28
C
8.3 PCL OUTPUT CONFIRMATION.............................................................................................................. 30
9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 32
9.1 PACKING ................................................................................................................................................. 32
9.2 EXTERIOR (1) ......................................................................................................................................... 34
9.3 EXTERIOR (2) ......................................................................................................................................... 36
9.4 CD MECHANISM MODULE..................................................................................................................... 38
10. SCHEMATIC DIAGRAM............................................................................................................................... 40
10.1 TUNER AMP UNIT (GUIDE PAGE) ....................................................................................................... 40
10.2 KEYBOARD UNIT.................................................................................................................................. 46
10.3 CD CORE UNIT (S11.6STD) ................................................................................................................. 48
10.4 WAVEFORMS ........................................................................................................................................ 50
D 11. PCB CONNECTION DIAGRAM.................................................................................................................... 52
11.1 TUNER AMP UNIT................................................................................................................................. 52
11.2 KEYBOARD UNIT .................................................................................................................................. 56
11.3 CD CORE UNIT (S11.6STD).................................................................................................................. 58
12. ELECTRICAL PARTS LIST .......................................................................................................................... 60
FH-X360UB/XNUW5
4
1 2 3 4
5 6 7 8
1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A
1. You should conform to the regulations governing the product (safety, radio and noise, and other
regulations), and should keep the safety during servicing by following the safety instructions
described in this manual.
2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors
during power-on mode may damage the ICs inside the unit.
3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment
(shorting-solder) by referring to "the DISASSEMBLY".
4. After replacing the pickup unit, be sure to check the grating.
5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by
electrostatic induction.
6. Notes about installation and pin number description of Power IC (IC301: PA2032A) B
The Power IC, PA2032A used on tha Tuner Amp Unit is a 25 pin IC.
The same PCB of the Tuner Amp Unit is used for other models that use a 27 pin IC, too.
So, the PCB has lands for a 27 pin IC.
When you replace the Power IC, install the Power IC onto 25 pins (2- 26 pin) located in the center of 27 pins for IC301.
Therefore, when you check the Power IC on the block diagram, the schematic diagram and the PCB connection
diagram, you have to pay attention as follows.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
FH-X360UB/XNUW5
5 6 7 8
5
1 2 3 4
2. SPECIFICATIONS
A FH-X360UB/XNUW5
General WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
Power source ...................14.4 V DC (10.8 V to 15.1 V al- audio)
lowable) (Windows Media Player)
Grounding system ............Negative type WAV signal format ........... Linear PCM & MS ADPCM
Maximum current consumption (Non-compressed)
..................................10.0 A
Backup current.................. 4.0 mA or less
Dimensions (W × H × D): USB
DIN USB standard specification
Chassis ............................ 178 mm × 100 mm × 157 mm ................................... USB 2.0 full speed
Nose ................................ 188 mm × 118 mm × 25 mm Maximum current supply
D ................................... 1 A
B Chassis ............................ 178 mm × 100 mm × 165 mm USB Class ....................... MSC (Mass Storage Class)
Nose ................................ 170 mm × 96 mm × 17 mm File system....................... FAT12, FAT16, FAT32
Weight ............................. 1.2 kg MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
Audio (Windows Media Player)
Maximum power output ... 50 W × 4 WAV signal format ........... Linear PCM & MS ADPCM
70 W × 1/2 Ω (for subwoofer) (Non-compressed)
Continuous power output
................................... 22 W × 4 (50 Hz to 15 000 Hz,
5 % THD, 4 Ω load, both chan- FM tuner
nels driven) Frequency range .............. 87.5 MHz to 108.0 MHz
Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
Preout maximum output level 30 dB)
C Signal-to-noise ratio ......... 72 dB (IEC-A network)
................................... 2.0 V
Loudness contour ............ +10 dB (100 Hz), +6.5 dB
(10 kHz) (volume: –30 dB)
MW tuner
Equalizer (5-Band Graphic Equalizer):
Frequency range .............. 531 kHz to 1 602 kHz
Frequency ........................ 80 Hz/250 Hz/800 Hz/2.5 kHz/
Usable sensitivity ............. 25 µV (S/N: 20 dB)
8 kHz
Signal-to-noise ratio ......... 62 dB (IEC-A network)
Equalization range ........... ±12 dB (2 dB step)
Subwoofer (mono):
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ LW tuner
125 Hz/160 Hz/200 Hz Frequency range .............. 153 kHz to 281 kHz
Slope ...............................–12 dB/oct, –24 dB/oct Usable sensitivity ............. 28 µV (S/N: 20 dB)
Gain ................................ +6 dB to –24 dB Signal-to-noise ratio ......... 62 dB (IEC-A network)
Phase .............................. Normal/Reverse
D
Note
CD player Specifications and the design are subject to
System ............................Compact disc audio system modifications without notice.
Usable discs ....................Compact disc
Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network)
Number of channels ........ 2 (stereo)
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
FH-X360UB/XNUW5
6
1 2 3 4
5 6 7 8
FH-X365UB/XNES A
General WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
Rated power source .........14.4 V DC audio)
(allowable voltage range: (Windows Media Player)
12.0 V to 14.4 V DC) WAV signal format ........... Linear PCM & MS ADPCM
Grounding system ............Negative type (Non-compressed)
Maximum current consumption
..................................10.0 A
Backup current.................. 4.0 mA or less USB
Dimensions (W × H × D): USB standard specification
DIN ................................... USB 2.0 full speed
Chassis ............................ 178 mm × 100 mm × 157 mm Maximum current supply
Nose ................................ 188 mm × 118 mm × 25 mm ................................... 1 A
D USB Class ....................... MSC (Mass Storage Class) B
Chassis ............................ 178 mm × 100 mm × 165 mm File system....................... FAT12, FAT16, FAT32
Nose ................................ 170 mm × 96 mm × 17 mm MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Weight ............................. 1.2 kg WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
Audio WAV signal format ........... Linear PCM & MS ADPCM
Maximum power output ... 50 W × 4 (Non-compressed)
70 W × 1/2 Ω (for subwoofer)
Continuous power output
................................... 22 W × 4 (50 Hz to 15 000 Hz, FM tuner
5 % THD, 4 Ω load, both chan- Frequency range .............. 87.5 MHz to 108.0 MHz
nels driven) Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) 30 dB)
Signal-to-noise ratio ......... 72 dB (IEC-A network) C
Preout maximum output level
................................... 2.0 V
Loudness contour ............ +10 dB (100 Hz), +6.5 dB
MW tuner
(10 kHz) (volume: –30 dB)
Frequency range .............. 531 kHz to 1 602 kHz (9 kHz)
Equalizer (5-Band Graphic Equalizer):
530 kHz to 1 640 kHz (10 kHz)
Frequency ........................ 80 Hz/250 Hz/800 Hz/2.5 kHz/
Usable sensitivity ............. 25 µV (S/N: 20 dB)
8 kHz
Signal-to-noise ratio ......... 62 dB (IEC-A network)
Equalization range ........... ±12 dB (2 dB step)
Subwoofer (mono):
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/ SW tuner
125 Hz/160 Hz/200 Hz Frequency range .............. 2 300 kHz to 7 735 kHz
Slope ...............................–12 dB/oct, –24 dB/oct (2 300 kHz to 2 495 kHz,
Gain ................................ +6 dB to –24 dB 2 940 kHz to 4 215 kHz,
Phase .............................. Normal/Reverse D
4 540 kHz to 5 175 kHz,
5 820 kHz to 6 455 kHz,
7 100 kHz to 7 735 kHz)
CD player
9 500 kHz to 21 975 kHz
System ............................Compact disc audio system
(9 500 kHz to 10 135 kHz,
Usable discs ....................Compact disc
11 580 kHz to 12 215 kHz,
Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network)
13 570 kHz to 13 870 kHz,
Number of channels ........ 2 (stereo)
15 100 kHz to 15 735 kHz,
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
17 500 kHz to 17 985 kHz,
18 015 kHz to 18 135 kHz,
21 340 kHz to 21 975 kHz)
Usable sensitivity ............. 28 µV (S/N: 20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)
E
Note
Specifications and the design are subject to
modifications without notice.
FH-X360UB/XNUW5
5 6 7 8
7
1 2 3 4
2.1 SPECIFICATIONS
FH-X369UB/XNID
General USB
A Rated power source .........14.4 V DC USB standard specification
(allowable voltage range: ................................... USB 2.0 full speed
12.0 V to 14.4 V DC) Maximum current supply
Grounding system ............Negative type ................................... 1 A
Maximum current consumption USB Class ....................... MSC (Mass Storage Class)
..................................10.0 A File system....................... FAT12, FAT16, FAT32
Backup current.................. 4.0 mA or less MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Dimensions (W × H × D): WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
D audio)
Chassis ............................ 178 mm × 100 mm × 165 mm (Windows Media Player)
Nose ................................ 170 mm × 96 mm × 17 mm WAV signal format ........... Linear PCM & MS ADPCM
Weight ............................. 1.2 kg (Non-compressed)
B Audio FM tuner
Maximum power output ... 50 W × 4 Frequency range .............. 87.5 MHz to 108.0 MHz
70 W × 1/2 Ω (for subwoofer) Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
Continuous power output 30 dB)
................................... 22 W × 4 (50 Hz to 15 000 Hz, Signal-to-noise ratio ......... 72 dB (IEC-A network)
5 % THD, 4 Ω load, both chan-
nels driven)
Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) MW tuner
Preout maximum output level Frequency range .............. 531 kHz to 1 602 kHz (9 kHz)
................................... 2.0 V 530 kHz to 1 640 kHz (10 kHz)
Loudness contour ............ +10 dB (100 Hz), +6.5 dB Usable sensitivity ............. 25 µV (S/N: 20 dB)
(10 kHz) (volume: –30 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network)
Equalizer (5-Band Graphic Equalizer):
Frequency ........................ 80 Hz/250 Hz/800 Hz/2.5 kHz/
C
8 kHz
SW tuner
Frequency range .............. 2 300 kHz to 7 735 kHz
Equalization range ........... ±12 dB (2 dB step)
(2 300 kHz to 2 495 kHz,
Subwoofer (mono):
2 940 kHz to 4 215 kHz,
Frequency ........................ 50 Hz/63 Hz/80 Hz/100 Hz/
4 540 kHz to 5 175 kHz,
125 Hz/160 Hz/200 Hz
5 820 kHz to 6 455 kHz,
Slope ...............................–12 dB/oct, –24 dB/oct
7 100 kHz to 7 735 kHz)
Gain ................................ +6 dB to –24 dB
9 500 kHz to 21 975 kHz
Phase .............................. Normal/Reverse
(9 500 kHz to 10 135 kHz,
11 580 kHz to 12 215 kHz,
CD player 13 570 kHz to 13 870 kHz,
System ............................Compact disc audio system 15 100 kHz to 15 735 kHz,
Usable discs ....................Compact disc 17 500 kHz to 17 985 kHz,
Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network) 18 015 kHz to 18 135 kHz,
D
Number of channels ........ 2 (stereo) 21 340 kHz to 21 975 kHz)
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 Usable sensitivity ............. 28 µV (S/N: 20 dB)
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch Signal-to-noise ratio ......... 62 dB (IEC-A network)
audio)
(Windows Media Player)
Note
WAV signal format ........... Linear PCM & MS ADPCM Specifications and the design are subject to
(Non-compressed) modifications without notice.
FH-X360UB/XNUW5
8
1 2 3 4
5 6 7 8
See the table below for the items to be checked regarding audio:
C CD Core Unit(S11.6STD)
B Keyboard Unit
E
A:FH-X360UB/XNUW5
B:FH-X365UB/XNES
C:FH-X369UB/XNID A Tuner Amp Unit
Unit Number : QWM3753(A)
Unit Number : QWM3751(B)
Unit Number : QWM3752(C)
Unit Name : Tuner Amp Unit
Unit Number : (A)
Unit Number : (B,C)
Unit Name : Keyboard Unit F
Unit Number : CWX4023
Unit Name : CD Core Unit (S11.6STD)
FH-X360UB/XNUW5
5 6 7 8
9
1 2 3 4
- Jigs List
A
Name Jig No. Remarks
16P FFC GGD1310 Tuner Amp Unit - CD Core Unit
Test Disc TCD-782 Checking the grating
L.P.F. Checking the grating (Two pieces)
- Grease List
Name Grease No. Remarks
Grease GEM1024 CD Mechanism Module
B
Grease GEM1043 CD Mechanism Module
3.4 CLEANING
D
Before shipping out the product, be sure to clean the
following portions by using the prescribed cleaning
tools:
Portions to be cleaned Cleaning tools
CD pickup lenses Cleaning liquid : GEM1004
Cleaning paper : GED-008
FH-X360UB/XNUW5
10
1 2 3 4
5 6 7 8
FH-X360UB/XNUW5
5 6 7 8
11
1 2 3 4
4. BLOCK DIAGRAM
A
A TUNER AMP UNIT
FM/AM ANTENNA
JA401
1 5
FMMIXIN1
16
2,3 PINDIN
18 57
LNAIN DACOUTL
RESET
FM/AM TUNER IC671
IC401 S-80827CNMC-B8M
TDA7706
39 1 2
RES OUT VDD VDD3.3V
34 93
I2CSCL TUN_SCL
33 94
B I2CSDA
31 88
TUN_SDA
RSTN TUNRES
ILMPW
SYSTEM MICRO
Q873
COMPUTER
IC601 B.UP ILM+B
(1/2)
JA891 R5S726A0D216FP Q874
2 KEYAD 56
REMOTE
KEYAD
WIRED
3 KEYD 105
KEYD 19
1 GND ILMPW
Q875
21 RGBDT/DIMMER
FLASH ROM
IC681
PEB113A8
C REGULATOR IC
IC911
BA49183-V12
11 113
6 VDDCONT SWVDD
SW5V SW5V
A :FH-X360UB/XNUW5 SWVDD
9
SWVDD
BSENS
1
2
90
8
BSENS
B :FH-X365UB/XNES VDD3.3V
7
VDD
SYSPW
SW5VCNT
3
SYSPW
8
C :FH-X369UB/XNID VDD1.2V
5
VDD12
4
SYS+B SYS+B +B B.UP
10 SYSTEM
+BUP COMPU
IC60
(2/2
R5S726A0
USB5V REGULATOR
D
PICKUP UNIT
(P10.6)(SERVICE)
C CD CORE UNIT(S11.6 STD)
8
IC551
BD9876EFJ
B.UP VCC
CN101 RF AMP, CD DECODER
IC552 5 118
VCC 12 12 V+3A
DIGITAL SERVO/DATA • PROCESSOR SYNC SYNC
VDD BD2232G-G
CPU Q601
LD LD- GND Q102 5 1 1 6 98
15 15 1 USB5V VOUT VIN LX EN DDON
Q101 LD
V+3A VDD 4
FB
MD MD 5 PD 2 54 7
5 PD BST
PUEN
REFO
VREF REFO 93 3 119
8 8 REFOUT EN USBCTL
4 120
OC USBFLG
AC,BD,E,F
HOLOGRAM
UNIT IC201
PE5791A
FOM FOM
3 3
ACTUATOR/
FOP FOP MOTOR DRIVER
FOCUS ACT. 2 2
IC301 CN701 CN701
TRACKING ACT. TOP 1 1 TOP
BD8223EFV
VDD VDD
TOM 4 4 TOM TD,FD VDD 9 9 VDD3.3V
E LD+
14 14 LD+ SD,MD
55
8 VDSENS
TKO+
7 MECHA VD
TKO- Q751
10 VD VD
FCO+ VD 2 2 B.UP
9
FCO- 1 1 Q752
SOP 3
SPINDLE SPO+
MOTOR M SOM 2 CNT
23 40
CLCONT
SPO-
22 41 85
LDIN LOEJ VDCONT
LCOP 5
LOADING/CARRIAGE SLLDO+ MUTE 21 39
CONT
MOTOR M LCOM 4
SLLDO-
29 RESET RESET 33
RESET 8 8 CDRST
38
DSCSNS
35
HOME
CD DATA (CDSRQ,CDSTBY,SKIP, CD DATA (CDSRQ,CDSTBY,SKIP,
SCL,SDA,DATA,BCLK,LRCK,WAIT) SCL,SDA,DATA,BCLK,LRCK,WAIT)
S903 S901
DSCSNS HOME
FH-X360UB/XNUW5
12
1 2 3 4
5 6 7 8
ELECTRONIC VOLUME/
SOURCE SELECTOR
IC201
PM9013A
JA251
PREOUT
TUNL 40 35 PL PL
INAN1L OUTPL 2
Q252
P251
V
EVOL_MCK
81 19
MCLK JA901 B
104 20 FUSE 10A
EVOL_LRCK LRCLK B.UP 18
103 21 17
EVOL_BCK BCLK
106 22 33 12(11) 15 B.UP
EVOL_DATA DIN OUTFL FLIn
110 23
M+B EVOL_DT DATA 34 13(12)
108 24 OUTRL RLIn 10(9) FL+
EVOL_CK CLK FL+ 1
111 25 MUTE 8(7) FL-
EVOL_CS STB FL-
Q301 3
87 26
EVOL_RST RESETB (1/2) 6(5) RL+
AUXL 37 RL+ 5
INBP4L POWER AMP
IC301 4(3) RL-
POWER SUPPLY
RL- 7
PAL012A
21 RGBDT/DIMMER
Q301
(2/2)
117 23(22) 26(25) BREM&A.ANT
MUTE MUTE H-SW 14
17 2(1)
ANTPW OFF.DET
TELIN
Q951
C
26 TEL
TELIN 9
A ASENS
Q941
113
SWVDD 89 ACC
ASENS 13
90
BSENS
8
SYSPW
B.UP
SYSTEM MICRO
COMPUTER
B KEYBOARD UNIT
IC601
(2/2) JA1921
FRONT AUX
CN801 CN1931
R5S726A0D216FP AUXR 3
AUXL AUXL AUXL 2
19 19
AUXGND 1
SRC
S1837
35 SOURCE SOURCE 4 2
SSENS 18 18
3 1
MULTI-CONTROL
S1839
D
53 ROT0 ROT0 2 5 KDT2
ROT0 6 6
118
SYNC 54 ROT1 ROT1 1 4 KST1
ROT1 4 4
1
98 3
DDON
21
KDT0
SWVDD 3 3 SWVDD 22
KDT1
119 23
KDT2
USBCTL
22 KYDT KYDT 2 24
120 KYDT 8 8 KYDT KDT3
USBFLG
IC801 3 KEY MATRIX
KST0
TC7SET08FUS1 5
23 DPDT DPDT 4 KST1
2 4
DPDT 10 10 DPDT 7
KST2
LCD DRIVER/ 15
KEY CONTROLLER KST3
34 DSENS DSENS IC1801
DSENS 20 20 PD6583A
LCD
E
55
VDSENS V1801
6
REM
REMOTE CONTROL
SENSOR
1 IC1941
GP1UXC14RK
85
VDCONT ILM+B
ILM+B 5 5
A B C
CN1911
USB5V 11 11
USB5V USB5V
2
F
USB
49 DM DM DM
DM 13 13 3
50 DP DP DP
DP 15 15 4
FH-X360UB/XNUW5
5 6 7 8
13
1 2 3 4
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A
Power ON
Vcc = 1.2 V Vcc : Pin 12, 20, 43, 78, 86, 109
PVcc = 3.3 V PVcc : Pin 3, 16, 28, 36, 48, 69, 82,101, 112
BSENS
B Pin 90
BSENS = L
ASENS
Pin 89
ASENS = L
C DSENS
Pin 34
DSENS = L
Starts
communication
with Grille
microcomputer.
D
300 ms
SWVDD <- H
Pin 113
300 ms
SYSPW <- H
Pin 8
FH-X360UB/XNUW5
14
1 2 3 4
5 6 7 8
ERROR CODES
If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a A
cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from
customers and facilitate failure analysis and repair work in servicing.
10 Servo Carriage Home NG The pickup cannot move toward the inner track.
The CRG cannot move from the inner track.
--> Defective HOME SW; Failure in CRG movement.
11 Servo Focus NG Focusing not available
--> Disc placed upside-down; Stains on the disc; excessive vibration.
12 Servo Spindle Lock NG Spindle not locked. Subcode not readable.
Subcode NG Proper RF AMP gain not obtained.
RF-amp NG --> Defective spindle; Scratches or stains on the disc; excessive vibration.
--> A CD-R/RW disc that does not contain data loaded, or in a rare case, disc placed upside-down.
--> RF signal error.
15 Servo RF NG The digital signal from the disc cannot be detected.
--> A CD-R/RW disc that does not contain data loaded. D
17 Servo Setup NG The laser output cannot be adjusted. Focus can be easily lost.
--> Scratches or stains on the disc; excessive vibration.
30 Servo Search Time Out Failed to reach a target address. And, the search became a timeout.
--> Carriage/Tracking error; Scratches on the disc; Stains on the disc
50 Mechanism Load NG Disc loading/ejection not completed
Eject NG --> A foreign object inserted in the mechanism; Disc jammed.
51 Mechanism Failure in retried Disc could not be ejected even after disc turning had been retried.
turning for ejection --> A foreign object inserted in the mechanism; Disc jammed.
E
NOTES
• Indications of error codes are available only during disc operations, because CD operations are unavailable if a mechanical error is
generated.
• If the TOC cannot be read, It stops because of error 07.
• If you design a new head unit, be sure to use one of the display formats indicated in “Display example of the head unit.”
• The 2 high-order digits of an error code denote the main classification, shown below.
code classification
0x
1x Servo-related errors
3x
5x Mechanism-related errors
FH-X360UB/XNUW5
5 6 7 8
15
1 2 3 4
A Symptoms are written in bold and causes in reg- Wait until the message disappears and you hear
ular, non-indented text. Regular, indented text is sound.
used to indicate actions to be taken.
NO AUDIO
Common
There are no songs.
AMP ERROR Transfer the audio files to the USB storage device
This unit fails to operate or the speaker connection is and connect.
incorrect; the protective circuit is activated. The connected USB storage device has security en-
Check the speaker connection. If the message abled.
fails to disappear even after the engine is Follow the USB storage device instructions to
switched off/on, contact your dealer or an disable the security.
authorized Pioneer Service Station for
B
assistance. SKIPPED
The connected USB storage device contains DRM
CD player protected files.
The protected files are skipped.
ERROR-07, 11, 12, 17, 30
PROTECT
The disc is dirty.
Clean the disc. All the files on the connected USB storage device
are embedded with DRM.
The disc is scratched.
Replace the USB storage device.
Replace the disc.
N/A USB
ERROR-07, 10, 11, 12, 15, 17, 30, A0
C The connected USB device is not supported by this
There is an electrical or mechanical error. unit.
Turn the ignition switch OFF and back ON, or Connect a USB Mass Storage Class compliant
switch to a different source, then back to the CD device.
player. Disconnect your device and replace it with a
compatible USB storage device.
ERROR-15
The inserted disc is blank. CHECK USB
Replace the disc. The USB connector or USB cable has short-
circuited.
ERROR-23
Check that the USB connector or USB cable is
Unsupported CD format. not caught in something or damaged.
D Replace the disc.
CHECK USB
FORMAT READ
The connected USB storage device consumes more
Sometimes there is a delay between the start of play- than maximum allowable current.
back and when you start to hear any sound. Disconnect the USB storage device and do not
Wait until the message disappears and you hear use it. Turn the ignition switch to OFF, then to
sound. ACC or ON and then connect only compliant
USB storage devices.
NO AUDIO
The inserted disc does not contain any playable files. ERROR-19
Replace the disc. Communication failed.
E Perform one of the following operations.
SKIPPED –Turn the ignition switch OFF and back ON.
The inserted disc contains DRM protected files. –Disconnect the USB storage device.
The protected files are skipped. –Change to a different source.
Then, return to the USB source.
PROTECT
All the files on the inserted disc are embedded with ERROR-23
DRM. USB storage device was not formatted with FAT12,
Replace the disc. FAT16 or FAT32.
USB storage device should be formatted with
FAT12, FAT16 or FAT32.
USB storage device
F STOP
FORMAT READ
There are no songs in the current list.
Sometimes there is a delay between the start of play-
Select a list that contains songs.
back and when you start to hear any sound.
FH-X360UB/XNUW5
16
1 2 3 4
5 6 7 8
PRE OUTPUT
1 FL+ 9 MUTE (UW5 Only)
2 FR+ NC (Except UW5)
3 FL- 11 NC
4 FR- 12 NC D
5 RL+ 13 ACC
6 RR+ 14 B.REM
7 RL- 15 B.UP
8 RR- 16 GND
FH-X360UB/XNUW5
5 6 7 8
17
1 2 3 4
6. SERVICE MODE
6.1 DISPLAY TEST MODE 1
A [How to enter Test mode]
Press and hold "EQ" and "LIST" buttons together, and turn BUP and ACC on.
SOURCE LIST
EQ
BAND ROTARY
C
Grille condition
Conf. item Operate Show LCD ILM
All light up EQ + LIST Draw 1 ILM(1)
All light off SOURCE No light Draw2 No light
Conf. LCD pattern 1 ILM(2)
(* And change ILM color) BAND Draw 3
(If not have, ILM(1) light on)
Conf. LCD pattern 2 ROTARY center Draw 4 ILM(1)
D
Drawings Style
Draw1 ALL light up
Draw2 ALL light off
Draw3
Draw4
FH-X360UB/XNUW5
18
1 2 3 4
5 6 7 8
[Operation key]
Operation key Processing Remarks
Enter display test mode
1+3 Switch to next test mode
[Test items]
Start display test mode. Key Illumination Icon
Press and hold "1" and "3" buttons together, and turn * Initial
BUP and ACC on. Off All off condition
S $ $ $ $ # # #
FH-X360UB/XNUW5
5 6 7 8
19
1 2 3 4
A
Overview
This mode is used for upgrading the MCU software of system using USB memory.
Press and hold "1" and "2" buttons together, and turn BUP and ACC on.
START UPDT
Switched every
D 5 seconds (3) Rewriting failed
PRG **/100
Display is continued until In 5 seconds, usual operation In 5 seconds, rewriting In 5 seconds, usual operation In 5 seconds, rewriting
E the power supply is turned (OFF SOURCE) is retried
is retried (OFF SOURCE)
OFF
Result of rewriting
(1) Rewriting succeeded Displayed when USB rewriting is normally terminated.
In 5 seconds, usual operation (OFF SOURCE) is started.
(2) Upgrading file error Displayed when there is no upgrading file in USB memory or the data of upgrading file is different.
Upgrading file is not detected In 5 seconds, usual operation (OFF SOURCE) is started.
If the upgrading file error is detected or the upgrading file is not detected after the rewriting is retried, the rewriting is failed.
In 5 seconds, rewriting is retried.
(3) Rewriting failed Displayed when the writing of upgrading file in serial Flash is not normally terminated.
Or, displayed if the upgrading file error is detected or the upgrading file is not detected after the rewriting is retried.
In 5 seconds, rewriting is retried.
(4) Retry count over Displayed when the retry becomes unavailable because the retry count is exceeded.
F The display is continued until the power supply is turned OFF. If the power supply is turned ON again, the display is not changed.
The upgrading using USB is disabled, so it is necessary to write programs in serial Flash using E10A.
FH-X360UB/XNUW5
20
1 2 3 4
5 6 7 8
- Flow Chart A
[BAND] [2]
Power On RF AMP *1
(T.Offset is adjusted) Gain switching
TRK MIN SEC TRK MIN SEC
00 00 00 GG GG GG
*6 C
[BAND] [2]
Power Off Tracking Open
Operation
*1) TYP t + 6 dB t + 12 dB [Key] Test Mode
TRK MIN SEC TRK
06MIN06SEC06 TRK
12MIN12SEC12 [BAND] Power On/Off
[RIGHT] CRG + / TR Jump +
(Direction of the external surface)
D
*2) Focus Close t S. Curve t F EQ measurement setting [LEFT] CRG - / TR Jump -
TRK
00MIN00SEC00 TRK
01MIN01SEC01 TRK
02MIN02SEC02 (Direction of the internal surface)
(TRK99MIN99SEC99) [1] T. CLS & AGC & Applicable servomechanism /
AGC,AGC display setting
[2] RF Gain switching / Offset adjustment display /
*3) F.Offset Display t RF.Offset t T.Offset Display t Switch to the order T.Balance adjustment / T. Open
of the original
[3] F. Close,S. Curve / Rough Servo and RF AGC /
display
F,T,RF AGC
*4) 100TR Jump [6] F. Mode switching / Tracking Close
After the [EJECT] key is pressed keys other than the [EJECT] key should not be pressed, until disc ejection is complete.
When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks
to Wall, causing the actuator to be damaged).
In the case of 100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released.
When the power is turned on/off the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the
default setting. F
Do not do Tracking Servo Close before doing Focus Servo Close. (Because the overcurrent flows)
FH-X360UB/XNUW5
5 6 7 8
21
1 2 3 4
7. DISASSEMBLY
While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same.
A
B
1 1
1 1 1
Fig.1
1
1 1
1 1
Fig.2
Fig.3
FH-X360UB/XNUW5
22
1 2 3 4
5 6 7 8
CD Mechanism Module
D
CD Mechanism Module
6
5 5
Fig.4
FH-X360UB/XNUW5
5 6 7 8
23
1 2 3 4
CD Mechanism Module
Fig.5
FH-X360UB/XNUW5
24
1 2 3 4
5 6 7 8
Handling OK
Handling NG
FH-X360UB/XNUW5
5 6 7 8
25
1 2 3 4
C
The spring is below a resin
flange and is built inside the
B A sheet metal bending.
Fig 3 Fig 4
FH-X360UB/XNUW5
26
1 2 3 4
5 6 7 8
FH-X360UB/XNUW5
5 6 7 8
27
1 2 3 4
Note :
The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism
module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU
unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the
PU unit must be changed, the grating should be checked using the procedure below.
Purpose :
To check that the grating is within an acceptable range when the PU unit is changed.
B Symptoms of Mal-adjustment :
If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform
track search operations, or taking a long time for track searching.
Method :
Measuring Equipment Oscilloscope, Two L.P.F.
Measuring Points E, F, REFO1
Disc TCD-782
Mode TEST MODE
CD CORE UNIT
F L.P.F.
E Xch Ych
E 100 kohm
Oscilloscope
VREF 390 pF
F 100 kohm
REFO1 390 pF
VREF
D
L.P.F.
Checking Procedure
1. In test mode, load the disc and switch the 3 V regulator on.
2. Using the > and < buttons, move the PU unit to the innermost track.
3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking
balance adjustment the display should now read "81". Press key 3. The display will change,
returning to "81" on the fourth press.
E 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase
difference is within 75 . Refer to the photographs supplied to determine the phase angle.
5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any
improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the
mechanism should be judged to be at fault.
Note
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be
seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the
average angle.
Hint
Reloading the disc changes the clamp position and may decrease the "wobble".
FH-X360UB/XNUW5
28
1 2 3 4
5 6 7 8
0 degrees 30 degrees
45 degrees 60 degrees
75 degrees 90 degrees
FH-X360UB/XNUW5
5 6 7 8
29
1 2 3 4
- PCL Output
In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode
cancelled), shift the TESTIN IC601(Pin 99) terminal to H.
The clock signal is output from the PCL terminal IC601(Pin115).
The frequency of the clock signal is 600 kHz that is divided by 20th of the oscillation frequency of X601 (12MHz).
The clock signal should be 600 kHz(- 25 Hz, + 25 Hz).
If the clock signal is out of the range, the X'tal (X601) should be replaced with new one.
FH-X360UB/XNUW5
30
1 2 3 4
5 6 7 8
FH-X360UB/XNUW5
5 6 7 8
31
1 2 3 4
X360UB/XNUW5
X365UB/XNES
B
X365UB/XNES
X365UB/XNES X369UB/XNID
X369UB/XNID
X365UB/XNES
X369UB/XNID
X360UB/XNUW5
X365UB/XNES
X369UB/XNID
F
FH-X360UB/XNUW5
32
1 2 3 4
5 6 7 8
1 Cord Assy See Contrast table (2) 7 Protector See Contrast table (2)
2 Poly Bag See Contrast table (2) 8 Card Remote Control Unit See Contrast table (2)
A
3 Screw See Contrast table (2) 9 Handle See Contrast table (2)
4 Cover CEG1356 * 10-1 Warranty Card See Contrast table (2)
5 Unit Box See Contrast table (2)
10-2 Owner's Manual See Contrast table (2)
6 Contain Box See Contrast table (2) * 10-3 Service Network See Contrast table (2)
QRB3356 English
FH-X360UB/XNUW5
5 6 7 8
33
1 2 3 4
X360UB/XNUW5
X365UB/XNES
X360UB/XNUW5
X365UB/XNES
FH-X360UB/XNUW5
34
1 2 3 4
5 6 7 8
FH-X360UB/XNUW5
5 6 7 8
35
1 2 3 4
A X365UB/XNES
X369UB/XNID
X365UB/XNES
X369UB/XNID
X365UB/XNES
X369UB/XNID X360UB/XNUW5
B B
FH-X360UB/XNUW5
36
1 2 3 4
5 6 7 8
1 Screw ASZ26P050FTC
2 Screw BSZ26P060FTC 11 Screw BPZ26P080FTC
A
3 Screw BSZ26P080FTC 12 Screw BSZ26P060FTC
4 Screw BSZ26P120FTC 13 Screw BSZ26P120FTC
5 Cord Assy See Contrast table (2) 14 Holder QNC3050
15 Heat Sink See Contrast table (2)
6 Case QNB3013
7 Holder QNC3057 > 16 Fuse(10 A) YEK5001
8 Bracket QNC3058 17 Card Remote Control Unit See Contrast table (2)
9 Bracket QNC3059 18 Cover See Contrast table (2)
10 Tuner Amp Unit See Contrast table (2)
FH-X360UB/XNUW5
5 6 7 8
37
1 2 3 4
A
B
(A)
(B)
B
(A) (B)
(A)
(A)
C B C
(A)
D
(A)
(A)
(A)
(B)
(A)
(B)
(A) C
(A) : GEM1024
F
(A)
(B) : GEM1043
FH-X360UB/XNUW5
38
1 2 3 4
5 6 7 8
21 Bracket CND4553
22 Arm CND6406
23 Bracket CND6127
24 Bracket CND5710
25 Lever CND5398
26 Sheet CNN3678
27 Rack CNV8342
28 Guide CNW2240
29 Roller CNW1172
D
30 .....
31 Arm CNW2241
32 Roller CNW1175
33 .....
34 Arm CNW1177
35 Arm CNW1178
36 Gear CNW1180
37 Gear CNW1181
38 ..... E
39 Gear CNW1183
40 Rack CNW1184
41 Gear CNW1185
42 Gear CNW1186
43 Gear CNW1187
44 Gear CNW2287
45 Clamper CNW1190
46 Arm CNW1192
F
47 Holder CNW1193
48 Holder CNW1194
49 Damper CNW1197
FH-X360UB/XNUW5
5 6 7 8
39
1 2 3 4
A-a A-b
Large size
SCH diagram
A-a
*1 C457 4700p/25 TUNR
*only A *1 CD C CN701
4 /CDSTBY
TUNER C456 4700p/25
/CDSRQ
TUNL
FM: -10.6 dBs - SW Model
8 RESET
11 DATA
GND
1u/6.3
CN701
6 SKIP
C464
FM/AM ANTENNA
9 VDD
7 SDA
AM: -10.3 dBs
5 SCL
VD
VD
AGND A B, C VKN1192-
JA401
C449
10
*only B, C
1
2
3
C450
9p/50
X401 C419 NM 15p/50
*1 *1
CTF1786-
MECHA VD
C453 DCH1246
YKS5041- 36.48MHz AGND
L420
L419
TUNGND 8p/50
1 C423 NM
2 X2 FM: -14.7 dBs
C445 0.1u/10
HSPC16701B02
4 GND2 3
NM
AM: -14.5 dBs C428 100p/50 22p/50
CDSRQ
RESET
DGND1
C446 NM
3 DGND 7.4V
KN2
DATA
CDSTBY
VDD4
SDA
SCL
P402
A-a
P401
A-b
SKIP
NM
Guide page
0.1u/10
1 2 C432 82p/50 2p/50 VD2 Q751
M2R6TP_GND R416 NM
C447
GND1
C709
X1
NM
KTD2092
C452
1u/10
VD1
CSS1848- C435 0.47u/10 1u/10
C455
0.22u/16 R701
C439
CCG1201-A-T 10u/10
L418 NM NM 0.1u/16
47k
R753
47k
L417
C751 NM
R417
C454 NM C441 NM 10p/50 R702
0.1u/10
NM
C753
RFGND
C451
L416
NM C459 100p/50 1000p/50 100k
R752
NM
390
1/4
*1 R415
L414
0 C448 0.1u/10 0.01u/16 VDCONT Q752
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
L415
PLLTEST
CTF1786 C467 NM 0.1u/10
Detailed page
TVDAC
A-a A-b
TCFM
OSCOUT
DACOUTR
R401
R402
NM
DACOUTL
VREFDEC
1 48 C467 3 4
OSCIN
220
750
GND-REF
GND-ADC_DAC
VCC-REF
VCC-ADC_DAC
GND-PLL
0.1u/10
VDDPLL1V2
VDDIO1V2
VCC-PLL
L406 CTF1389 NM
0.1u/10
R754
C444 2 5 GND
10k
2 47 2.2u
L407 NM 0.27uH
RN731VN
DZ2J082M0
CCG1218- 1 6
RN731VN
3 46
D402
D401
D751
B
0.1u/10 4 45 NM
150
L401 L409
C752
C410
FMMIXIN2 NM 0.39uH 6 3
0.27u 5 TEST 44
FMMIXIN1 FMPINDRV VDD_CORE L410 47uH 2.2uH 7 2
33p/50 C402 6 FMPINDDEC GND1V2 43
0.01u/16
0.01u/16
GNDRF
0.01u/16
L414 CTF1786 NM
R715
0.01u/16
GPIO0 8 1
6p/50
C409
C408
C407
C406
C405
C403
NM
7 42
L402
0.15u
TCAM GPIO1
R403 390 330 R703
220
220
100
220
100
1u/10 8 GPIO2 41 GND 4.7k
1k
AGND VCCRF IC401 GPIO3 R408 470 360
orRFGND C404 NM 9 GPIO4 40
CK_SEL TDA7706 NM
R409
R711
10 GPIO5 39 0 R704 100k
RF GND GNDVCO GPIO6
L403 11 38 R411 680 390
R706
R707
R708
R709
R710
C412 LFREF GPIO7 C702
CTF1786- 0.1u/10 C411 12 37 R415 NM 0 R705
C413
0.1u/10
LF1 GPIO8 NM
C445 0.1u/10 NM
L701
0.01u/16 13 36
NM
PINDDEC C701 NM
A GND VCCVCO GND3V3
C414 0.01u/16 PINDIN C442 C464 NM DCH1246
VREG3V3
14 35
VCCREG1V2
*1 0.01u/16 C703
RDSINT
TCAM2 VDD3V3
GNDSLINK
AMMIXIN1
AMMIXIN2
RFGND
LNAOUT2
LNADEC2
RSTN
C415 34
GNDLNA
CCG1192- TUN_SCL
LNADEC
LNAOUT
REG1V2
I2CSCL
LNAIN2
R724 NM
DGND
LNAIN
0.1u/10
VDIG
16 TUN_SDA
C417
C461
C416
NM
NM
RFGND
C468 NM 1u/10
L413
CTF1786-
C418
0.022u/16 GND
C461 0.1u/10
17
18
19
20
21
22
23
NM 24
25
26
27
28
29
30
31
32
GND NM
C419 15p/50 R403 C424
C420
0
NM
0.1u/10
RFGND
0.1u/10
C427
TUN_RST
*1
C426
C436 NM
CTF1389 C425
C460
*2
R404
4.7u
1000p/50
0.1u/16
1M
1u/10
C438
L405
NM
10u
C468
R410
C440
C439
L407
NM 3.3V
8p/50
C423
R407
0.27u C430
1M
33
CDDATAIN
C422
NM
VDCONT
1000p/50
VDSENS
CDSTBY
CD_SDA
CD_SCL
CDSKIP
CDSRQ
CDRST
RFGND
*1 *1 *1
100p/50
0.39u
L409
C431 NM DGND
R406
C428
R408
470
3p/50
C421
R412 R413
1/4W
8.2 8.2 1/4W
C441
10p/50
DGND
NM
VDCONT
MCLK
R405
BSENS
ASENS
*1 FLASH ROM
RESETB
CDWAIT
C463
TUN_RST
L411 NM
82p/50
R411
0.47u/10
C432
NM
680
C435
C429 L410
NM
C434
R414 0
R681
IC681
R684
RF GND
47k
0.01u/16
47k
0.01u/16 47u
C465
C466 1u/10 *1C462 C433
C459
100p/50 1 8
RF GND RF GND
C458
*1 1000p/50 *1 *1 2
CS VCC
NC/SIO3 7
NM RFGND DGND NM
NM
RFGND DGND SO/SIO1
AGND RF GND DGND GND DGND AGND 3 SCLK 6
WP/SIO2
R682
47k
4 5
GND SI/SIO0
C682
KN1 PEB113A8
NM M2R6TP_GND
CN971
NM BT Connector
22p/50
C625
0.1u/10
VCC 16
R638
C622
47k
NM
C971
VCC 15
GND 14 C973
47p/50
GND 13 R974 100
C623 0.1u/10
BTDATA R636
BTDATA 12
47k
C621 0.1u/10
R975
R632
100 BT_BCK
220
220
220
100
220
220
220
47k
BTBCK 11
C620
R635 1k
R634 1k
0.1u/10
47k
R976 100 BT_LRCK R637
C624
0.1u/10
BTLRCK 10
L971
R633
R631
R630
R629
R628
R627
R626
R625
GND 9 47k
NM
BT_RST
NRST_CPU 8
BTTX
SYSTOBT 7
R971 NM BTRX
90
89
88
87
86
85
84
83
82
81
80
MD_CLK 79
78
77
76
75
74
73
72
71
70
69
68
R640
R639
BTTOSYS 6
4.7k
4.7k
VDCONT
TUNRES
QSPCLK
MD_BOOT
C972
QSSL
QIO1
Vss
NM
EVOL_MCK
R972 91
QIO3
QIO2
QIO0
5 NM
Vss
Vcc
PVcc
/ASENS
GND CP_SCL
AUDIO X1
Vcc
Vss
PVcc
/BSENS
EVOL_RST
/CDWAIT
MIC1P 4 CP_SDA 92
R641
GND 3 TUN_SCL 93
R973 NM GND
R642
MIC1N 2 TUN_SDA NM 94
2.2k TUN_SDA CP_SCL
C974
GND 1 CD_SCL NM 95 CD_SCL CP_SDA IC601
MIC1P
MIC1N
DDON
R668
R
47k
47k
(RMIC)
NM MIC1P
R643 99 TESTIN A 4
6 DDON
100k 100
5 MIC1N Q601 Vss B 2
4 C626
3 LTC014YEB 101 PVcc C 1
2 0.1u/10
1
VA892 NM
1000p/50
1k R644 100
C894
KEYD 103
NM
C893
EVOL_BCK
W.REM 3 BCLK
NM
R893
JA891
C892
0.1u/16
only A 105
0.1u/16
KEYD
D CKS6437-
R646
GND D602
10k
106 EVOL_DATA
RB551VM-30
KEYD 107
DIN R647 Vss
100
GND CLK 108 EVOL_CK
Q531 R648
22p/50
1k C629
C631
R540
47k
C531
R532
2.2k
2.2k
47k PCL
CPRST RAM_MON 116
RAM_MON
R534 2.7k
SYNC
RGBDT/DIMMER
IC531
RGBCS/ILMCLR2
MUTE 117
B.UP
4.7u
NM CMS03 RGBCK/ILMCLR1
L551 USB&USB5V C553 D551 R652 SYNC 118 /USBFLG
1 8 CTH1524- 0.01u/16 SYNC
BT_TESTIN
BT_LRCK
2.2k 119
CCG1222-
220u/16
4 BT_BCK
SYSPW
2 7
C552
C551
ANTPW
BTRST
ILMPW
9
C565
1u/16
NM
C570
RB056L-40
DPDT
BTRX
KYDT
120
BTTX
PVcc
SDA RST
4.7u
FLG
ROM
3 PVcc
IC551
220u/6.3
Vss
3 6
Vss
Vcc
Vss
NM
Vcc
D552
R552
BD9876EFJ
1u/10
C564 CCG1201-
470
R661
NC1 SCL
0
47k
4 5
0.1u/10
R653
C532
NM
6800p/25
1 8
1
2
6
7
8
9
C555
10
11
12
13
14
15
16
17
18
19
20
21
22
23
NC2 NC3 Lx VCC
C558
LX VCC
TP1
2 7 10k
C633
R555
GND 9 BST
only A, C
C557
GND
NM
C556
C554
GND BST
180k D
ROM
3 6 DDON BTTESTIN
R553
GND VC EN
R551
0.1u/10
VC FIN EN
C603 0.1u/10
R664 10k
6.8k
4 5
NM
SYNC
R601
0.1u/10
FB SYNC
C604
0.1u/10
47k
C601
R602
FB SYNC
47k
NM
C563
only B
R603
iPod CP@(2.0C)
43k D
C602
R554
GND
GND GND
IC552
RGBDT
D GND
BD2232G-G
R662
GND 1 5
only B
47k
VIN VOUT
2
GND FLG
R663
3 4 FLG
C569 NM
only A, C
47k
EN OC
C562
C561
NM
1u/10
E
C560
C559
1u/10
NM
USBCLT
RGBST/ILMCLR2
RGBCK/ILMCLR1
RGBDT/DIMMER
USBCTL
DGND
SYSPW
BTDATA
BT_LRCK
GND
BT_BCK
BT_RST
OFFSET
ILMPW
DPDT
BTRX
KYDT
BTTX
VBUS
DSENS
RGBDT/DIMMER
R802
NM
C801
CN801
CKS6452- NM J
DSENS 20
R801 2.2k R805 100
19
NOTE : AUXL GND R803 22k
SOURCE 18 R806 100
Symbol indicates a resistor. AUXR 17 R804 22k R807 100
USB5V
12
11
US5V
10
CN1931 DPDT
USBGND 9
R818
8
The > mark found on some component parts indicates A FH-X360UB/XNUW5
KYDT
RGBDT 7
the importance of the safety factor of the part. 6
B FH-X365UB/XNES ROT0
Therefore, when replacing, be sure to use parts of ILM+B 5
F SWVDD 3
D804 DZ2S068C
D803 DZ2S068C
D805 DZ2S068C
D806 DZ2S068C
D807 DZ2S068C
ILMGND 2 DGND
NM
NM
D801
NM
NM
ILMG
0.1u/16
C807 1u/10
NM
C803
NM
1
NM : No Mount DGND NM
C805 NM
C806 NM
C802
D802 NM
D808 NM
D809 NM
VA801 NM
VA802 NM
USGND C804
C814
C813
D810
D811
NM
C808
A GRILLE
DGND USBGND ILM GND
FH-X360UB/XNUW5
40
1 2 3 4
5 6 7 8
A-b
C CN701 C707 ROL
4 /CDSTBY
RL
*only A *only B, C
/CDSRQ
NM
8 RESET
15 PGND
11 DATA
13 LRCK
FL
12 BCLK
16 WAIT
GND
01
6 SKIP
14 GND
A
9 VDD
7 SDA
5 SCL
VD
VD
C708
FM: -1.7 dBs FM: -5.7 dBs TUNER AMP UNIT
10u
92-
NM
AM: -1.4 dBs AM: -5.5 dBs
10
C236
1
2
3
AUX:+9.3 dBs
C212 CCG1192-
R720
A GND 1u/10 AUX:+9.1 dBs
0.1u/10
0.1u/10
0.1u/10
NM CD:+9.3 dBs CD:+9.6 dBs
CDSRQ
DGND C221
NM
USB:+9.7 dBs
RESET
USB:+9.3 dBs
DGND1
PGND
DATA
CDSTBY
VDD4
SDA
BCLK
C231
SCL
LRCK
C204 1u/10
WAIT
SKIP
NM
C213
C214
C215
PGND DGND C206 1u/10
AGND DGND REFERENCE AREA MAP *only A *only B, C
R718
R701 C710
220
29 C211
PGND GND
R702 RCA 251 - 300 GRILL 801 - 850
NM
NM AM: -1.4 dBs AM: -6.4 dBs
100k R719 AMP 301 - 400 SWVDD5 851 - 870
AUX:+9.1 dBs AUX:+9.3 dBs
40
39
38
37
36
35
34
33
32
31
30
28
27
26
25
24
23
22
21
100k TUNER 401 - 470 ILMPW 871 - 890 CD:+9.3 dBs CD:+10.4 dBs
OUTRL
DVDD2
INAN1L
INBN3L
IN5L
DATA
OUTPL
STB
CLK
INAP2L
INBP4L
AGNDL1
AGNDL2
RESETB
BCLK
OUTFL
VREFL
C223
AVDDL1
AVDDL2
DIN
iPod CP 531 - 550 W.REM&MIC 891 - 900 USB:+9.3 dBs USB:+10.6 dBs
PM9013A
12 AGNDR1
13 AGNDR2
9 AVDDR1
10 AVDDR2
1000p/50
IC201
3 INBN3R
2 INAP2R
4 INBP4R
7 OUTRR
OUTPR
8 OUTFR
11 VREFR
17 DVDD1
20 LRCLK
14 DGND
NM 18 DOUT
C235 19 MCLK
GND
TEST
5 IN5R
B
6
15
FLASH ROM 681 - 690 TELIN 951 - 960
10u
150
L201
150
150
3
2 NM DSENS 691 - 700 B.REM& 961 - 970 RL FL
L202
C224 0.1u/10
NM
C218 47u/16
A.ANT
CCG1192-
C704 CD MECHA 701 - 750
R715
1
R716
R717
R703
220
220
100
220
100
C225
0.1u/10
C220
CCG1192-
4.7k C705
C217
1k
C216
10u
Set back chart
NM
C219
R711
10u
R704 100k C706 CCG1201- 820
ucomD RFGND
DGND
1u/10
4.7u
>
1u/10
GND MUTE
R706
R707
R708
R709
R710
NM
10p/50
1u/10
C702
100p/50
R258
C258
C209 10u
22k
NM
1000p/50
R705 3.0A
C232
C229
C228
CCG1192-
C226
NM
C207 0.1u/10
C208 0.1u/10
NM
NM
L701
1
2
3
P251
NM
NM
RN1910
CEK1386- RCAG
C201
Q252
C234
C203
C205
C703 1 2
R259 PL
6
5
4
NM R721 NM C227 NM
R724
100p/50
R257
C257
JA251
22k
R722 NM NM AGND
NM AGND
USBGND USB GND FR C255 PR
R723 NM CCG1201- 4.7u R255 GND CKB1099-
PRch
ROR RR 3
820
PR 2
GND FLch C252 R252 FL 1
CCG1201- 820
FR
6
5
PREOUT
4.7u
4
100p/50
R254
C254
22k
CDDATAIN
CDLRCKIN
1
2
3
CDSCKIN
RN1910
CDSTBY
CD_SDA
RESETB
CD_SCL
CDWAIT
Q251
CDSKIP
CDSRQ
CDRST
LRCLK
AUXG
TUNR
AUXR
MCLK
DATA
AUXL
TUNL
BCLK
CLK
STB
DIN
C260
C259
C261
0.1u/10
0.01u/10
NM
6
5
4
100p/50
R253
C253
22k
FRch C251 R251 GND
FLASH ROM L681
NM CCG1201- 820 GND
4.7u
R681
IC681
R684
47k
NM
47k
R685
47k
1 8
The pin number of left side is a number on the PCB (silk printing).
0.1u/10
3
SO/SIO1
SCLK 6
16.9344MHz GND1
X603
NM 1
The pin number of right side (in the IC frame) means the pin number of IC itself.
WP/SIO2 1 3 X1 No connection
C683 3p/50
R682
R313 R312
47k
4 5 2 1 2
C681
GND SI/SIO0
C
OFF.DET 1
C682
NM
R683
PEB113A8 2 P-GND2 2
12p/50 3X2 4 12p/50 AMP 4
CSS1794- RL- 3
SYS+B 5.78 V R309
16.9344MHz STBY 5
R624 STBY 4
10k 6
C328
22p/50
NM
1608
DGND 2.2k RL+ 5
7
R301
R311
470
R303
C329
VCC 6
NM
47k
470
L601 VDD3.3V
8
FL- 7
NM GNDTP1 9
R304
C617
NM
NM
R302
8
7
6
5
10
470
C319
AGND GND GND FL+
NM
10u/16 9
47k
C621 0.1u/10
R623
NM
ASEBRK 47k
C318
R622
11 SVR
220
220
220
220
220
220
47k
47k
C620
0.1u/10
10
GND C301 0.22u/16 NM 12
TMS 2
TDI 3
TDO 4
TCK 1
FLIn 11
R631
R630
R629
R628
R627
R626
R625
TRST
C305 0.22u/16 13
VDD1.2V RLIn 12
L602
14
C320
NM
NM AGND 13
R620 C307 0.22u/16 GND 15
RRIn 14
C614
C615
NM
NM
MD_CLK 79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
ASEBRK 62
TRST 61
NM 16
*2 only A AC_GND
FRIn 15
TDO
TCK
17
QSPCLK
MD_BOOT
QSSL
QIO1
Vss
TDI
C309 NM
NM
NM
NM
QIO3
QIO2
QIO0
Vcc
PVcc
60
AUDIO_X1
C331 NM
C332 NM
C333 NM
C334 NM
AC-GND
Vss
16
AUDIO_X2
R619
C612 1u/16 18
47k
RB751SM-40
59 FR+ 17
C310
C311
C312
C321
0.1u/10 R618 GND GND 19
NM
58
D601
MODEL 47k 20
AVref MODELAD 57 FR- 19
GND C901 21
AVcc B.UP
IC601 KEYAD 56 AGND KEYAD VCC 20
AVss MU1 22
R5S726A0D216FP VDSENS 55 VDSENS CCH2040- RR+ 21
R305 R306 GND 2200u/16
*2 ROT1 54 R616 47k
ROT1
10k GNDTP2
23
MUTE 22
220 24 RR-
R618 R619 ROT0 53 R615 47k ROT0 23
25 P-GND4
CDSKIP 52 CDSKIP
C335 NM
A 47k 22k 24
1u/10
Q301
R307
C327
ASEMDR614 26
22k
C323
C324
C325
C326
47k MUTE 27
C 10k 47k DP 50 DP 2 5 No connection
DM 49 DM 1 6 R308
NM
NM
NM
NM
SW5V
PVcc 48 RN4983
R659
R660
SYS+B
B.UP
NM
15k
15k
3.3V
1.2V
0.1u/10
C611
Vss 47
Vss 46 MUTE Q302
D
GND GND
PVcc
NM
XTAL 45 R613 C608 OFFSET
GND
R612 1.5k
EXTAL 44 12p/50
NM C610
GND JA901
Vcc 43
X2 3
NC1 2
CKM1613-
0.1u/10
NMI 42 47k
IC REGULATOR 18 >
CSS1847-
IC911
12MHz
YEK5001
16 GND
1 X1
POWER SUPPLY
22k
4
47k
5 SYS+B
R609
47k
PVcc 36
SW5V 12
0.1u/10 USB GND 6 SW5V
SSENS 35 SSENS
11
RGBDT/DIMMER
CDDADATIN TELIN 10
33 NM CDRST 1.2V 8 VDD12
CDLRCKIN
R607 NM 9 TEL
SWVDD 9 SWVDD
CDSCKIN
32 CDDATAIN RR2
CDSTBY
CPPWR
ANTPW
ILMPW
CPRST
KYDT
10 +BUP
BTTX
PVcc
RL2
PVcc
31 CDLRCKIN
Vss
Vss
Vcc
7
Vcc
C673
2p/50
1 5 5
OUT NC2 FR2 RL+
C929
NM
2 D911
C925
NM
4 FR-
SWVDD
VDD CRG03
SYS+B
FL2
C605 0.1u/10
D671
0.1u/10
3 4
R670
C603 0.1u/10
R664 10k
NM
3 FL-
TELIN1
C913 1000p/50
NM
FR1
R911
C604
C911
0.1u/10
NM
1
NM 2 FR+
R671 FL1
C928
CCG1201-A
1000u/16
R603
S-80827CNMC-B8M CRG03
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
1 FL+
47k
C602
R604
100k
C914
1000p/50
1000p/50
1000p/50
0.1u/16
C915
C912
C927
C926
C924
C923
C922
C921
C920
C919
C918
C916
NM
NM
C917
RFGND
NM
NM
1u/10
NM
C671
C930
NM
C672
4.7u
RESET
RGBDT
only A
NM
RFGND GND *only A
4.7u
4.7u
4.7u
4.7u
DGND
FM:+24.4 dBs
NM
GND
ASENS
AM:+24.6 dBs
AUX:+35.1 dBs
NM
R605
*3 CD:+35.3 dBs
E
LSCR523UB
ASENS2 ASENS1
R941 D941 R944 USB:+35.3 dBs
Q941
RGB Supply
RGBST/ILMCLR2
RGBCK/ILMCLR1
RGBDT/DIMMER
Q871 22k 1k
DZ2J068M0
2SA1577(QR)
R943
6.8k
R942
C941
47k
*only B, C
0.1u/16
CDSCKIN
CDSTBY
OFFSET
ILMPW
CPPWR
R872
CPRST
DPDT
BTRX
KYDT
BTTX
10k
TELIN
FM:+20.3 dBs
GND ASENS AM:+20.5 dBs
R871
AUX:+35.3 dBs
3.3k
(1/10W)
CD:+35.6 dBs
R952 only A USB:+35.7 dBs
22k TELIN
Q872
Q951
LTC143EUB LSAR523UB
R808 D951
SSENS
R953 L951
2.2k GND
R805 100 AUXL R951 15k BTH1101-
R803 22k R877 Q873 LED Supply TELIN
2SD1767(QR) DAN202UM
R806 100 1k GND
AUXR
R807 NM
22k 100
R879
R804 AUXG
R873
NM
1.2k
NM
L801 R809 Q874
11 2 2 DP
0.1u/16
3 4 C968
D871
DZ2J075M0
22 CCG1192-A
47k
C969 R310
0.1u/16
2 5 10u
C872
NM
NM
NM
R874
RN4983
390
R878
R812 NM RGBCK/ILMCLR1 NM
R876
D872
D301
C322
0.1u/16
NM
B.REM&A.ANT
C330
C961
NM
D807 DZ2S068C
1 5
NM
NM
NM
0.1u/16
C852
DPDT
NM
INB Vcc
NM
C810 NM
R851
2
4.7k
C851
NM
D808 NM
D809 NM
VA801 NM
INA
VA802 NM
3 4
C809
GND OUTY
D810
D811
0.1u/10
C808
C811
TC7SET08FUS1
GND
A
GND SWVDD
GND
FH-X360UB/XNUW5
5 6 7 8
41
F
E
B
A
D
C
42
A-a A-b
A-b
N701 C707 ROL RL
NM *only A *only B, C
FL
C708
GND
VDD
FM: -1.7 dBs FM: -5.7 dBs
10u
1
1
9
C236
10
11 DATA
12 BCLK
13 LRCK
14 GND
15 PGND
16 WAIT
AM: -1.4 dBs AM: -5.5 dBs A
R720
A GND 1u/10 AUX:+9.1 dBs AUX:+9.3 dBs
NM CD:+9.3 dBs CD:+9.6 dBs
DGND C221
0.1u/10
0.1u/10
0.1u/10
USB:+9.3 dBs USB:+9.7 dBs
NM
C204 1u/10
NM
DATA
PGND
C231
BCLK
PGND DGND
DGND1
LRCK
WAIT
C206 1u/10
C212 CCG1192-
C213
C214
C215
AGND DGND REFERENCE AREA MAP *only A *only B, C
C710
220
EVOL 201 - 250 MECHA VD 751 - 800
R718
NM C202 1u/10 C233
PGND GND RCA 251 - 300 GRILL 801 - 850 FM: -1.7 dBs FM: -6.6 dBs
NM
NM
AM: -1.4 dBs AM: -6.4 dBs
R719 AMP 301 - 400 SWVDD5 851 - 870
AUX:+9.1 dBs
40
39
38
37
36
35
34
33
32
31
30
29 C211
28
27
26
25
24
23
22
21
AUX:+9.3 dBs
100k TUNER 401 - 470 ILMPW 871 - 890 CD:+9.3 dBs CD:+10.4 dBs
C223
iPod CP 531 - 550 W.REM&MIC 891 - 900
STB
CLK
DIN
IN5L
USB:+9.3 dBs USB:+10.6 dBs
DATA
BCLK
1000p/50
OUTPL
OUTRL
OUTFL
VREFL
DVDD2
INAN1L
INAP2L
INBN3L
INBP4L
USB&USB5V 551 - 600 PW CONNECT 901 - 910
AGNDL1
AGNDL2
AVDDL1
AVDDL2
RESETB
GND
IC201
AGND DGND UCOM 601 - 670 IC REG 911 - 940
PM9013A
INAN1R
INAP2R
INBN3R
INBP4R
IN5R
OUTPR
OUTRR
OUTFR
AVDDR1
AVDDR2
VREFR
AGNDR1
AGNDR2
DGND
TEST
REG
DVDD1
DOUT
MCLK
LRCLK
RESET 671 - 680 ASENS 941 - 950
RCA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
17
18
19
20
L201 FLASH ROM 681 - 690 TELIN 951 - 960
10u
150
150
150
NM DSENS 691 - 700 B.REM& 961 - 970 RL FL
NM
C235
A.ANT
NM
C704 CD MECHA 701 - 750
L202
BT MOD 971 - 990 RR FR
R715
10p/50
R716
R717
C705
CCG1192-
C210
C225
C224 0.1u/10
10u
C218 47u/16
C220
C256 R256 Set back chart
C217
PLch
C216
10p/50
0.1u/10
NM
CCG1192- CTF1793- 16
2
2
C706 CCG1201-
10u
820
C219
CCG1192-
ucomD RFGND
DGND GND 4.7u MUTE
C702 10p/50
NM
1u/10
1u/10
>
10u
NM
22k
1u/10
3.0A
R258
C258
NM
1
2
3
P251
NM
NM
100p/50
C232
C229
C228
C226
CEK1386- RCAG
NM
L701
1000p/50
C209
C201
C703 Q252 2
C234
C203
1
CCG1192-
C205
RN1910
6
5
4
R721 NM R259 PL
NM C227 NM
C207 0.1u/10
C208 0.1u/10
R722 NM NM AGND
22k
JA251
R257
C257
R254
C254
100p/50
FH-X360UB/XNUW5
Q251
RN1910
6
5
4
CDDATAIN
CDSCKIN
CDLRCKIN
AUXL
AUXG
TUNL
CDWAIT
TUNR
AUXR
MCLK
LRCLK
BCLK
DIN
DATA
CLK
STB
RESETB
NM
C260
C259
C261
22k
0.1u/10
R253
C253
0.01u/10
M L681
NM CCG1201- 820 GND
4.7u
NM
47k
3
3
R685
C X602 IC301
3 7 CSS1603- PAL012A
X603
0.1u/10
K 6
16.9344MHz GND1 NM 1
1 3 X1 No connection
5 2 1 R313 R312 2
0 OFF.DET 1
C619 NM NM
C681
GND2 C618 3
2 P-GND2 2
47k
R683
3X2 4 12p/50 4
C683 3p/50
12p/50 AMP
CSS1794- RL- 3
SYS+B 5.78 V R309
16.9344MHz STBY 5
R624 STBY 4
10k 6
2.2k RL+ 5
NM
DGND
C328
1608
7
VDD3.3V VCC 6
470
NM
L601
47k
R301
470
8
R311
R303
C329
FL- 7
NM GNDTP1 9
R621 C317 P-GND1 8
8
7
6
5
470
NM
NM
GND 10
R304
C616
C617
470
R302
NM
NM
C319
C318 11 SVR
10
R623
47k
R622
C301 0.22u/16 NM 12
C620
GND FLIn 11
0.1u/10
C305 0.22u/16 13
TDI 3
TCK 1
TMS 2
TDO 4
VDD1.2V RLIn 12
L602
TRST
ASEBRK 47k
14
AGND 13
NM
NM GND
C307 0.22u/16
C320
R620 15
RRIn 14
C303 0.22u/16 AGND
NM
NM
69
68
67
66
65
64
63
NM 16
C614
C615
FRIn 15
C613 0.1u/10
*2 only A C313 AC_GND 17
60 AC-GND 16
NM
NM
NM
TCK
TDI
TDO
TMS
TRST 61
C612
PVcc
1u/16 18
4
59 17
4
FR+
47k
R619
ASEBRK 62
QSPCLK
0.1u/10 R618 GND GND 19
58
C309 NM
AUDIO_X1
NM
AUDIO_X2
C321
The pin number of left side is a number on the PCB (silk printing).
MODEL 47k 20
D601
10k
MODELAD 57 FR- 19
R617
AVref C901
RB751SM-40
AVcc AGND KEYAD GND B.UP 21
KEYAD 56 VCC 20
AVss MU1 22
VDSENS 55 VDSENS CCH2040- RR+ 21
R305 R306 GND 2200u/16 23
ROT1 54 R616 47k MUTE 22
ROT1 GNDTP2
10k 220
ROT0 53 R615 47k ROT0 24 RR-
23
R618 R619
CDSKIP 25 P-GND4
A 47k 22k CDSKIP 52 24
ASEMDR614 Q301 26
ASEMD 51 3 4 H-SW 25
The pin number of right side (in the IC frame) means the pin number of IC itself.
22k
B 22k 47k
1u/10
GND
R307
C327
47k DP MUTE 2 5 27
C 10k 47k DP 50 No connection
C335 NM
C323
C324
C325
C326
DM 49 DM 1 6 R308
NM
NM
NM
NM
PVcc 48 RN4983 NM
15k
15k
R659
R660
SW5V
B.UP
47
3.3V
1.2V
Vss
SYS+B
C611
0.1u/10
Vss 46 GND MUTE GND Q302
KEYAD VCC 20
AVss MU1 22
VDSENS 55 VDSENS CCH2040- RR+ 21
R305 R306 GND 2200u/16 23
ROT1 54 R616 47k MUTE 22
ROT1 GNDTP2
10k 220 24
ROT0 53 R615 47k ROT0 RR- 23
R618 R619
CDSKIP 25 P-GND4
A 47k 22k CDSKIP 52 24
ASEMDR614 Q301 26
ASEMD 51 3 4 H-SW 25
mber of IC itself.
22k
B 22k 47k
1u/10
GND
R307
C327
47k DP MUTE 2 5 27
C 10k 47k DP 50 No connection
C335 NM
C323
C324
C325
C326
DM 49 DM 1 6 R308
NM
NM
NM
NM
PVcc 48 RN4983 NM
15k
15k
R659
R660
SW5V
B.UP
47
3.3V
1.2V
Vss
SYS+B
C611
0.1u/10
Vss 46 GND MUTE GND Q302
NM
XTAL 45 R613 C608 OFFSET
PVcc
GND
R612 1.5k
EXTAL 44 12p/50
GND JA901
NM C610
Vcc 43 CKM1613-
0.1u/10
X2 3
NMI 42 47k
5
5
NC1 2
IC REGULATOR IC911 18 >
PLLVcc 41 R611 BA49183-V12 600uH GND1 GND2 (10A)
17 FUSE
C609 0.1u/10 BSENS
X601
Vss 40 BSENS 1 BSENS L901 D901 B.UP3 B.UP1 YEK5001
12MHz
CSS1847-
R913 SYSPW 2 1 16 GND
NC2
RES 39 SYSPW 2 SYSPW 1SR154-400
CTH1432- 15 B.UP
4
1 X1
22k D902 BREM
Vss 38 C607 3 SW5VCNT
+B 14 BREM
CKIO 37 12p/50 4 +B 1SR154-400 GND ACC &A.ANT
C606 13 ACC
PVcc 36 SYSB 5 SYS+B
47k
47k
12
R610
SW5V
R609
SSENS 35 0.1u/10 USB GND SSENS 6 SW5V
DSENS1 R608 11
/CDRST DSENS VDD
/DSENS 34 7 VDD
TELIN
CDDADATIN 10
33 NM CDRST 1.2V
CDLRCKIN 8 VDD12
R607 NM 9 TEL
32 CDDATAIN SWVDD 9 SWVDD RR2
R606 NM B.UP2 8 RR-
31 CDLRCKIN 10 +BUP RL2
RGBDT/DIMMER
R914 VDDCNT 7 RL-
PVcc
Vss
KYDT
DPDT
CPRST
CPPWR
TELIN
CDSTBY
SWVDD5
CDSCKIN
RST 11 VDDCONT RR1
IC671 6
22k RL1 RR+
22
23
24
25
26
27
28
29
30
12 GND
1 5 5 RL+
POWER SUPPLY
C673
2p/50
2 D911
NM
4 FR-
C929
VDD CRG03
NM
FL2
C925
D671 3 4 3
VSS NC1 FL-
NM
D912 FR1
1
1
SWVDD
SYS+B
R670
NM 2
NM
FR+
R912
R911
R671
C911
FL1
TELIN1
S-80827CNMC-B8M CRG03 1
100k FL+
C928
47k
C605 0.1u/10
RFGND
NM
NM
C930
R604
C914
NM
NM
NM
C915
C912
NM
C927
C926
C924
C923
C922
C921
C920
C919
C918
C916
1000u/16
C917
0.1u/16
C671
1u/10
C672
C913 1000p/50
1000p/50
CCG1201-A
1000p/50
1000p/50
6
6
RESET NM
4.7u
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
RFGND GND *only A
4.7u
4.7u
4.7u
4.7u
DGND
only A
FM:+24.4 dBs
NM
GND
ASENS
AM:+24.6 dBs
AUX:+35.1 dBs
NM *3 CD:+35.3 dBs
R605
ASENS2 ASENS1
R941 D941 R944 USB:+35.3 dBs
RGB Supply
Q941
Q871 22k 1k
DZ2J068M0
2SA1577(QR)
LSCR523UB
6.8k
47k
R943
R942
*only B, C
C941
0.1u/16
10k
FM:+20.3 dBs
R872
KYDT
DPDT
CPRST
CPPWR
TELIN
CDSTBY
CDSCKIN
GND ASENS AM:+20.5 dBs
AUX:+35.3 dBs
R871
3.3k
CD:+35.6 dBs
(1/10W)
R952 only A USB:+35.7 dBs
22k TELIN
Q872
Q951
LTC143EUB LSAR523UB
R808 D951
SSENS
FH-X360UB/XNUW5
R953 L951
2.2k GND
AUXL R951 15k BTH1101-
R877 Q873 LED Supply TELIN
2SD1767(QR) DAN202UM
1k GND
AUXR
7
7
NM
AUXG
NM
NM
1.2k
R879
Q874
R873
L801 2 2 R809 DP
3 4 C968
22 CCG1192-A
47k
C969 10u R310
D871
2 5
0.1u/16
NM
NM
R810 DM GND GND 0
C872
NM
3 3 1 6
0.1u/16
R811 RGBST/ILMCLR2 RN4983 ILMPW
DZ2J075M0
CTF1713- 22 NM
C873
390
R874
D302
R878
R812 NM RGBCK/ILMCLR1 NM
C871
NM
RGBDT/DIMMER
R876
D872
D301
R813 2.2k
C322
47k
B.REM&A.ANT
0.1u/16
R875
Dim off 12.13 V C330
NM
Dim on 8.03 V *3 NM
DPDT LTC043EEB
ILM GND
8.2k
A B, C GND GND
R815
R816 2.2k ROT0 AGND
ILMPW D941 DZ2J075M0 DZ2J068M0
R817 2.2k ROT1 R943 33k 6.8k
SWVDD R944 1.2k 1k
L851 IC801
NM DPDT 1 5
NM
INB Vcc
NM
NM
2
C852
INA
NM
4.7k
NM
R851
3 4
C851
GND OUTY
C810 NM
C809
D811
8
8
C811
TC7SET08FUS1
VA802 NM
0.1u/10
GND
GND SWVDD
GND
A-a A-b
A-b
43
E
A
D
C
F
B
F
E
B
A
D
C
44
A-a A-b
A-b
A-a
*1 C457 4700p/25 TUNR CN701
C456 4700p/25
*only A *1 CD C
TUNER TUNL
FM: -10.6 dBs - SW Model
AM: -10.3 dBs CN701
VD
VD
GND
/CDSRQ
SDA
VDD
FM/AM ANTENNA AGND
C464
1u/6.3
A B, C VKN1192-
1
1
1
2
3
4 /CDSTBY
5 SCL
6 SKIP
7
8 RESET
9
JA401
10
11 DATA
12 BCLK
13 LRCK
14 GND
15 PGND
16 WAIT
9p/50
YKS5041- AGND *only B, C MECHA VD
C449
36.48MHz *1 *1
C450
9p/50
TUNGND 8p/50
C423 NM
L420
2 1 X2
L419
CTF1786-
4 GND2 3
FM: -14.7 dBs
C428 100p/50 22p/50
CTF1786-
7.4V
NM
3 DGND AM: -14.5 dBs
KN2 1 2
SDA
C432 VD2
SCL
82p/50 2p/50 Q751
NM
DATA
PGND
M2R6TP_GND R416 NM
VDD4
BCLK
GND1
RESET
P
P402
CDSRQ
DGND1
P401
SKIP
LRCK
WAIT
X1 KTD2092 VD1
C453 DCH1246
NM
C446 NM
C448 0.1u/10
CDSTBY
C445 0.1u/10
C447
CSS1848- C435 0.47u/10 1u/10
0.1u/10
C709
C455
C452
1u/10
0.22u/16 R701
HSPC16701B02
L418 NM C439
220
NM 0.1u/16
R718
L417 47k
47k
C454 NM C441 NM 10p/50 R702
R753
RFGND
NM
L416
R417
C753
NM NM C459 100p/50 1000p/50 100k R71
C451
0.1u/10
R415
390
0
1/4
R752
C751 NM
*1 C448 0.1u/10 0.01u/16 100
L414 L415
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
VDCONT Q752
CTF1786 C467 NM 0.1u/10
1 48 C467 NM 3 4
0.1u/10
CCG1201-A-T 10u/10
220
750
L406 CTF1389 NM
R401
R402
TCFM
2 C444 2 5 GND
TVDAC
PLLTEST
47 2.2u
OSCIN
10k
L407 NM 0.27uH
R754
OSCOUT
CCG1218- 1 6
0.1u/10
3
GND-PLL
VCC-PLL
DACOUTR
DACOUTL
VREFDEC
GND-REF
VCC-REF
46 C443 RN4983
VDDIO1V2
C401 FMMIXDEC L408 4.7uH 1.5uH 5 4
VDDPLL1V2
RFGND 0.1u/10 4
D402
D401
45 NM
L401 FMMIXIN2 3
VCC-ADC_DAC
GND-ADC_DAC
L409 NM 6
D751
0.39uH
RN731VN
150
C410
150
150
RN731VN
0.27u 5 TEST 44
C752
DZ2J082M0
FMMIXIN1 FMPINDRV VDD_CORE L410 47uH 2.2uH 7 2
33p/50 C402 6 FMPINDDEC GND1V2 43
0.01u/16 GNDRF 8 1 C704
C403 GPIO0 L414 CTF1786 NM
7 42
NM
GPIO1
R715
10p/5
R716
TCAM
R717
6p/50
C409
C408
C407
C406
C405
R403 390 330
L402
1u/10 GPIO2 R703
0.15u
8 41
0.01u/16
0.01u/16
0.01u/16
GND 4.7k C705
220
220
100
220
100
VCCRF
1k
2
2
10 GPIO5 39 0
RF GND
R704 100k C706
GNDVCO GPIO6
R711
12 37 R415 NM R705
LF1 GPIO8 NM
0.01u/16 13 36 C445 0.1u/10 NM C701
C413
PINDDEC NM
NM
0.1u/10
C414 0.01u/16 14 PINDIN 35 C442 C464 NM DCH1246
*1 TCAM2 VDD3V3 0.01u/16 C703
L404 RFGND 15 34 0.1u/10 C465 NM 0.01u/16
C415 CCG1192- TUN_SCL R721
I2CSCL R724 NM
CTF1786- 10u DGND
VREG3V3
RSTN
RDSINT
16 I2CSDA 33 TUN_SDA C466 NM 1u/10 R722
RFGND NM
GNDLNA
LNAIN
LNADEC
LNAOUT
LNAIN2
LNAOUT2
LNADEC2
AMMIXIN1
AMMIXIN2
GNDSLINK
VDIG
VCCREG1V2
REG1V2
C417
NM
NM
0.1u/10
1u/10
C461
C416
C418 C468
0.1u/10
0.022u/16 GND R723
L413
17
18
19
20
21
22
23
25
26
27
28
29
30
31
32
GND C461 0.1u/10 NM
C419 15p/50 R403 C424
CTF1786-
0
C420
NM 24
RFGND TUN_RST
NM
0.01u/16 L406 390 0.01u/16 *1 B.UP
C427
C426
C425
NM
CTF1389
0.1u/10
L408 GND
0.1u/10
SW5V
R409
4.7u CCG1192- *2
L405
C460
10u
1M
L407
NM
R404
NM 0.27u C430 3.3V
C438
1u/10
C468
R410
C440
C439
C436
1M
33
0.1u/16
C437 NM
C423
8p/50
R407
1000p/50
1000p/50
NM
RFGND
C422
FH-X360UB/XNUW5
*1 C431 NM DGND *1 *1
R412 R413
L409
0.39u
VDSENS
VDCONT
CDSRQ
CDSTBY
CD_SCL
CDSKIP
CD_SDA
CDRST
CDDATAIN
CDSCKIN
CDLRCKIN
CDWAIT
470
R406
C428
R408
100p/50
1/4W
C421
3p/50
8.2 8.2 1/4W
DGND
C463
C441
FLASH ROM L681
NM
*1 L411 NM
NM
10p/50
R405
MCLK
C429 L410
680
0 NM
NM
R411
BSENS
ASENS
R414
C432
IC681
C435
82p/50
RF GND
RESETB
VDCONT
CDWAIT
0.01u/16
C434
C466 0.01u/16 47u
47k
0.47u/10
1u/10
TUN_RST
47k
R681
C459
R684
47k
3
3
*1C462
RF GND RF GND CSVCC
C458
*1 1000p/50 *1 *1 2 NC/SIO3 7
NM RFGND DGND NM RFGND DGND SO/SIO1
0.1u/10
1
NM
R682
C681
C682
PEB113A8
47k
KN1
R683
C683 3p/50
NM M2R6TP_GND
CN971
NM BT Connector
VCC 16
DGND
47k
C625
NM
R638
C622
VCC 15
22p/50
0.1u/10
C971
GND 14 C973
47p/50
GND 13 R974 100
8
7
6
5
BTDATA R636
BTDATA 12
R975 100 BT_BCK
47k
BTBCK 11 47k
R623
220
220
220
R632
100
47k
220
220
220
BTLRCK 10
L971
0.1u/10
C624
C623 0.1u/10
R635 1k
R634 1k
TDI 3
47k
TCK 1
TMS 2
TDO 4
GND 9
0.1u/10
R633
R631
NM
R630
R629
R628
R627
R626
R625
C621 0.1u/10
ASEBRK 47k
BT_RST
NRST_CPU 8
BTTX
SYSTOBT 7
R971 NM BTRX
90
89
88
87
86
85
84
83
82
81
80
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
BTTOSYS 6
4.7k
4.7k
R640
R639
NM
Vss
TCK
TDI
TDO
Vss
Vcc
TMS
Vcc
Vss
C972
QIO1
TRST 61
QIO3
QIO2
QIO0
QSSL
PVcc
92
PVcc
4
MIC1P CP_SDA
4
ASEBRK 62
/ASENS
TUNRES
VDCONT
MD_CLK 79
QSPCLK
R641
/BSENS
GND 3 TUN_SCL 93
/CDWAIT
MD_BOOT
GND
AUDIO_X1
R973 NM
EVOL_MCK
AUDIO_X2
EVOL_RST
R642
MIC1N 2 TUN_SDA NM 94 MODE
2.2k TUN_SDA CP_SCL AVref
C974
GND 1 CD_SCL NM 95 CD_SCL CP_SDA IC601 AVcc KE
96 TUN_SCL AVss
GND GND CD_SDA CD_SDA R5S726A0D216FP VDS
GND
MIC1P
MIC1N
CDSRQ 97 /CDSRQ *2 R
JA892 TESTIN 98 DDON R
R618 R619
47k
47k
R643 99
R669
R668
NM
(RMIC) MIC1P
TESTIN A 47k 22k CDS
6 DDON
5 100k 100
MIC1N Vss B 22k 47k AS
4 Q601
LTC014YEB C626 101 PVcc
3 C 10k 47k
2 0.1u/10
1 KEYD 102 BT_TESTMD
C627 22p/50
(W/R) 1 R891 KEYD2 BT_TESTMD
1k KEYD BCLK R644 100 103 EVOL_BCK P
3
NM
KEYAD2
NM
KEYAD KEYAD 22p/50
C894
W.REM 2 LRCLK
C893
R645 100 104
VA891
EVOL_LRCK
R893
R892 1k C628
1000p/50
1000p/50
VA892 NM
105 KEYD
/16
892
16
JA891
C891
only A
CD_SCL CP_SDA IC601 KE
96 TUN_SCL AVss
GND GND CD_SDA CD_SDA R5S726A0D216FP VDS
GND
MIC1P
MIC1N
CDSRQ 97 /CDSRQ *2 R
JA892 TESTIN 98 DDON R
R618 R619
47k
47k
R643 99
R669
R668
(RMIC)
NM MIC1P
TESTIN A 47k 22k CDS
6 DDON
5 100k 100
MIC1N Vss B 22k 47k AS
4 Q601
LTC014YEB C626 101 PVcc
3 C 10k 47k
2 0.1u/10
1 KEYD 102 BT_TESTMD
C627 22p/50
(W/R) 1 R891 KEYD2 BT_TESTMD
1k KEYD BCLK R644 100 103 EVOL_BCK P
3
NM
KEYAD2
NM
KEYAD KEYAD 22p/50
C894
W.REM 2 LRCLK
C893
R645 100 104
VA891
EVOL_LRCK
R893
R892 1k C628
1000p/50
1000p/50
VA892 NM
JA891 105 KEYD
C891
only A
C892
GND CKS6437- D602 106
0.1u/16
EVOL_DATA
10k
0.1u/16
RB551VM-30
R646
KEYD 107 EX
DIN R647 Vss
100
GND CLK 108 EVOL_CK
Q531 R648 1k C629 109
L531 LSAR523UB
5
Vcc
5
C631
1k 0.1u/10 110
22p/50
NM DATA R649 EVOL_DT PLL
R536 4.7k CPPWR STB R650 1k 111
R540 EVOL_CS
C630 112
47k
PVcc
R531
C531
47k
0.1u/10
CP_SCL
2.2k
SWVDD5 0.1u/10 113
R533
R532
2.2k
R537 100 SWVDD
R539 CP_SDA 114 Vss C
R538 100 PCL
47k 115 PCL P
CPRST RAM_MON 116
RAM_MON SS
IC531 SYNC
R651 47k
USB5V MUTE 117 MUTE USBCTL /CDRST /DSE
NM CMS03 CDDADATIN
L551 USB&USB5V /USBFLG
4.7u
C553 D551 R652
3.3V
B.UP
SYNC SYNC 118 CDLRCKIN
1 8 CTH1524- 0.01u/16
R534 2.7k
GND PAD VCC USBCTL 2.2k 119
2 9 7
SDA RST 120
NM
IC551 FLG
C552
C551
3 6
C565
RGBDT/DIMMER
1u/16
C570
4.7u
Vss
BD9876EFJ
220u/16
PVcc
SYSPW
ILMPW
BTDATA
NM
BT_LRCK
PVcc
ROM
Vss
Vcc
RGBCS/ILMCLR2
Vss
BTRX
BTTX
KYDT
DPDT
ANTPW
CPRST
CPPWR
TELIN
0
CDSTBY
CDSCKIN
Vcc
BT_TESTIN
NC1 SCL
CCG1222-
RGBCK/ILMCLR1
4 5
470
D552
R535 4.7k
R552
R653
47k
1u/10
1
2 BTRST
3 PVcc
4 BT_BCK
6
7
8
9
1 8
R661
220u/6.3
NM
NC2 NC3 Lx VCC
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
RB056L-40
C532
LX VCC
2 7
C555
10k
0.1u/10
GND 9 BST GND
C558
TP1
GND BST only A, C
NM
6800p/25
C633
3 6
R555
DDON BTTESTIN
C557
GND
C556
C554
VC EN
ROM
VC FIN EN
4 5
R553
C564 CCG1201-
SYNC
180k D
NM
R551
FB SYNC
NM
6.8k
R670
FB SYNC
47k
0.1u/10
R601
47k
C604
C601
R602
TELIN1
NM
0.1u/10
0.1u/10
R664 10k
C563
R603
47k
C605 0.1u/10
C602
C603 0.1u/10
R604
GND
43k D
R554
GND GND
IC552
6
6
D GND
BD2232G-G
GND
RGBDT
1 5
47k
2
GND FLG
3 4 FLG
EN OC only A, C
47k
R663
NM
C562
C561
1u/10
USBCLT
C569 NM
NM
C560
C559
1u/10
USBCTL
DGND
GND
SYSPW
RGBST/ILMCLR2
BT_RST
BT_BCK
BTDATA
RGBCK/ILMCLR1
BTRX
BTTX
ILMPW
KYDT
DPDT
RGBDT/DIMMER
BT_LRCK
OFFSET
CPRST
CPPWR
TELIN
CDSTBY
CDSCKIN
VBUS
DSENS
C801
NM
R802
CN801
CKS6452- NM R808
J
RGBDT/DIMMER
FH-X360UB/XNUW5
DSENS 20 2.2k
R801 2.2k R805 100
AUXL 19 GND
NOTE : R803 22k
SOURCE 18 R806 100
7
7
KYDT 8
R818
The > mark found on some component parts indicates A FH-X360UB/XNUW5 RGBDT 7
R816 2.2k
the importance of the safety factor of the part. ROT0 6
B FH-X365UB/XNES 5
Therefore, when replacing, be sure to use parts of ILM+B
R817 2.2k
C FH-X369UB/XNID ROT1 4
identical designation.
SWVDD 3
ILMGND 2 DGND
NM
NM
ILMG
NM
NM
1 C803
NM
NM
DGND
D801
NM
NM
NM : No Mount
0.1u/16
C802
USGND C804
NM
C814
C810 NM
C813
C809
C805 NM
C807 1u/10
D803 DZ2S068C
D804 DZ2S068C
C806 NM
D802 NM
D805 DZ2S068C
D807 DZ2S068C
D809 NM
D810
D811
8
D806 DZ2S068C
C808
D808 NM
8
VA801 NM
VA802 NM
GRILLE
DGND USBGND ILM GND
A-a A-b
A-a
A-b
45
E
A
D
C
F
B
F
E
B
A
D
C
46
B
SEG51
SEG50
SEG49
SEG48
SEG47
SEG46
SEG45
SEG44
SEG43
SEG42
SEG41
SEG40
SEG39
SEG38
SEG37
SEG36
SEG35
SEG34
SEG33
SEG32
56 COM3
COM3 55 COM2
COM2 54 COM1
COM1 53 COM0
COM0 SEG51
1
1
SEG51 52
51 SEG50
SEG50
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
50 SEG49
SEG49 49 SEG48
SEG48 48 SEG47 R1801 1 60
SEG47 SEG46 SEG31
SEG46 47 DBG SEG31
46 SEG45 47k 2 59
SEG49
SEG48
SEG47
SEG46
SEG45
SEG44
SEG43
SEG42
SEG41
SEG40
SEG39
SEG38
SEG37
SEG36
SEG35
SEG34
SEG45 SEG44 KYDT SEG30 SEG30
45 KYDT
SEG44 44 SEG43 3 58
SEG43 SEG42 KST0 KST0 SEG29 SEG29
SEG42 43
42 SEG41 DPDT 4 57 SEG28
SEG41 41 SEG40 DPDT SEG28
SEG40 40 SEG39 5 56
SEG39 SEG38 KST1 KST1 SEG27 SEG27
SEG38 39
SEG51
SEG50
38 SEG37 6 55 SEG26
SEG37
SEGMENT LCD
SEG36 REM SEG26
SEG33
SEG32
SEG36 37
36 SEG35 KST2 7 54 SEG25
SEG35 35 SEG34 KST2 SEG25
SEG34
C FH-X369UB/XNID
34 SEG33 47k 8 53 SEG24
B FH-X365UB/XNES
SEG33 33 SEG32 RST SEG24
SEG32 32 SEG31 R1802 9 52 SEG23
A FH-X360UB/XNUW5
SEG31 31 SEG30 BTPW SEG23
V1801
SEG30 30 SEG29 10 51
SEG29 SEG28 SEG22 SEG22
NC
CAW2033-
SEG28 29
28 SEG27 R1804 11 50 SEG21
SEG27 27 SEG26 V2 SEG21
IC1801
SEG26 NM
SEG25
PD6583A
SEG25 26 12 49 SEG20
25 SEG24 V3 SEG20
10.2 KEYBOARD UNIT
SEG24
DGND
24 SEG23 C1807 R1803 13 48 SEG19
SEG23 23 SEG22 VLCD SEG19
SEG22 22 SEG21 2.2k 14 47
SEG21 1u/10 VCC SEG18 SEG18
21 SEG20 KST3
SEG20 20 SEG19 15 46
SEG19 SEG18 KST3 SEG17 SEG17
SEG18 19
18 SEG17 16 45 SEG16
SEG17 17 SEG16 NC SEG13 SEG16
SEG16 16 SEG15 C1806 17 44
SEG15 C SEG15 SEG15
KDT0
KDT1
15 SEG14 SEG12
2
2
X1801
10 SEG9 20 41 SEG12
SEG9 9 SEG8 VSS
KDT2
KDT3
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG8
COM0
COM1
COM2
COM3
CSS1547-
SEG10
SEG11
8 SEG7
SEG7 7 SEG6
SEG6 SEG5
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
SEG5 6
5 SEG4
SEG4 SEG3 R1805
*1
SEG3 4
3 SEG2
DGND
SEG2 2 SEG1 47k
5 MHz
SEG1 1 SEG0 R1806
SEG0
47k
R1807
R1955
R1953
47k
GRILLE uCON
D1953 - D1956
R1808
47k
SEG10
SEG11
KDT0
KDT1
KDT2
KDT3
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
COM0
COM1
COM2
COM3
FH-X360UB/XNUW5
A
390
390
D1951 D1952 R1951
KST3
KST2
KST1
KST0
RED COLOR
270
SOURCE
SWBA05(FI231719)
1/4W R1941
FM-3528SXK620H08
SWBA05(FI231719)
3
3
47k
NM
R1942
*1
only A
4
3
4
3
4
4
3
3
C1955 C1954
2
S1826
NM NM R1953 REM
S1834
EQ
S1830
S1821
1
CSG1155-
2
1
CSG1155-
CSG1155-
2
1
CSG1155-
2
2
GND
1
1
560
560
DISP
LEFT
B, C
C1941
IC1941
1/4W
DGND
VCC
3
REMOTE
GP1UXC14RK
CCG1192- KDT0
4
BLUE COLOR
3
FM-3528BK-470M
R1943
*1
S1837
NM
4
CSG1155-
3
4
2
3
LED
4
1
3
SRC
4
3
S1831
100
CSG1155-
CSG1155-
S1835
R1944
1
2
1
NM
CSG1155-
2
1
LIST
CSG1155-
ILMGND
2
1
only B, C
1/10W
EJECT
KDT1
DGND
4
4
3
3
*1
4
3
4
S1832
S1823
C1952
1
C1953
S1836
CSG1155-
CSG1155-
NM
2
2
1
1
NM R1955
CSG1155-
2
1
RIGHT
KDT2
4
4
1/4W
4
3
4
4
3
3
*1
5
S1829
S1833
S1824
CSG1155-
CSG1155-
CSG1155-
2
1
2
2
1
1
D1956 D1955
R1956
BAND
BACK
NM KDT3
1/10W
4
5
5
4
S18
KY
DP
CSD
SO
MULTI-C
5 6 7 8
B KEYBOARD UNIT
KDT3
CK
SOURCE
5-
2 KYDT
B
1 DPDT
C1825 CN1931
CKS6451-
NM
D1932
1 DGND
D1931
NM
NM
DGND
ILMGND 2 ILMGND
3 SWVDD
4 ROT1
DGND
5 ILM+B
6 ROT0
L1801
7 USBGND
NM R1931 2.2k 8 KYDT
A
R1823
R1822
NM
27k
9 USBGND
S1839
R1932 2.2k
5 2
10
11
DPDT
USB5V
CN801
5 2
3
12 ILMCLR1
3 R1911
4 1 13 DM
4 1
NM 14 ILMCLR2
CSD1168- R1912
DGND 15 DP
NM 16 AUXGND C
MULTI-CONTROL 17 AUXR
18 SOURCE
19 AUXL
20 DSENS
AUX:+2.0 dBs
DGND
USB L1911
2
CN1911
CKS6443-
1
NM
4
ILM+B
1
2
Dimmer off 12.23V
Dimmer on 8.13V 3
4
D1911
5
NM
D1912
NM
6
C1913
C1911
0.1u/16
NM
C1914
0.1u/16 D
NM
C1912
ILMGND C1915 DGND
ILMGND DGND
NM
ILMGND DGND
L1922
CTF1389-
AUX
R1956
R1922
1/10W
NM
NM
JA1921
CNK1094- E
3 L1921
D1955
2
1 CTF1389-
R1921
C1921
C1922
C1923
NM
NM
NM
NM
D1956
L1923
CTF1389-
ILMGND R1923
NM
B
FH-X360UB/XNUW5
5 6 7 8
47
1 2 3 4
PU UNIT(P10.6) (SERVICE)
A CXX3556
V3R3
E:P5+P10
2.7
(1/10W)
(1/10SR,1608)
2.4
C104
4.7u/6.3
(2125)
R
2.4
R
PUEN R
LD1 Q102 R
LTA123JUB
0.047u/16
C214
LD Q101 R109 LD
VCC
2SA1577(QR) 2.2k
R2
C102
D101
NM
NM
39
LD-
15 15
ASY
LD+
14 14 V+3A EFM
B+D BD
13 13
B VCC
12 12
V+3A
ATEST
75
74
C101
NM
P5+P10 E
11 11
ATEST
GND
10 10
C110
C111
P1+P6 F
NM
NM
9 9
VREF REFO 76
8 8 C221 A.VDD1
VR 77
C201
NM
R108
7 7 A.GND1
1M
0.1u/10
A+C
6 6
AC PD
PD
f C216
1800p/50
78
79
RFI
MD
5 5 RFAGC AGCO
TOM C220 80
TOM
HOLOGRAM UNIT 4 4
0.1u/10
C3T
FOM FOM C219 81
3 3 AGCI
FOP FOP 0.1u/10 82
2 2 RFO RFO
FOCUS ACT C228 R229 83
TOP
R218 R217
TOP
5.6k
1 1 EQ2
4p/50
C218
TRK ACT 27p/50 470 84
EQ1
C217 R216 85
4.7k
C205 RF2-
56p/50 1.2k 86
TOM
FOM
FOP
TOP
NM RF-
AC
BD
F.ACT: Applying positive voltage to FOP, 87
E
F
A.GND2
the lens approaches DISC. CN101 C204
C222
0.1u/10
88
A.VDD2
CKS4808-A NM 89
T.ACT: Applying positive voltage to TOP, AC
A
C the lens moves outer circumference of DISC. BD 90
B
F 91
F
E 92
E
REFO 93
REFO1 REFOUT
REFO2 C229 d C223 94
95
FE-
FE 68p/50
0.1u/10 FEO
1608:PARTS 96
* NO MOUNT PARTS (NM) C236 ADCIN ADCIN
C205 C209 C238 C224
C240 C307 C308
0.1u/10 c 47p/50
97
98
TE-
TE TEO
C708 C225 99
Land for manual soldering 0.01u/16 100
TE2
R101 R102 R103 TEC TEC
R246
2125:PARTS
LD
C239
NM
M1 C104
1
2
SPDL MOTOR
CXE2273 LD
PD
BLK
SOM Parts with Polarity
D
IC201 IC301
RED D101 VDD
SOP Q101 Q102 Q201
C202
M2 C301
LOAD/CRG MOTOR
GND
BL
LCOM
YW
LCOP
CXC4026
CN702
2
C307 IC301
7 NM
1u/10
(1608) 1
BD8223EFV
SPIN 28 SIN
8 MD
VDD 1
2 POWVCC CIN
SOM SLIN 27 SD
SPO-
C315
E HOME 3 SOP
LCOM C312
3
4
SPO+
BIAS 26
25
FIN NM
a9 FD
S901 HOME
SLLDO-
TKIN
5
431
NM SLLDO+
CSN1080-A 6 CNT 23 CLCONT
S905 NM 8SNS POWGND
7 LDIN 22
4
FOP LOEJ
431
FOM 8 21
MUTE
S903 1 DSCSNS TOM 9
TKO+
FCO-
PRTOUT 20
CONT
43 1
C308 FCO+
CSN1081-A 11 PRTLIM 18 R309 47k
TKRNF
DSCSNS 1u/10
(1608)
12
13
FCRNF
PRTF 17
16
MOTOR DRIVER LOGIC TABLE
PRTT LOAD EJ PLAY OFF
TKCDET
SWITCHES: 14 PREVCC 15
FCCDET CLCONT H H L L
0.1u/10
C306
CONT L L H L
S901:HOME SWITCH.........ON-OFF
C314
C313
S903:DSCSNS SWITCH.....ON-OFF VD
C301
NM
C
FH-X360UB/XNUW5
48
1 2 3 4
5 6 7 8
MD
R305 SD
TD
FD
PUEN
C CD CORE UNIT (S11.6STD)
R307
1k
1k
C302
C303 1000p/50
1000p/50 PUEN
C304
R304
R303
C305 0.022u/16
12k
12k
0.1u/10
R308
R306
4.7k
4.7k
R310
TEMP
ADENA
4.7k
/CDSRQ
SKIP
R311
R312 4.7k
R313 4.7k
4.7k GND
0.1u/10
0.047u/16
3300p/50
C214
C213
C212
R246
C235
(1608)
NM
NM
VDD TEMP
TEMP
R215
e
MDX
R260
39k TH201
10k
NM
0.1u/10
R214
10k
b MONI2
MONI1
MONI0
C215
C16M
ASY
MDY
GND
R232 0 10k
R281 56 22
LRCK0
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
R282 56 22
MD
EFM
SD
TEMP
TD
FD
VDCONT
ASY
SD2
VDSENS
TEST
/CDSRQ
ATEST
AD.GND
AD.VDD
/ADENA
SKIP
MONITOR_3
MONITOR_2
MONITOR_1
MONITOR_0
/PUEN
R291 56 22
IO.GND2
IO.VDD2
/TESTIN
R294 470 0
76 50 BSCK0 /WAIT
A.VDD1 PC3
77 49 SDA
A.GND1 SDA
C216 78 48 SCL
RFI SCL
1800p/50 79 47 R291 LRCK
AGCO /WAIT
80 46 C283 56
C3T TX/EMPH
C219 81 45 NM BCLK
AGCI LRCK
0.1u/10 82 44 R281 56 C281 C282
RFO SCKO
8 R229 83 43 R282 56 NM NM DATA
EQ2 DOUT
0 470 84 42 C284
EQ1 PA7
7 R216 85 41 NM LOEJ
RF2- LOEJ
0 1.2k 86 40 CLCONT
RF- CLCONT
87 39 R264 1k CONT
A.GND2 IC201 CONT R245
88 38 DSCSNS 100k
A.VDD2 PE5791A DSCSNS R253
89 37 8SNS
A NC NM
90
B 12SNS
36
R254 C
91 35 HOME
F HOME 100k
92 34 EJSW R240
E EJSW
93 33 /CDSTBY 47k
REFOUT /CDSTBY
C223 94 32 ICECK
ICECK
FE- ICECK
68p/50 95 31 R297
FEO IO.VDD1 C211
96 30 NM
ADCIN IO.GND1 0.1u/10
C224 97 29 R237 RESET
TE- RESET
47p/50 98 28 C233 220
TEO C.GND
99 27 C210 0.01u/16
TE2 C.VDD
100 26 0.1u/10 R232
TEC VPP
INTQ(INT1)
DA.GND1
DA.VDD1
0
DA.GND
DA.VDD
REG16
VPP
D.GND
ICEMD
X.GND
D.VDD
X.VDD
REGC
REGS
ROUT
/XTAL
LOUT
XTAL
/SCK
/RST
/STB
SO
CVDD
PD
LD
A0
C239
SI
NM
VPP
CVDD
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
1
R294
0.1u/10
470
SO
SCK
RST
A0
ICEMD
STB
SI
INTQ
X201
CSS1603-A
D
VDD2
VDD1
3
C203
(1608)
SCK
C238
C240
GND
CVDD
SCK
VPP
RESET
6
ICECK
CDSTBY
CDSRQ
RESET
SKIP
SDA
SCL
VD1
VD2
CN701
10 GND
6 SO
CKS6146-A
8 SI
I/O
CN702
4
2
VD
1 VD 7.5V
NM 2 VD 7.5V
/CDSRQ
3 /CDSRQ
R706
CVDD 3
ICECK 5
VPP 9
SCK 7
VDD 1
/CDSTBY /CDSTBY
4
SCL R702 220
5 SCL
SKIP 100
6 SKIP
R701
SDA
E
RESET 100
7
8
SDA
RESET A
9 VDD 3.3V
10 GND GND
CN701
DATA
11 DATA
BCLK
12 BCLK
LRCK
13 LRCK
1000p/50
C710
C705
C707
C708
14 GND GND
NM
(1608)
NM
NM
15 PGND
LOGIC TABLE /WAIT
GND
16 WAIT
J PLAY OFF
H L L IIC-BUS
R711
R710
C703
C702
C701
NM
NM
NM
NM
NM
L - - Digital
PGND
L H L
WAIT
GND1
GND2
GND3
DATA
LRCK
BCLK
i h g
F
PGND1
PGND2
C
FH-X360UB/XNUW5
5 6 7 8
49
1 2 3 4
10.4 WAVEFORMS
- CD CORE UNIT(S11.6STD) Note : 1. The encircled numbers denote measuring points in the circuit diagram.
2. Reference voltage REFO1(1.65 V)
A
1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div
3HOME 5 V/div 5CLCONT 5 V/div
4LOEJ 5 V/div 4LOEJ 5 V/div
6VD1 10 V/div
12 cm CD Loading operation 12 cm CD Loading operation
Ref.: Ref.:
GND GND
B
Mode: Mode:
Normal Normal
7SIN 1 V/div 1 s/div aFIN 200 mV/div 500 ms/div cTE 500 mV/div 200 ms/div
8CIN 500 mV/div bRFOK(MONI_2) 2 V/div dFE 500 mV/div
9TIN 500 mV/div 7SIN 2 V/div
12 cm CD-DA setup operation after loading 12 cm CD-DA Source On setup operation Source On setup operation
dFE 500 mV/div 20 ms/div eMDX 2 V/div 50 ms/div eMDX 2 V/div 5 μs/div
aFIN 500 mV/div 7SIN 500 mV/div 7SIN 500 mV/div
cTE 500 mV/div
9TIN 500 mV/div
D CD-DA Play operation Spindle waveform during play operation Spindle waveform during play operation
(Wider)
aFIN 500 mV/div 200 ms/div cTE 500 mV/div 2 ms/div fRFAGC 1 V/div 500 μs/div
E dFE 500 mV/div fRFAGC 500 mV/div cTE 500 mV/div
9TIN 500 mV/div
Focus Search waveform Track Open waveform 100 Track Jump waveform (32 Track Jump x 3)
FH-X360UB/XNUW5
50
1 2 3 4
5 6 7 8
A
fRFAGC 1 V/div 2 ms/div fRFAGC 1 V/div 200 ms/div gLRCK 2 V/div 10 us/div
cTE 500 mV/div cTE 1 V/div hBCLK 2 V/div
9TIN 500 mV/div 8CIN 500 mV/div iDOUT(DATA) 2 V/div
7SIN 2 V/div
32 Tracks Jump waveform
(Zoom of 100 Track Jump waveform) Search operation(Outter to Inner) Digital Out waveform
B
Mode: Mode: Mode:
TEST Normal Normal
Ref.: Ref.: C
GND GND
Mode: Mode:
Normal Normal
Ref.:
REFO
Mode:
Normal
FH-X360UB/XNUW5
5 6 7 8
51
1 2 3 4
2 3 C891 R891 1 5
C260 2
4 1 5 1 4 6 R892
6 5 3 2 VA891
R251
R256
R258
C893
C258
R253
Q252 C320
C253
R893 VA892 C331 C33
Q251
R259
1 R255 C328 C317
P251
130 1 C255 C301 C305
C257
B
R257
R254
C254
C256
C252
C318
SIDE B C259 R252 C251
C309
R301
C311
R303
D551 R555 C562
C551
C556
120
C563 C557
IC551 C558
5 C555 C564
C553 R553 R552
110
R551
C554
1 R554
C570
C565
1
C552
D552 L551
100
C
80
70
D
60
50
40
E
C CN701
30
20
10
B CN1931
Y
F
0 X 10 20 30 40 50 60 70
A
FH-X360UB/XNUW5
52
1 2 3 4
5 6 7 8
A
SIDE A
C326
1 5 15 25
POWER SUPPLY L901 Q751
10
IC301
20
JA901 C752
E
1 D751 R752
C319 2 4 6 8 10 12 14 16 18
FUSE
1
C325 1 3 5 7 9 11 13
C320
C331 C333 C334 C332 15 17
317 Q752 C753
R310
R312
C313
C301 C305 C307 C303 C327
B
R306 C335 C324 C323 D902 D901 C751
C318 C321
C310
1 R307
R305
C901 C314 FM/AM
R943
C961
R304 D301
ANTENNA
D302
C309
R301
C311
Q301 C329
R303
C312
C941
D941
C322
R302
R311
R944
R309
JA401
R942
E C330
R941
C911
Q941 C930
KN2
R951
C202
R953
C204 L951
C234
C233
C205
D951
C229
C969
C203
C228
P402
IC201 1
C201
C421
P401
C206
40
1
C218
C422
R405
C419
C212 R952 C968
5
C226 E
C227
35
L409 L405
C207 C231 Q951
R406
R313 L407 C410 D401
C210 C423
10
L401
C209 C214 C219 L201 E C461 L402
C417
R403
15
C235
25
L404
L202
C407 C406
C224
R404 C418
C236
C424
C463
C415
C412
C405
C414
C416
20
C402 R402
C403
C404
C413
L403
C217 C220 C425 C401 D402 C458
R685
C681
R409 C464
Q531 L681 C426 C411
C
C455
R681 IC681 R408 C454
E
L531 1 C429 R407 C427 L420
C453
C682 15 10 5 1
C428
R535
R536
L419
R631
R638
C532
20
R682
C531
60
C460 C457
5 C432 C452
C430
X603
R632
R754
R637
25
R410
R633
R634
IC401
R626
C620 R625
1 R753 C433
R635
R629
55
R411 C431 C451 C450
IC531
C434
C625
C441 R417 1
30
R642 C618 L411
50
5
R627
R624
R630
C624
R537
R540
C623
C621
X602 X401
C446
C448
1 R623 R414 35 40 45
R641 R622 1 C435
R532
R533
C613
C612
90 85 80 75 70 65 C440
R619
R538
R618
C436 L413
R539 C443 L418
C627 R643 D601 C444
95
L415
C442 C445
55
C437
C467
C628
R415
L414
C626 R617 C466
C439
L417
R416
C468
100
R644 L416
50
C608 C671
R647 C611
105 110
R613
R646
R648
D602
R612
R649 C629 C610 1 X601 1 C462
40
R650 C609
C672 C607
115 120
C606
R651 Q873
R669 R610 D671
C633 1 5 10 15 20 25 30 R611 R671 Q872 E
R653
R601
E
R879
R652 R608 E
Q874
D911
C616
D912
R873
C617
D
Q601 C601 R616
C605
C602
C603
L601
C604
1
R621 R871
R607
R605
R661 R602
R973 R609 L602
R606
R663
R872
C971 R659
D871
D872
C615
C614
R604
R662
R876
R670 E
R660
CN971
R875
R874
Q871 C914
15
R974 E
R975
C973 Q875
R976 C918
10
C972 C929
L971 C710 C928
R971 C925
R972 C917
5
C915
C913
C702
C922
C920
C974 C924
C703
R704
C701
C927
R912
R913
1
R914 R911
C921 C919
R707
R724
R701
C704 C912
R723 C708
R722 10 5 1
R702
IC911
R719
R708
R709
R710
R718
R717
R716
R721
C569 C707
R706
E
N701 15 10 5 1
CN701 1R703
R877
C872
C852
KN1 C561
IC552
1
R878
C873
R812
R810
R809
C802
R811
R806
R807
R805
C851
L851 C560 R801
C811
C559 R808
R817
R816
R815
R851
R814
C805
D804
D809
D807
D805
D810
D806
D808
VA802
C810 R818
C804
C806
1 5 15
10 20
CN801 C801
F
FRONT
0 70 80 90 100 110 120 130 140 150 160
A
FH-X360UB/XNUW5
5 6 7 8
53
1 2 3 4
A
A TUNER AMP UNIT
TESTIN
PCL
1
E
F
160 150 140 130 120 110 100 90 80
A
FH-X360UB/XNUW5
54
1 2 3 4
5 6 7 8
SIDE B
A
150
140
1
1
130
B
120
110
100
90
80
70
60
50
40
E
30
20
10
Y
F
X 0
80 70 60 50 40 30 20 10
A
FH-X360UB/XNUW5
5 6 7 8
55
F
E
B
A
D
C
56
B
B
1
1
1
S1822
90 EJECT
V1801
80 55 50 45 40 35 30 25 20 15 10 5 1
KEYBOARD UNIT
SEGMENT LCD
11.2 KEYBOARD UNIT
D1951 D1952
IC1941
1
70
2
2
60
1 2 3 4 5 6 DISP
S1836 S1834 S1835 S1832 S1833 S1831 S1830
1
1
1
1
1
1
1
D1955 D1956
50
EQ
S1826
1
SRC LIST USB
S1837 S1828
CN1911
1
40
FH-X360UB/XNUW5
1
1
2
3
MULTI-CONTROL
4
S1839
3
3
5
5
30
6
1
D1953
D1954
1
20 AUX
1
LEFT RIGHT
3
S1824 S1829
10
1
1
BAND BACK
Y
0 X
4
4
F
C
D
A
57
B
SIDE B
8
8
90
80
70
60 55 50 45 R1943 R1941
40
R1951
7
7
65 C1941
60
35
R1944
R1942
70
30
IC1801 R1955
FH-X360UB/XNUW5
75
R1808
R1956
R1806
25
R1805
R1807
80
C1953
1 5 10 15 20
C1952
R1801 R1804
50
X1801
R1803
1
C1807
R1802
C1806
C1915
40
1
C1825
D1912 R1823
D1911
L1911
R1911
R1953
30
C1911 R1822 R1954
6
6
1
C1913
R1912
C1954
C1912 L1801
C1955
R1921
20
L1921
C1921
R1922
1
L1922
C1922 15 5 1 R1932 D1931
CN1931
L1923
R1931 D1932
KEYBOARD UNIT
C1914
C1923 R1923 10
20 10
Y
X 0
160 150 140 130 120 110 100 90 80 70 60 50 40 30 20 10
5
5
CN801
B
A
1 2 3 4
60
B
D101
F
CN702
R253
10
R245
1 5
E
C238
C
C240 C710
C205 R706
R297
C299
40
C707 C705
C220 R702
R701
SPDL
MOTOR
30
D
CN701
15 10 5 1
A
CN701
C702
20 C307
R710
C701 C308 C312
REFO1
E
R306
R304
R303
R308
10 5 1
IC301
10
R264 15 20 25
C306
R307
R305
R309
F 0
X 10 20 30 40 50
C
FH-X360UB/XNUW5
58
1 2 3 4
5 6 7 8
60
R102
R103
R101
C104 B
Q102
R108 Q101
C202 E
E
X201
1 R109 50
R294
C203
C239
C209 C225 C110 C101
C233
R237 25 20 15 10 5 1 C224 C111
C
100
C210 C223
C236
C229
C211
30
95
R240 40
R282
35
C284
90
R281 C204
C222
IC201
C281
40
C218
C301
C282 85 R216 R218
C219 R229
R291 C217
C283
45
80
C216 C228
C221 R217
50
55 60 65 70 75
30
C212 C215 D
R214
R215
R260
S905 1
C708
C213
C214
20
E
C303
C302
C304
C305
C703
R711
C313
C315
R313
C314
1
R312 DSCSNS
R311 S903 10
R310
0 F
50 40 30 20 10 X
C
FH-X360UB/XNUW5
5 6 7 8
59
1 2 3 4
C
560
561
(A,108,21)
(A,103,24)
CKSRYB105K10
CKSRYB105K10
B
Unit Number : (A)
C 564 (A,33,114) 4.7 uF CCG1201
C 565 (A,16,107) 4.7 uF CCG1222
Unit Number : (B,C)
C 601 (A,105,66) CKSSYB104K10 Unit Name : Keyboard Unit D
C 602 (A,109,65) CKSSYB104K10
MISCELLANEOUS
C 603 (A,111,65) CKSSYB104K10
C 604 (A,113,65) CKSSYB104K10 IC 1801 (B,79,58) IC PD6583A8
C 605 (A,117,65) CKSSYB104K10 IC 1941 (A,25,74) IC(B,C) GP1UXC14RK
C 606 (A,122,71) CKSSYB104K10 D 1951 (A,34,70) White LED SWBA05(FI231719)
C 607 (A,127,73) CCSSCH120J50 D 1952 (A,135,70) White LED SWBA05(FI231719)
FH-X360UB/XNUW5
64
1 2 3 4
5 6 7 8
Circuit Symbol and No. Part No.
C 229 (B,9,40) CKSSYB104K10
C 233 (B,32,46) CKSSYB103K16
C 236 (B,8,40) CKSSYB104K10
C 238 (A,25,44) CKSRYB104K16 A
C 299 (A,26,41) CKSSYB104K10
FH-X360UB/XNUW5
5 6 7 8
65