Beruflich Dokumente
Kultur Dokumente
QUESTIONS
3. Which of the following process is used to give surface finish to the final object.
a. Casting
b. Spinning
c. Coining
d. Electroplating
9. During hot working, which of the following property of material will increase
a. Ductility
b. Stiffness
c. Toughness
d. All of the above
10. During cold working, which of the following property of the material will decrease
a. Ductility
b. Stiffness
c. Toughness
d. All of the above
12. Which of the following pattern is used to cast more than one piece in a single cast
a. Gated pattern
b. Match plate pattern
c. Cope and drag pattern
d. Boxed up pattern
13. Which of the following core is used to make blind hole in work piece
a. Balanced core
b. Horizontal core
c. Vertical core
d. Hanging core
15. Which of the following factor is not responsible for shrinkage defect in casting
a. Defective runner
b. Defective gate and riser
c. Pouring temperature of metal
d. None of the above
17. Which of the following factor is not responsible for porosity and blow hole defect
a. Improper method of welding
b. High velocity of arc length
c. Long length of arc
d. None of the above
18. Wrong inclination of electrode, wrong diameter of electrode, high voltage, long
arc length and corrosion on surface are responsible for which type of defect
a. Under cutting
b. Over lapping
c. Poor fusion
d. Distortion
19. The filler material used in brazing process has melting temperature more than
a. 310 0C
b. 427 0C
c. 600 0C
d. 1023 0C
26. The process of making a small cut, usually at a 45 degree angle, to remove a 90
degree edge is known as
a. Thread cutting
b. Chamfering
c. Knurling
d. Taper turning
30. In which of the following type of FMS, automation is obtained by single robot
a. FMM
b. FMC
c. FMG
d. FMMS
Which machine tools are basically handled and controlled by Computer Numerical
44
Control (CNmachine especially at the manufacturing sector?
a D All of the above c Mills & Grinders
b C Lathes d B Routers