Sie sind auf Seite 1von 7

RELIANCE INDUSTRIES LIMITED

JAMNAGAR

Total Questions : 50 Max. Marks : 50 Time Duration : 1 hour

Instructions :

1. Please do not write anything on this Question Paper


2. Give the answers in the ANSWER SHEET provided with this Question Paper
3. Please ‘X’ mark the correct option in the ANSWER SHEET.
4. No Negative marking for incorrect answers

1. Priming is needed in a

a) reciprocating pump
b) gear pump
c) centrifugal pump
d) diaphragm pump

2. Boiler feed pump is usually a

a) reciprocating pump
b) gear pump
c) multistage centrifugal pump
d) turbine pump

3. Function of inert vessel provided in a reciprocating pump is to …

a) reduce the discharge fluctuation


b) reduce the danger of cavitation
c) reduce the vibration on pump
d) balance the pump bearing

4. Net positive suction head (NPSH) of a centrifugal pump must be

a) greater then the vapour pressure of liquid


b) less then the vapour pressure of liquid
c) equal to the vapour pressure of liquid
d) less then barometric pressure

5. With the increase in molecular weight of the gas , the head developed by centrifugal
compressor will,

a) decrease
b) increase
c) remain same
d) depend upon type of gas

6. Moisture can be removed from lubricating oil by using

a) centrifuges
b) clarifier
c) vacuum filter
d) bag filter

1 of 7
7. Cyclone are used primarily for separating

a) solid
b) solid from fluid
c) liquid
d) solid from solid

8. Main constituent of natural gas is

a) CH4
b) C2H2
c) C2H4
d) C6H6

9. Viscosity index is

a) measure of flash point


b) is the measure of variation of viscosity with temperature
c) of lubricating oil should flow
d) none of the

10. Presence of sulphur in gasoline

a) leads to corrosion
b) increase lead susceptibility
c) decrease gum formation
d) help during stabilization

11. Which is the highest flash point of all

a) diesel
b) kerosene
c) petrol
d) fuel oil

12. LPG when brought to an atmospheric pressure and temperature will be

a) Liquid lighter then water


b) Liquid heavier then water
c c) Gas lighter then air
d d) Gas heavier then air

13. Fined tube heat exchangers

a) give larger area per tube


b) use metal fin of low thermal conductivity
c) facilitate very large temperature drop through tube wall
d) are used for smaller heat load

14. Water always boil when …..

a) temperature reaches 100 deg C


b) vapour pressure equal to 76cm Hg
c) saturated vapour pressure equal to the external pressure on its surface
d) saturated vapour pressure is less then the atmospheric pressuer

2 of 7
15. Steam trap is used to …

a) condense the steam flowing in pipe line


b) remove water resulting from partial condensation of steam
c) stop the supply of steam
d) for filtration of steam

16. Steam ejector used for

a) remove the condense from the steam line


b) create the vacuum
c) superheat the steam
d) effective use of steam

17. CO2 can be adsorbed by

a) Almina
b) Activated carbon
c) Cold Ca(OH2)
d) Clay

18. Thermocouple is suitable for measuring

a) liquid temperature only


b) very high temperature only
c) very low temperature only
d) both high and low temperature

19. The general formula for olefins is

a) CmH2m+2
b) CmHm
c) CmH2m
d) None of above

20. Which of the following statements is true for ideal gas.

a) P1/P2 = T1/T2
b) P1/V1 = P2/V2
c) P1T1 = P2T2
d) (P1V1)/T1 = 1/R

21. Calorie is equal to

a) 250 Btu
b) 746 Horse power
c) 1000 Kcal
d) 4.2 Joule

3 of 7
22. Manometer is used for measuring

a) Temperature
b) Pressure
c) Flow
d) Density

23. Which of the following gas is toxic gas

a) nitrogen
b) oxygen
c) carbon dioxide
d) chlorine

24. Cathodic protection is used for

a) prevention against corrosion in underground tank


b) prevention of cathode
c) protection of tank against static electricity
d) guarding for anode

25. A combustible gas will burn in atmosphere in presence of flame if its

a) concentration is below lower explosivity limit


b) concentration is between lower and higher explosivity limit
c) concentration is above higher explosivity limit
d) none of above

26. The unit of specific gravity is

a) kg/m3
b) kg/cm3
c) gm/cm3
d) none of above

27. The presence of carbon monoxide in flue gas of fired heater indicates

a) less fuel pressure


b) more combustion air and less draft
c) incomplete combustion
d) fuel with more carbon to hydrogen ratio

28. PVRV (pressure vacuum relief valve ) is used in

a) atmospheric storage tanks


b) pressurized feed surge drums
c) ejectors
d) pressure vessels

29. Low NOx burners use

a) staged combustion
b) more air
c) less fuel
d) nitrous oxide material

4 of 7
30. Distillation use following property to separate the components

a) difference in density of liquids


b) difference in boiling point of liquids
c) difference in temperature of liquid
d) difference in surface tension of liquids

31. Fin fan air coolers use following method of heat transfer.

a) conduction
b) convection
c) radiation
d) none of above

32. The pressure drop of liquid in pipe in turbulent flow is

a) proportional to velocity
b) proportional to square of velocity
c) proportional to temperature of liquid
d) none of above

33. Double contact double absorption process is used for manufacture of

a) nitric acid
b) acetic acid
c) nitrous acid
d) sulfuric acid

34. The positive isolation means

a) isolation using blinds or spades


b) isolation with valve without tagging
c) isolation with valves with tagging
d) positively isolating two valves

35. Cavitation can be prevented by

a) suitably designing the pump


b) maintain the suction head sufficiently grater than the vapour pressure.
c) Maintain the suction head = developed head
d) Maintain the suction head lower than the vapour pressure.

36. The valve used for very accurate control of fluid is

a) needle valve
b) globe valve
c) gate valve
d) butterfly valve

37. LPG stand for

a) liquid petroleum gas


b) liquefied petrol gas
c) liquid petrol gas
d) liquefied petroleum gas

5 of 7
38. Check valves are used

a) at high pressure
b) in bends
c) for controlling water flow
d) for unidirectional flow

39. Cracking is a

a) exothermic reaction
b) endothermic reaction
c) favored at very low temperatures
d) none of these

40. Which has the highest flash point of all

a) diesel
b) kerosene
c) petrol
d) furnace oil

41. What is the reflux ratio at total reflux

a) zero
b) infinity
c) unity
d) data insufficient

42 Surging is caused by

a) high suction pressure


b) high gas flow rates
c) discharge pressure higher than system pressure
d) system pressure is higher than discharge pressure

43. Compressors are connected in series to increase


a) capacity
b) pressure
c) both a & b
d) none of above

44. Which of the following could be an indication of bad seals ?

a) Low oil level in reservoir


b) Oil leaks
c) Decrease in compressor capacity
d) All the above

45. Most economic and realistic maintenance practice of today is

a) Corrective maintenance
b) Predictive maintenance
c) Preventive maintenance
d) Breakdown maintenance

6 of 7
46. In Electrochemical Corrosion, dissolution/oxidation reaction occurs at…..

a) Cathode
b) Anode
c) Electrolyte
d) None of the above

47. Units of measurement of mechanical vibration is/are

a) mm
b) cm/sec
c) ‘g’ unit
d) mm/sec

48. A liquid which is three times heavier than water has a specific gravity of

a) 1.5
b) 2
c) 3
d) 4.5

49. Absolute pressure is

a) Guage pressure + 1
b) Guage pressure – 1
c) Atmosheric pressure +1
d) Atmospheric pressure – 1

50. Normally in a high pressure system, Pressure control valve is

a) Fail open
b) Fail close
c) Fail in position
d) None

*************************************

7 of 7

Das könnte Ihnen auch gefallen