Purpose
‘Ths Term nat on Un tis the ntertace between the
f ed wring from RTD sensors and one or two Ana og
Save Modu es (NASMO3)
Description
‘The NTA 03 Term nat on Unt s shown nF gure
Installation
Pease refer to the Term nat on Un t and Cabe
nsta aton secton of ths manua for comp ete
instruct ons for nsta_ng ths Termnat on Unt
TABLE 1
NTAIO3
Res stance Temperature Detector
Inputs (RTD)
Additional Cable Installation Procedures
addition to the standard Term nat on Un t Cab
ng procedures (see the Term nat on Un t and Cab e
sta at on sect on of this manua ), the P2 socket con
nects the Term nat on Un t to a second Ana og S ave
Modu e if so des red F gure 2 shows the cab e con
ect on between the NTAIO3 Term nat on Un tand the
NASMO3 Analog S ave Modu e
Th s TU provides a socket for ca bratng as ave
module by the master See the Analog Master Module
— NAMMO02 — Calibration Guide (Product Instruction
Supplement — IS-£93-912-2) for deta s
NTAIO3 Application Summary
foekuE
ANALOG SLAVE
MODULE NASMO3
NKTUOT
RTD nputs
100 Ohm
and Pat num RTD
16NTAIO3
Res stance Se ect
‘Switch (for calbrat on)
£1 Shed for P1
P1 Socket for NKTUOT Cab @
to NASMO3
£3 Shed for PS
2 Common
F125 Amp Fuse
P3. Socket for Ga brat on
4 4 24V de
P2 Socket for NKTU1 Cab e
to NASMO3
&5 Shed
140.
Term na Locat on
‘Typ.ca Connect on of an
RTD to an NTAO3 pat
A
FIGURE 1 NTAI03 Termination Unit and Ternunal AssignmentsNTAIO3
NTAOS
PS Connector
RKTUOT
NKTUOT
P3 Connector
=
5
NS
NASMOS
CAL BRAT ON
FIGURE 2
NTAOS
P3 Congector
NASMOS
E51 594,
WASMOS
\
]
TPes1398,
Cable Connections for the NTAIO3