Beruflich Dokumente
Kultur Dokumente
, LTD
Y12E AIRCRAFT
MAINTENANCE MANUAL
MAINTENANCE PRACTICE -
1 Equipment Required
Indicating light.
None.
None.
None.
2 Preparation
3 Operation
b) Remove 4 screws (6) from the fire-extinguisher, and then remove the
fire-extinguisher and cover and tie the tube fitting properly to prevent foreign
objects from falling into the tube.
26-21-00
Nov. 30/2013 Page 201
HARBIN AVIATION INDUSTRY CO., LTD
Y12E AIRCRAFT
MAINTENANCE MANUAL
c) Plug the airborne detonation cap connector to the locking mechanism of the
firing-extinguisher.
d) Secure tightly the bonding wire with screws and gaskets (7).
3.3 Electrically operational test on engine nacelle fire extinguishing system (see Fig.2).
b) Plug in the external power plug and turn on the battery external power supply
switch.
c) Turn on extinguisher detonation cap switch (59Q) or (60Q), and check the circuit
of fire-extinguishing system with the indicating light, and check the isolating
diodes (55Q, 56Q, 57Q and 58Q) in the circuit for break and short-circuit.
e) Turn off the power supply and plug off the external power supply plug.
f) Secure the airborne detonation cap connector tightly on the locking mechanism of
the firing-extinguisher.
26-21-00
Nov. 30/2013 Page 202
HARBIN AVIATION INDUSTRY CO., LTD
Y12E AIRCRAFT
MAINTENANCE MANUAL
3.4.1 Weigh the fire extinguisher, and check the cause and replenish the
fire-extinguishant and nitrogen if the weight reduction of the extinguisher found is
10% or more of the weight marked on the placard attached to it.
3.4.2 Inspect the pressure value indicated on the fire extinguisher pressure gauge for the
compliance with the requirements of following table:
(oF )
Pressure Mpa 3.2 3.4 3.6 3.8 4.0 4.2 4.4 4.6 4.8
(Psi)
(455.15) (483.59) (512.04) (540.49) (568.93) (597.38) (625.83) (654.27) (682.72)
The fire extinguisher must be removed and repaired or replaced if the pressure
reduction is lower than 6% or more of the listed value in the table.
3.4.3 Check the pipeline and components of the fire-extinguisher system for wear,
scratch, deformation and blockage, check the installations for security and wire
attachments for security and wire insulations for intactness.
4 Final Procedure
4.1 Close the lower fairing of engine nacelle, and secure it tightly.
4.2 Check the tools for missing and clean the working area.
26-21-00
Nov. 30/2013 Page 203
HARBIN AVIATION INDUSTRY CO., LTD
Y12E AIRCRAFT
MAINTENANCE MANUAL
1 Screw, nut and washer; 2 Fire-extinguishing nozzle; 3 Nut; 4 Flat tube nozzle;
5 Fire-extinguishing tube; 6 Screw, washer and nut; 7 Screw, washer;8 Bonding wire;
9 Fire extinguisher; 10 Support; 11 Screw, washer and nut; 12 Bracket;
26-21-00
Nov. 30/2013 Page 204