Beruflich Dokumente
Kultur Dokumente
1. Add frame:
/* command: frame add frameid frametype
/* Some frametypes possibly used in Quangninh:
/* 4: RSP_10 (HGB) /* control card is RSP
/* 2: RSP_14 (HIB) /* control card is RSP
/* 11: PV8_10 (HGB) /* control card is PV8
/* 9: PV8_14 (HIB) /* control card is PV8
E.g : add frame id=50, frametype=4 (frame RSP_10 HGB)
MD5500(config)#frame add 50 4
3. Add boards
/* command: board add frameid/slotid boardname
E.g: add ASL 32 ports in frame 50 at slot 3
MD5500(config)#board add 50/3 a32
4. Confirm boards
/* after boards added, they are to be confirmed.
/* command: board confirm frameid/slotid
/* if only frameid entered, all the cards in frame are confirmed
E.g: confirm boards at slot 3 in frame 50
MD5500(config)#board confirm 50/3
----------------------------------------------------------------------
SlotID BoardName Status Sub0 Sub1 Sub2 Sub3
----------------------------------------------------------------------
0
1 PWX3 Normal
2 TSS Normal
3 A32 Normal
4 A32 Normal
5 A32 Normal
6 A32 Normal
7 A32 Normal
8
9 RSP Normal
10 RSP Normal
11 A32 Normal
12 A32 Normal
13 A32 Normal
14 A32 Normal
15 A32 Normal
16 A32 Normal
17
----------------------------------------------------------------------
/* in table above the frame is RSP_10 (HGB), TSS card is always in slot
2,
/* slot 8 is empty (normally used for HW card)
6. Add subscribers
/* enter menu "narrow user"
MD5500(config)#narrow user
/* on screen displayed:
/* MD5500(config-narrow-user)#
/* command to add sub.: pstnuser add framid/slotid/portid v5Id L3Add
telno {telno}
E.g: create a subscriber for port 0, in frame 50 at slot 3, v5id =100,
L3Address=10,
tel. number =801210 (this number is used only for easy management)
Note: When adding subscriber, parameter "telno" in fact is used only for
management.
"telno" and "l3 address" should be the same in both LE and Honet
/* display again
MD5500(config-narrow-user)#show pstnport attribute 9/3/0
-----------------------------------------------------------------------
Frame/Slot/Port Gain(db) Pulse-Dial Polarity-Reverse
-----------------------------------------------------------------------
9 / 3 / 0 High gain Enabled Not supported
-----------------------------------------------------------------------