Beruflich Dokumente
Kultur Dokumente
2009-03-09
7. Press button of <COPY IMAGES FROM SD TO NAND FLASH> and wait for
the flashing light to go green. Usually it will take 3-4 minutes to program a unit.
8. When you see the screen below the loading of boot files is successful.
03. Known issues with this Release
If you get this screen then you must reset the power to the device by turning the power
supply on and off.
The above screen means that the program connected to the Solstice Board but failed to
recognize the SD Card.
04. Troubleshooting
In order to troubleshoot, please Press the COMCHECK button.
If you get this message:
Check if all the cables are connected and whether you are in programming mode, because
the program was unable to find the Solstice board.