Beruflich Dokumente
Kultur Dokumente
by kgopal2
4.PCB
7.Bunch of wires
The battery pack is a 12v 1200mAh made out of three lithium polymer cells each having a voltage of approximately
4 volt.
First all three cells are glued together and then all of them are connected in series.
These battery pack consists of 3 sub-packs of 3-3 cells which makes 3 packs of 12volts connected in parallel.
This Circuit diagram shows the connection for making a 12v battery level indicator.
Cut a rectangular socket from the ATX casing to fir the 3 pin socket as shown in the picture.
I made a fitting of the circuit by insulating the back part of the circuit to prevent short circuit because if the soldering
joints of inverter circuit touches the ATX casing then it may cause a Electric shock or even a short circuit.
A short circuit may be dangerous and even cause fire in the batteries.
Connecting the battery terminals with a switch before connecting to the circuit to prevent battery heating during
standby.
Fitting the battery inside the ATX was a tricky stuff to do. The room space was really low after fitting the inverter
circuit and the indicator.
And due to 3 pin socket, the room for the battery pack was really low.
Connecting the battery charger with a switch is the last step for this project.
CHEERS!!!
It can run small table fans, CFLs, LED bulbs, Phone Chargers etc.