Beruflich Dokumente
Kultur Dokumente
Which system uses a laser light beam In all standard television broadcast Monochrome picture - chroma
for playback? channels, the difference between the amplifier off
which is not tuned to 3.58 MHz? Color oscillator feeds this - color
a. video preamplifier demodulators Channel 4 (66-72 MHz) transmitted -
b. chroma amplifier 267.25 MHz carrier freq. 69.25
c. burst amplifier Drafting color bars in the picture MHz upper side freq.
d. color demodulator input indicate trouble in the Y
a. AFPC for color oscillator What is the contrast of picture?
Not tuned to 3.5 MHz - video b. Chroma BPA a. video amplifier
preamplifier c. Color killer b. composite video
d. Y video amplifier c. BPA chroma
The contrast control is in the _______ d. BPA
a. Y video amplifier Drafting color bars trouble - AFPC for
b. chroma amplifier color oscillator Contrast of picture - video amplifier
c. color killer
d. delay line The beat frequency between the 3.58- What is the audio signal output?
MHz color subcarrier and the 4.5-MHz a. FM detector
Contrast control - Y video amplifier sound signal is b. AFPC
a. 0.92 MHz c. AGC
The color level control is in the
a. BPA
b. 3.58 MHz d. Demodulator
c. 4.8 MHz
b. AFPC d. 4.5 MHz Audio signal output - FM detector
c. Demodulator
d. G-Y amplifier Beat freq bet 3.58 MHz and 4.5MHz - What is the gain control of RF and IF?
0.92 a. AGC
Color level control – BPA b. AFPC
Which control varies the phase angle
The color oscillator does not operate. of the demodulated color video c. Modulator
The trouble is signal? d. demodulator
a. no color a. tint
b. incorrect hues b. color level Gain control of RF and IF – AGC
c. excessive confetti c. drive
d. no picture d. picture IF conversion is...
a. Mixer
Color oscillator malfunction - no color Varies phase angle –tint b. Modulator
Which of the following stages must be c. Demodulator
The balance for Y video signals to the on during horizontal flyback time? d. AGC
three guns in the picture tube is set a. burst separator
by the IF conversion - mixer
b. Y video filter
a. drive controls c. chroma BPA
b. screen controls Help's the synchronization of picture..
d. R-Y video amplifier
c. tint control a. Sync separator
d. contrast control On stage during horizontal flyback - b. AGC
burst separator c. AFPC
Sets Y video signal balance - drive
controls
d. Modulator
Which of the following stages has bias
from the ACC and color-killer circuits? Synchronization of picture - sync
a. chroma BPA separator
b. R-Y demodulator
c. R-Y video amplifier Brightness of raster
Which signal needs a 0.8 us time d. color oscillator
delay? a. high-voltage supply
a. Y video Has bias from ACC - chroma BPA
b. low-voltage supply
b. 3.58-MHz chroma c. modulator
c. B-Y video d. AGC
d. color burst A crystal-ringer circuit is used for the
a. AFPC on color oscillator Brightness of raster - high-voltage
Needs 0.8 us time delay - Y video b. Y video amplifier supply
c. color demodulators
The output of the burst separator d. chroma BPA
feeds the Dc electrode voltages
a. AFPC for color oscillator Uses crystal-ringer circuit - AFPC on a. low-voltage supply
b. color demodulators color oscillator b. high-voltage supply
c. G-Y adder c. modulator
d. Y video amplifier With a 2 MHz video signal modulating d. demodulator
the picture carrier signal9for channel
Burst separators feed - AFPC for 4(66-72 MHz), which of the ff. Dc electrode voltages - low-voltage
color oscillator frequencies area transmitted? supply
a. 267.25 MHz carrier freq. Problems in TV snowy picture the
The output of the color oscillator feeds 69.25 MHz upper side freq.
the cause is
a. color demodulators b. 66 MHz carrier freq. 68 MHz a. RF amplifier
b. chroma BPA upper side freq. b. Local oscillator
c. picture tube c. 71.75 MHz carrier freq. 69- c. IF amplifier
d. burst separator 73 MHz side freq. d. Modulator
d. 367.25 MHz carrier freq.
65.25-69.25 MHz side freq. Snowy picture - RF amplifier
c. Weak signal causes the
Adjacent-channel selectivity picture look small or thin
a. IF wave traps d. Strong signal causes the
b. IF amplifier picture look small or thin
c. pre-amplifier
d. demodulator True - Weak signal cause snow in
the picture
Adjacent channel selectivity - IF
wave traps The upstream signal in two-way cable
systems has the freq. of
Baseband video signal a. 5 to 30 MHz
a. video detector
b. video heads b. 10 to 25 MHz
c. capstan c. 10 to 100 MHz
d. AGC d. 8 to 20 MHz
Baseband video signal - video
upstream signal in two-way cable -5
detector
to 30 MHz
Which of the ff. is a midband cable TV
channel is
A typical value for the IF signal, in
a. A or 14
megahertz for up-down cable
b. B or 14
converter is
c. B or 15
a. 612.754
d. A or 15
b. 625.25
c. 675.25
Midband cable TV - A or 14
d. 630.25
Coaxial cable for distribution systems
Typical IF signal up-down converter -
has an impedance of
612.75
a. 150 ohms
b. 100 ohms
Frequency synthesis is used for the
c. 75 ohms
a. VCO in the up-converter
d. 120 ohms
b. VCO in the mid-converter
c. VCO in the down-converter
Coax cable impedance - 150 ohms
d. none of these
The cable converter output for the TV
Frequency synthesis - VCO in the
receiver is usually on channel
up-converter
a. 3
b. 4
For in-band descramblers, the
c. 7
decoding pulses are sent on the
d. 2
a. sound carrier
b. video carrier
Cable converter TV – channel 3
c. sound and video carrier
d. none of these
A tap for the subscriber drop line has
a
In-band descramblers are sent -
a. high tap loss sound carrier
b. low tap loss
c. moderate tap loss A trunk cable run has a loss of -20
d. zero tap loss dBmv. To make up for thi9this loss,
the voltage gain of the next amplifier
Tap subscriber drop line - high tap should at least be
loss a. 10
b. 20
c. 5
d. 30